Installation Instructions If you have questions, ca!! 800-GEiCARES or visit our website at: w.monogram.
Installation Instructions BEFORE YOU BEGIN Read these instructions and carefully. IMPORTANT- CAUTION: Due to the weight and size of these completely wall ovens and to reduce the risk of personal injury or damage to the product, TWO PEOPLE ARE REQUIRED FOR PROPER INSTALLATION. Save these instructions for local inspector's use. IMPORTANT- PRUDENCE Observe all governing codes and ordinances. Note to Installer - Be sure to leave these instructions with the Consumer.
Installation Instructions CONTENTS Installation Preparation Electrical Requirements ...................................................7 Tools and Materials ......................................................... 7 Product Information Product Dimensions ..........................................................3 Provide Oven Supports .....................................................8 Step 1, Remove Packaging .............................................
Cabinetry Framed Cabinet, Framed Single oven Cabinet, ___ I23-1/2", I 28" Min. 28-3/8" Max. Double Oven 30"_23-1/2"_ ns de I 28"Min. 28-3/8"Max. 30 Order a 30" oven cabinet with the cutout sized to fit Order a 30" oven cabinet with the cutout sized to fit the double oven. the single oven. • These ovens require 3/4" overlap on both sides. Allow 1" Min. for top overlap and clearance to upper doors. Allow 1/4" clearance atthe bottom.
Cabinetry Installation Over a Monogram Warming Drawer Double Single Oven Oven 23-1/2" Min. 2x2 or 2x4 Anti-Tip Block Against Rear ,Wall, 9" From Floorto Bottom of Block _AIIow 5/8" Overlap on All Sides 1" Min. Above Toekick or Adjust to Oven Installation Height 2x2 or 2x4 Anti-Tip Block Against Rear Wall, 9" From Floorto Bottom of Block ,, NOTE: Install the oven only with specific models listed on the label located on top of the oven. NOTE: Additional clearances between cutouts may be required.
Cabinetry Installation Monogram Below a Advantium Oven Installation Between Monogram a Warming Advantium Drawer a Oven and 23-1/2" Min. _-Inside_. 2" Min. Note: Install the oven only with specific models listed on the label 45-1/4" located on top of the oven. NOTE: Additional clearances may be required. Check to be sure the oven supports above the Warming Drawer does not obstruct the required interior 23-1/2" depth and 9-1/4" height.
Installation ELECTRICAL REQUIREMENTS These Monogram built-in ovens require a separate properly ground ed 3-wire 120/208 or 120/240 volt, 60 Hz power supply, protected by a time delay fuse or circuit breaker. • Double ovens are rated at 6.5 KW at 240 volt and 6.5 KW at 208 volt. • Single ovens are rated at 3.3 KW at 240 volt and 2.8 KW at 208 volt. • Ovens are supplied with a flexible power cable which must be attached to a junction box. The cable length is 53"for both single and double convection ovens.
Installation Preparation ISTEP 1] REMOVE PACKAGING PROVIDE OVEN SUPPORTS Ovens may be supported by either a solid bottom or by 2 x 4 runners. • The support must be level and rigidly mounted, flush with the bottom edge of the cutout. _/_ /x F • Remove the carton, plastic coverings and styrofoam side/corner posts. • To prevent damage to the floor, do not remove the styrofoam base until the oven is ready to be installed. • Remove oven contents, shelves and packaging.
Installation Preparation WARNING ELECTRICAL SHOCK • If a cold water pipe is interrupted by plastic, non-metallic gaskets, union connections or other insulating materials, DO NOT use for grounding. • DO NOT ground to a gas pipe. • DO NOT have a fuse in the NEUTRAL or GROUNDING circuit. A fuse in the NEUTRAL or GROUNDING circuit could result in an electrical shock. HAZARD • The electrical power to the oven branch circuit must be shut-off while line connections are being made. • Use copper wiring only.
Installation Instructions SKIP THIS STEP IF YOU ARE CONNECTING TO 240 VOLT POWER SUPPLY. [STEP 31 208V ELECTRICAL SUPPLY WARNING If connecting to a 208 volt, 60 HZ supply, a jumper must be used across two terminals. These ovens are pre-wired for connection to 240 volt, 60 HZ, supply. If connecting to a 208 volt supply, modifications must be made. • For double ovens, there are two jumpers, one for the upper oven, one for the lower oven. • For single ovens there is one jumper.
Installation Instructions ISTEP41REMOVE OVEN DOOR(S) I STEP 51 ROUTE CABLE THROUGH CUTOUT • Open the door fully. • Pull the hinge latches up and hook them onto the hinge hooks on both sides, CAUTION Oven(s) are very heavy.
Installation Instructions ISTEP61SECURE OVEN TO [STEP 7] REPLACE OVEN DOOR CABINET • Grasp door firmly on both sides. • Insert and seatthe upper and lower hinge arms into the oven slots. • Slide oven into cabinet opening. • Drill 3/32" pilot holes through the oven front frame and into the cabinet frame. QQ • Align the groove on the lower hinge arm with the bottom of the oven slot. QQQ Slot Hinge Latch -Un-Hookedafter Replacement / \ • Secure oven to cabinet with screws provided.
Installation Instructions ISTEP 81 CONNECT ELECTRICAL WARNING ELECTRICAL AVERTISSEMENT SHOCK RISQUE DE CHOC I_LECTRIQUE HAZARD • Electrical ground is required on this appliance. • DO NOT connect to the electrical supply until appliance is permanently grounded. • Cet appareil dolt _tre mis _ la terre. • NE PAS brancher I'alimentation _lectrique si I'appareil n'est pas mis _ la terre de fa£on permanente.
Installation INSTALLATION Instructions CHECKLIST 1. Turn all knobs to OFFor Normal. 2. Turn on power atthe circuit breaker. 3. Set the clock for current time of day. Refer to the Owner's Manual for instructions. 4. Check oven door for full opening and closing, Oven lights should be on when the door is opened and off when the door is closed.
Notes 15
NOTE:While performing installations described in this book, safety glasses or goggles should be worn. l_or ,\lo_tog'ram 1o(<11s_'n,_ce _n 3ore an, a, (:<111 1.800.444. 1641. NOTE: Product improvcmcm al General Electric. Therefore, and Sl)((ifi(ations are sll|)je(I is a c(mtinuing ( n(Icavor materials, appearmace t() (ilang( _,_+illlollt noli(e. Monogram; I Pub.No.