User's Manual
Table Of Contents
- Section 1 Introduction
- 1.1 Purpose of This Manual
- 1.2 General Description
- 1.3 General Specifications
- Section 2 Installation / Initial Turn-On
- 2.1 Introduction
- 2.2 Installation Checkboxes
- 2.3 Transmitter Cabinet Placement
- 2.4 Transmitter AC Connection
- 2.5 Signal and Ground Connections
- 2.6 Interlock Connections
- 2.7 3 Port Patch Panel
- 2.8 Motorized RF Switch Connections
- 2.9 Install PA and PS Modules
- 2.10 Initial Turn-On
- 2.11 Parallel Remote Control Connections
- 2.12 Remote Status Outputs, J15 & J16
- Section 3 Operation/ Adjustments
- 3.1 Introduction
- 3.2 Transmitter Control Panel
- 3.3 Graphical User Interface (GUI)
- 3.4 GUI Home Page
- 3.5 Drive Chain Main Menu
- 3.6 Power Amp Main Menu
- 3.7 Output Main Menu
- 3.8 Power Supply Main Menu
- 3.9 System Main Menu
- 3.10 GUI Menu Structures
- Section 4 Theory of Operation
- 4.1 Introduction
- 4.2 Block Diagram Descriptions
- 4.3 Transmitter Control System
- 4.4 Transmitter RF System
- 4.5 Power Supplies
- Section 5 Replacement Procedures
- 5.1 Introduction
- 5.2 PA Module Removal
- 5.3 PA Module Pallet Replacement
- 5.4 Power Supply Module Replacement
- 5.5 Circulator Removal/Replacement
- 5.6 Blower Assembly Removal
- Section 6 ISP (In-System Programming)
- 6.1 Introduction
- 6.2 Installing the ISP Program
- 6.3 ISP Procedures
- Section 7 Parts List
- 7.1 Parts List Index
10/19/07 888-2687-001 7-9
WARNING: Disconnect primary power prior to servicing.
Section 7 Parts List
Ranger ™ Mobile Series
610 1145 000 HDR, 6PIN, 1ROW, STRT,POL 1.0 EA J6
610 1367 000 HDR, 16C 1ROW STRAIGHT 1.0 EA J10
612 1227 000 RCPT, 9 PIN D PC MT 1.0 EA J12
817 2570 014 SW/FW, RANGER_PSM 0.0 EA
992 7203 001 PWA, 376 MICRO MODULE 1.0 EA
992 7255 101 *PWA, PS MONITOR, SMT 1.0 EA
Table 7-11 PWA, 376 MICRO MODULE - 992 7203 001
Harris PN Description Qty UM Reference Designators (J)
381 0029 000 N-MOSFET, 2N7002 SMT ESD 3.0 EA Q1 Q2 Q3
383 0126 000 *IC MAX705/ADM705 ESD 1.0 EAU7
383 0166 000 IC, 71024/7C109/6226 ESD 2.0 EA U5 U6
383 0277 001 IC LM4040CIM3-4.1 ESD 1.0 EA CR2
383 0426 000 IC NC7ST04 ESD 1.0 EA U1
385 0012 000 DIODE, SCHOTTKY MBR0520 ESD 1.0 EA CR1
389 0010 001 LED, RED, 1.4MM RECT ESD 1.0 EA DS2
389 0010 002 LED, GRN, 1.4MM RECT ESD 1.0 EA DS1
393 0050 000 IC, MC68376 PROG/ESD 1.0 EA U2
393 0063 000 EEPROM, 25C040 PROG/ESD 1.0 EA U3
393 0077 000 IC AM29F800BB PROG/ESD 1.0 EA U4
445 0008 000 XTAL 4.194304 MHZ SMT 1.0 EA Y1
496 0059 000 IND CHIP 1UH 10% 3.0 EA L1 L2 L3
515 0134 111 CAP 27PF 100V 5% 0805 C0G 2.0 EA C25 C26
515 0137 501 CAP 0.1UF 50V 10% 1206 X7R 22.0 EA C4 C5 C6 C7 C8 C9 C10 C11 C13 C14
C16 C17 C18 C19 C20 C21 C22 C23 C24
C27.C28 C29
526 0383 000 CAP 10UF 10V 10% 6032 5.0 EA C1 C2 C3 C12 C15
540 1568 000 RES NETWORK, 10K OHM 5% SMT 5.0 EA R13 R14 R17 R25 R26
545 0308 109 RES 22.1 OHM 1% 0.1W 0805 11.0 EA R1 R2 R3 R6 R7 R8 R15 R16 R19 R20
R22
545 0308 201 RES 100 OHM 1% 0.1W 0805 1.0 EA R29
545 0308 208 RES 200 OHM 1% 0.1W 0805 1.0 EA R10
545 0308 301 RES 1K OHM 1% 0.1W 0805 5.0 EA R4 R9 R12 R18 R21
545 0308 305 RES 1.5K OHM 1% 0.1W 0805 1.0 EA R28
545 0308 306 RES 1.62K OHM 1% 0.1W 0805 1.0 EA R11
545 0308 401 RES 10K OHM 1% 0.1W 0805 1.0 EA R23
545 0308 408 RES 20K OHM 1% 0.1W 0805 1.0 EA R24
545 0308 601 RES 1MEG OHM 1% 0.1W 0805 1.0 EA R27
545 0308 999 RES ZERO OHM JUMPER 0805 1.0 EA R5
604 1163 000 SWITCH, PB, SPST MOM, SMT 1.0 EA S1
610 1369 004 PLUG, 80C 2 ROW VERTICAL 2.0 EA J1 J2
843 5522 000 SPEC, 376 MICRO MODULE 0.0 EA
843 5522 001 SCH, 376 MICR0 MODULE 0.0 EA
843 5522 003 PWB, 376 MICRO MODULE 1.0 EA
Table 7-12 *PWA, PS MONITOR, SMT - 992 7255 101
Harris PN Description Qty UM Reference Designators (D)
000 0000 010 B/M NOTE: 144.0 EA DO NOT POPULATE C13 C39 C45 C57
C73 C78 C79 C80 C81 C82 C83 C84 C88
C113 C119 C122 C130 C131 C133 C134
C135 C136 CR29 CR30 DS20 DS21 DS22
DS32 DS33 DS34 DS37 DS38 Q14 R32
R33 R34 R52 R53 R61 R63 R66 R67 R68
R69 R70 R79 R106 R153 R154 R155
R167 R168 R169 R170 R171 R172 R173