User Manual

ManualsBrandsGE ManualsCommercial Air ConditionersGE Zoneline® Heat Pump Unit with ICR, 230/208 Volt - AZ65H12DAD

49-7756 02-16 GE

Air Conditioners

AZ45

AZ65

Owner’s Manual and

Installation Instructions

Write the model and serial

numbers here:

Model # ___________________

Serial # ____________________

Find these numbers on a label

behind the room cover on the

base pan.

Zoneline

Safety Instructions ...........2-4

Operating Instructions

Controls ...........................5

Air Direction. . . . . . . . . . . . . . . . . . . . . . . . 6

To Remove the Room Cover ........6

Ventilation Control .................6

Auxiliary Controls ...............7-11

Remote Thermostat ...............11

Care and Cleaning

Base Pan .........................12

Outdoor Coils .....................12

Room Cover and Case .............12

Ventilation Filter ...................12

Air Filters .........................13

Installation Instructions

Preparation .......................14

Replacing an Existing Unit .........15

Electrical Connection ...........16-18

Installing the Zoneline .........19, 20

Optional Drain Kit .................21

Troubleshooting Tips .....22, 23

Normal Operating Sounds .........24

Consumer Support

Ownership Registration ........25, 26

Warranty .........................27

Consumer Support ........Back Cover

Español

For a Spanish version of this

manual, visit our Website at

www.zoneline.com.

Para consultar una version

en español de este manual

de instrucciones, visite nuestro

sitio de internet

www.zoneline.com.

Français

For a French version of this

manual, visit our Website at

www.zoneline.com.

Pour un version français de

ce manuel d’utilisation, veuillez

visiter notre site web à l’adresse

www.zoneline.com.

Summary of content (28 pages)

PAGE 1
Air Conditioners ® Zoneline Safety Instructions . . . . . . . . . . . 2-4 Operating Instructions Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Air Direction. . . . . . . . . . . . . . . . . . . . . . . . 6 To Remove the Room Cover . . . . . . . . 6 Ventilation Control . . . . . . . . . . . . . . . . . 6 Auxiliary Controls . . . . . . . . . . . . . . . 7-11 Remote Thermostat . . . . . . . . . . . . . . . 11 Care and Cleaning Base Pan . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 2
IMPORTANT SAFETY INFORMATION READ ALL INSTRUCTIONS BEFORE USING SAFETY INFORMATION This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert symbol and the word “DANGER”, “WARNING”, or “CAUTION”. These words are defined as: DANGER Indicates a hazardous situation which, if not avoided, will result in death or serious injury.
PAGE 3
CONSIGNES DE SÉCURITÉ IMPORTANTES LISEZ TOUTES LES INSTRUCTIONS AVANT L’UTILISATION SAFETY INFORMATION Ce symbole représente une alerte de sécurité. Ce symbole vous avise de dangers potentiels pouvant causer, à vous ou autrui, des blessures graves ou fatales. Tous les messages de sécurité seront précédés du symbole d’alerte de sécurité ainsi que des mots « DANGER », « AVERTISSEMENT » ou « ATTENTION ».
PAGE 4
INFORMACIÓN IMPORTANTE DE SEGURIDAD LEA TODAS LAS INSTRUCCIONES ANTES DE USAR INFORMACIÓN DE SEGURIDAD Éste es el símbolo de alerta de seguridad. El mismo alerta sobre potenciales riesgos de muerte o lesiones tanto para usted con para otras personas. Todos los mensajes de seguridad estarán a continuación del símbolo de alerta de seguridad y con la palabra “PELIGRO”, “ADVERTENCIA” o “PRECAUCIÓN”.
PAGE 5
About the controls on your Zoneline Controls Temp Control The temp control is used to maintain the room temperature. The system will cycle on and off to keep the room at the same level of comfort. Press the + pad to raise the temperature. Press the - pad to lower the temperature. NOTE: The display shows the set temperature, not the room temperature. Fan, Mode and Operation Control )$1³Sets the fan operation for HIGH or LOW.
PAGE 6
Other features of your Zoneline To Remove the Room Front Additional controls are located behind the room cover. To remove: Pull out at the bottom to release it from the holding tabs on the sides (1). Then lift up (2). To replace: Align and place the top rail of the room cover over the chassis (1). Push inward at the bottom until it snaps into place (2). Air Direction To change the air direction, remove the room cover. Remove the 4 louver screws that hold the louver insert in place.
PAGE 7
Auxiliary controls on your Zoneline $X[LOLDU\ &RQWUROV³$X[ 6HW %XWWRQ While the unit is preset to what most customers prefer, the auxiliary controls located behind the room cover, below the control panel. Red Aux Set Button Remove the room cover. See the To Remove the Room Cover section. If the owner modifies the auxiliary controls it is then the owner is responsible for ensuring the auxiliary controls are set to the desired function.
PAGE 8
Auxiliary controls on your Zoneline MODE 2 Fahrenheit / Celsius This feature allows the individual to switch the temperature units between Fahrenheit and Celsius on the display. Press MODE until a 2 appears in the first digit of the display for Fahrenheit/Celsius mode. °F °C Press the - pad to select Celsius or the + pad to select Fahrenheit. The individual will see an F for Fahrenheit or a C for Celsius in the second digit of the display based on the selection.
PAGE 9
Auxiliary controls on your Zoneline MODE 5 Temperature Limiting Temperature limiting is a feature that reduces energy costs by limiting the lowest temperature that can be obtained in cooling and the highest temperature that can be obtained in heating. Press MODE until a 5 appears in the first digit of the display for Temperature Limiting cool mode. The COOL LED light on the main control will be lit. To change to heat mode, press MODE again and the HEAT LED light on the main control will be lit.
PAGE 10
Auxiliary controls on your Zoneline MODE 8 All-Electric Heat (AZ65 only) This electric heat option functions only on the AZ65 model. When this option is ON “ ,” heat pump operation is locked out, causing the unit to provide only electric resistance heat. To set All-Electric Heat option, press MODE until an 8 appears in the first digit of the display. Press the + or - pad to set this switch to OFF “ “ or ON “ .” This is shown in the second digit of the display.
PAGE 11
Auxiliary controls on your Zoneline CDC Switch External Fan (Field Installed) R When connected, an auxiliary or external fan can be controlled with the indoor fan motor on the Zoneline. Connections provide 24 V AC to energize a remote relay. CDC E. Fan The RAKCDC accessory must be used when using an external fan. Central Desk Control (Field Supplied) R The Central Desk Control is a feature that allows the unit to be made operable/inoperable from a remote location.
PAGE 12
Operating Instructions Make Up Air Models (not on all units)) The make-up air ventilation system is designed to condition air cycled through the vent door and into the room. In addition to providing fresh air, it dehumidifies incoming air when it is above 55% relative humidity. The make-up air ventilation system is operated by a switch located on the front of the electrical control cover under the Zoneline room front.
PAGE 13
Care and cleaning Ventilation Filter If the vent door is open, clean the vent filter twice a year or as required. Access requires the removal of the unit from the wall sleeve. Turn the Zoneline off and unplug before removing and cleaning. To clean the vent filter: IMPORTANT: This filter is not removable. Trying to remove this filter will damage the unit. ■ Use a vacuum to remove debris from the filter. ■ Use a damp rag to wipe down the filter and surrounding area after vacuuming.
PAGE 14
Installation Instructions Zoneline Air Conditioners Questions? Call 844-GE4-PTAC (or 844-434-7822 ) or Visit our Website at: GEAppliances.com BEFORE YOU BEGIN Read these instructions completely and carefully. • IMPORTANT – Save these instructions for local inspector’s use. • IMPORTANT – Observe all governing codes and ordinances. • Note to Installer – Be sure to leave these • Note to Owner – Keep these instructions for instructions with the owner. future reference.
PAGE 15
Installation Instructions REPLACING AN EXISTING UNIT Check the “Essential Elements” label for important information. Replacing a ducted unit New ducted installation: If this unit is to be installed in a new ducted application using a duct adapter kit, the kit must be installed before the unit is placed in the wall case. The installation instructions are packed with the kit.
PAGE 16
Installation Instructions 230/208 VOLT ELECTRICAL CONNECTION OPTIONS POWER CORD CONNECTION Depending on application, a power supply kit with LCDI must be used to supply power to the Zoneline unit. The appropriate kit is determined by the voltage, the means of electrical connection and the amperage of the branch circuit. Power cords may include an arc fault interruption or a leakage current detection interruption device. A test and reset button is provided on the plug case or the inline case.
PAGE 17
Installation Instructions 265 VOLT ELECTRICAL CONNECTION OPTIONS WARNING Connection of this 265 V AC product to a branch circuit MUST be done by direct connection in accordance with the National Electrical Code. Plugging this unit into a building-mounted exposed receptacle is not permitted by code. These models must be installed using the appropriate GE power supply kit for the branch circuit amperage and the electrical resistance heater wattage desired.
PAGE 18
Installation Instructions POWER CONNECTION CHART Power Cord Connections 230/208 Volt Power Supply Kits with Current Leakage Detection Device (1) RAK315P/SP RAK320P/SP RAK330P/SP Wall Plug &RQ¿JHUDWLRQ Tandem Perpendicular Large Tandem Circuit Protective Device 15-Amp Time-Delay Fuse or Breaker 20-Amp Time-Delay Fuse or Breaker 30-Amp Time-Delay Fuse or Breaker Heater Wattage @ 230/208 Volts 2.40/1.96 KW 3.40/2.78 KW 4.80/3.93 KW (High Fan) 3.80/3.
PAGE 19
Installation Instructions INSTALLING THE ZONELINE 1. INSTALL THE WALL CASE AND EXTERIOR GRILLE The RAB71A/B series or RAB77A4/77B wall case must be properly installed per instructions packed with the case. • Remove the corrugated stiffener and the outdoor protective panel. Use the slit in the outdoor panel as a handhold and push out. Protective panel 2. PREPARE THE UNIT • Carefully remove the foam shipping blocks from the room front, compressor and outdoor fan.
PAGE 20
Installation Instructions INSTALLING THE ZONELINE (cont.) 3. INSTALL THE UNIT INTO THE WALL CASE Slide the unit into the wall case and secure with four screws through the unit flange holes. The four screws will be located in a sealed bag that sits under the control panel, sitting in the pocket in the basepan. The four wall case screws will be taped to the pocket in front of the control box. NOTE: There are several extra holes in the unit side flanges for installation in wall cases other than GE.
PAGE 21
Installation Instructions 237,21$/³'5$,1 .,7 ,167$//$7,21 Dry Air 25 Series models are designed to improve dehumidification by 25%. Since more moisture will be removed from the air, there is a greater possibility that water will drip from the wall case than with a standard unit. To prevent this water from dripping onto external building walls, we recommend the use of RAD10 Drain Kit. External Drain See the Installation Instructions in the RAD10 kit. Alternate: 6” long, 1/2” O.D.
PAGE 22
Before you call for service Troubleshooting Tips Save time and money! Review the charts on the following pages first and you may not need to call for service. Problem Possible Causes What To Do Zoneline does not start The unit is unplugged. • Make sure the Zoneline plug is pushed completely into the outlet. The power cord is not firmly attached. • Remove the room cover and make sure that the black connector on the end of the power cord is firmly engaged. The fuse is blown/circuit breaker is tripped.
PAGE 23
Problem Possible Causes What To Do The air is not always cool or hot during operation The heat pump is not producing hot air. • This is normal. The heat pump will produce warm air but not as hot as air produced when the higher-cost electric heat is used. The Smart Fan Auxiliary Controls may be set to continuous fan. • This causes the fan to blow room temperature air even when the compressor or heater cycles off. The continuous air movement provides better overall temperature control in the cool mode.
PAGE 24
Things that are normal Normal Operating Sounds You may hear a pinging noise caused by water being picked up and thrown against the condenser on rainy days or when the humidity is high. This design feature helps remove moisture and improve efficiency. “CLICK” You may hear relays click when the controls cycle on and off or are adjusted to change the room temperature. Water will collect in the base pan during high humidity or on rainy days. The water may overflow and drip from the outdoor side of the unit.
PAGE 25
Product Registration Follow these three steps to protect your new appliance investment: Complete and mail your After mailing the registration Consumer Production below, store this document in a Registration today. Have safe place. It contains inforthe peace of mind of knowing mation you will need should we can contact you in the you require service. Our serunlikely event of a safety vice number is 844-GE4-PTAC PRGL¿FDWLRQ (or 844-434-7822 ). 1 2 3 Read your Owner’s Manual carefully.
PAGE 26
Product Registration Please place in envelope and mail to: Please place in envelope and mail to: Veuillez mettre dans une enveloppe et envoyez à : 26
PAGE 27
Zoneline Warranty All warranty service provided by our Factory Service Centers or an authorized Customer Care® technician. To schedule service, on-line, visit us at GEAppliances.com, or call 844-GE4-PTAC (or 844434-7822 )). For service in Canada, contact Gordon Williams Corp. at 1.888.209.0999. Please have serial number and model number available when calling for service. Staple your receipt here. Proof of the original purchase date is needed to obtain service under the warranty.
PAGE 28
Consumer Support GE Appliances Website GEAppliances.com Have a question or need assistance with your appliance? Try the GE Appliances Website 24 hours a day, any day of the year! For greater convenience and faster service, you can now download Owner’s Manuals, order parts or even schedule service on-line. Schedule Service GEAppliances.com Expert GE repair service is only one step away from your door.