No,∶ PSDS001A Edition∶ PRODUCT SAFETY DATA sHEET FOR CARBON ZINC BATTEItrEs (R03,R6,R14&F田 0) T。 G B狨 tery Co。 (ChinO Limited ¨ ˉ ^Iˉ Checke了 Drafted T奶 9.
Page 1 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Revision: 9.2 Date of prepared: 26th May 2015 Please follow the warnings and precautions listed below to avoid possible hazards from the improper uses of Carbon Zinc Batteries and to ensure correct and safe use of them. The following notes should be put in an appropriate and effective location in each end‐use product and its instruction manual.
Page 2 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Date of prepared: 26th May 2015 Revision: 9.2 Under normal conditions of use, the battery is hermetically sealed. If the electrolyte is leaked, hazardous material may be released. Human Health Effects Inhalation The electrolyte inhalation can cause respiratory irritation. Skin contact The electrolyte can cause skin irritation, chemical burns.
Page 3 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Revision: 9.2 Date of prepared: 26th May 2015 Section IV – First‐aid Measures None unless internal materials exposure. If contents are leaked out, observe following instructions. Inhalation If electrolyte leakage occurs, provide fresh air and seek medical attention. Skin Contact If liquid solution from the battery comes out and contact with skin or clothes, flush out with clean water.
Page 4 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Revision: 9.2 Date of prepared: 26th May 2015 Section VII – Handling and Storage Handling Never swallow. Never touch the liquid leaked out of battery. Never short‐circuit the battery. Never charge. Never expose to open flame. Never heat. Never disassemble or deform. 1) Keep the battery out of reach of babies or small children.
Page 5 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A 5mg/m3 TWA PNOR 3mg/m3 TWA PNOC ( respirable fraction ) ( respirable particulate) 1mg/m3 TWA (fume) Zinc Chloride None established Ammonium Chloride Acetylene Black Date of prepared: 26th May 2015 Revision: 9.2 1mg/m3 TWA (fume) 2mg/m3 STEL (fume) 10mg/m3 TWA (fume) 20mg/m3 STEL (fume) 3.5mg/m3 TWA (as carbon black) 3.
Page 6 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Revision: 9.2 Evaporation rate Flammability (solid, gas) N.A. N.A. Date of prepared: 26th May 2015 Upper/lower flammability or explosive limits N.A. Vapor pressure Vapor density N.A. N.A. Relative density Solubility N.A. N.A. Partition coefficient: n‐octanol/water Auto‐ignition temperature N.A. N.A. Decomposition temperature Viscosity N.A. N.A.
Page 7 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Revision: 9.2 Date of prepared: 26th May 2015 Persistence/degradability : Since a battery cell and the internal materials remain in the environment, do not bury or throw out into the environment. Section XIII – Disposal Considerations The battery may be regulated by national or local laws/ regulations. Please follow the instructions of proper regulation.
Page 8 of 8 Safety Data Sheet for Carbon Zinc Battery Document Number: PSDS001A Form of UN No. Transportation Date of prepared: 26th May 2015 Revision: 9.2 US DOT 49 CFR 172.102 Provision 130 IATA A123 ICAO Not regulated UN Proper Transport Packing Shipping Name Hazard Class Group Environmental Guidance Hazards N.A. N.A. N.A. N.A. Transport in Precaution bulk Number N.A. Special N.A. N.A. N.A.
