GE Monogram® Installation Instructions Outdoor Cooking Center Dual Burner Outdoor Cooktop Liquid Propane Model ZX2L SS Natural Gas Model ZX2N SS
Before you begin—Read these instructions completely and carefully. IMPORTANT: Save these instructions for local inspector’s use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES. NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer. NOTE TO CONSUMER: Keep these instructions with your Owners Manual for future reference. If you received a damaged burner, you should contact your dealer. Installation of this burner requires basic mechanical skills.
Design Information Dual Burner Outdoor Cooktop Models Available Monogram Dual Burner Outdoor Cooktops are factory set for LP or natural gas. Order the model for your installation situation. Natural Gas Liquid Propane Model ZX2N SS Model ZX2L SS Product Dimensions & Clearances When installed on the side of a grill cart, allow 6" clearance at the rear and right side to vertical combustible materials.
Design Information Dual Burner Outdoor Cooktop Choosing the Location • These cooktops are designed for outdoor use only. Do not locate the cooktop in a building, garage or other enclosed area. • Ensure that fresh air ventilation is adequate. • Consider exposure to wind and proximity to traffic paths. • The minimum clearances to combustibles must be maintained at all times. • Do not install an outdoor cooktop below overhead unprotected combustible construction.
Installation Dual Burner Outdoor Cooktop 2 Step Installation On 27" Cart (Skip this step if you are installing in an enclosure) The cooktop burner is designed to fit onto the right side of the 27" grill head. • Open the grill lid and remove the right cooking grate and Gourmet Radiant Tray (or Lava Rock Tray). Secure Support Brackets to Grill • Remove the cooktop burner cover, burner grate and stainless steel aeration pan and drip tray.
Installation Dual Burner Outdoor Cooktop 2A Step Installation Into An Enclosure (Skip this step if burner is installed on a grill cart) • All built-in installations should be at least 35-1/2" above the floor. Clearances to Combustibles: • Allow at least 6" clearance from the back and sides to any combustible material. • Allow at least 1" clearance below the cooking surface on all sides.
Installation Dual Burner Outdoor Cooktop 3 Step Provide Gas Supply LP GAS MODELS Go to Step 3A For Natural Gas Model Connections LP Connection with ZX27QDC Kit For Quick Disconnect Coupling System WARNING PRODUCT STORAGE When storing the LP burner indoors, disconnect the LP tank. Store the tank outdoors in a well ventilated area. Do not store spare LP tanks near or below the burner installation. For installation with a 27" LP gas grill that does not feature the new Quick Disconnect coupling.
Installation Dual Burner Outdoor Cooktop 3A Step Provide Gas Supply NATURAL GAS MODELS The burner and its individual shut-off valve must be disconnected from the gas supply during any pressure testing of the system at test pressures in excess of 1/2 PSIG. The burner must be isolated from the gas supply system by closing its individual shut-off valve during any pressure testing of the system at test pressures equal to or less than 1/2 PSIG.
Installation Dual Burner Outdoor Cooktop 4 Step Test for Leaks WARNING TEST FOR LEAKS A complete gas tightness check must be performed at the installation site. DO NOT USE A FLAME TO CHECK FOR GAS LEAKS. • Do not use the burner until all connections have been leak tested. • Repeat leak test after each LP tank change or gas re-connect. • Check to be sure the main valve on the LP tank or the shut-off valve is in the “OFF” position. • Make a soap solution of one part liquid detergent and one part water.
Installation Dual Burner Outdoor Cooktop Step 6 Adjusting the Burners Adjustments should not be required, unless vibration during transit or variations in local gas supply make minor adjustments necessary. 1-1/2" Proper Flame Adjustments must be made by a qualified technician at the time of installation. Extreme care should be used if adjustments are made after installation. 3/8" Burner • Push and turn the burner control knobs to the “LITE” position. Push and turn the small ignitor knob clockwise.
Notes Dual Burner Outdoor Cooktop 11
Note: While performing installations described in this book, safety glasses or goggles should be worn. For Monogram® local service in your area, call 1-800-444-1845. Note: Product improvement is a continuing endeavor at General Electric. Therefore, materials, appearance and specifications are subject to change without notice. Monogram. ® We bring good things to life. Pub. No. 49-8842-2 Dwg. No. 164D3333P082 Printed in USA (N.D. 728) 3/03 10746-Rev.