® POWER SYSTEMS, INC.
INTRODUCTION Thank you for purchasing this model of the QUIETPACT™ product line by Generac Power Systems, Inc. This model is designed and manufactured to supply electrical power for recreational vehicles. ◆ READ THIS MANUAL THOROUGHLY If you do not understand any portion of this manual, contact Generac or your nearest Generac Authorized Service Dealer for starting, operating, and servicing procedures.
Table of Contents QUIETPACT™ 65D Recreational Vehicle Generator Part I – Owner’s Manual Introduction ......................................Inside Front Cover Read This Manual Thoroughly ....................................IFC Contents ......................................................................IFC Operation and Maintenance ........................................IFC How to Obtain Service..................................................IFC Authorized Service Dealer Locator Number ..............
Safety Rules QUIETPACT™ 65D Recreational Vehicle Generator SAVE THESE INSTRUCTIONS – The manufacturer suggests that these rules for safe operation be copied and posted in potential hazard areas of the recreational vehicle. Safety should be stressed to all operators and potential operators of this equipment. WARNING: The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm.
Safety Rules QUIETPACT™ 65D Recreational Vehicle Generator ELECTRICAL HAZARDS FIRE HAZARDS • The generator covered by this manual produces dangerous electrical voltages and can cause fatal electrical shock. Avoid contact with bare wires, terminals, connections, etc., while the unit is running. Before operating the generator, ensure all appropriate covers, guards, and barriers are in place . If you must work around an operating unit, stand on an insulated, dry surface to reduce shock hazard.
Section 1 – General Information QUIETPACT™ 65D Recreational Vehicle Generator 1.1 GENERATOR IDENTIFICATION Please record the following information from the generator DATA DECAL or information decal, located below the user control panel. 1. Model Number ____________________ 2. Serial Number __________________ 3. kW Rating__________________________ 4. Rated Voltage __________________ Model: 004614-1 QUIETPACT™ 65D 1. 2-Pole, 30-amp Circuit Breaker 2. Hourmeter 3. Oil Fill Opening and Plug 4.
Section 1 – General Information QUIETPACT™ 65D Recreational Vehicle Generator 1.2 GENERATOR APPLICABILITY These generators have been designed and manufactured for supplying electrical power to recreational vehicles. You should neither modify the generator nor use it for any application other than for what it was designed. If there are any questions pertaining to its application, write or call the factory. Do not use the unit until you have been advised by a competent authority.
Section 1 – General Information QUIETPACT™ 65D Recreational Vehicle Generator ◆ 1.5.2 FUEL CONSUMPTION (GAL/HR) Model No Load QUIETPACT™ 65D 0.28 (004614-1) Half Load Full Load 0.45 0.78 ◆ 1.5.3 ENGINE OIL REQUIREMENTS Use a high-quality detergent oil with American Petroleum Institute (API) classification “For Service CC.” Detergent oils keep the engine cleaner and reduce carbon deposits.
Section 2 – Operation QUIETPACT™ 65D Recreational Vehicle Generator 2.1 GENERATOR CONTROL PANEL The following features are mounted on the generator control panel (Figure 2.1): Figure 2.1 – Generator Control Panel ◆ 2.1.4 LINE BREAKER The line (i.e., main) breaker protects the generator’s AC output circuit against overload and provides a method of turning OFF the generator’s 230-volt AC output to the vehicle circuits. The QUIETPACT™ 65D has two 30-amp breakers. NOTE: Refer to Section 1.
Section 2 – Operation QUIETPACT™ 65D Recreational Vehicle Generator ◆ 2.3.2 ENGINE LUBRICATION Before starting the engine, have the engine crankcase properly serviced with the recommended oil. Refer to Section 1.5.3 (Page 6) and Sections 3.1 and 3.2 (Page 12) for oil servicing procedures and recommendations. The generator engine releases DEADLY carbon monoxide gas through its exhaust system. This dangerous gas, if breathed in sufficient concentrations, can cause unconsciousness or even death.
Section 2 – Operation QUIETPACT™ 65D Recreational Vehicle Generator ◆ 2.6.2 DO NOT OVERLOAD THE GENERATOR If the engine does not start after it has been cranking for 15 seconds, release the Start/Stop switch, wait 15 seconds, and try again. Holding the switch for longer than 15 seconds can damage the starter motor. 4. Let the engine run at no-load for a few minutes to stabilize and warm up. 5.
Section 2 – Operation QUIETPACT™ 65D Recreational Vehicle Generator Figure 2.2 – Engine Protective Devices The voltage regulator also incorporates a “voltage surge protection circuit.” This circuit prevents troublesome surges in the generator AC output voltage. Voltage surge is a common cause of damage to electronic equipment. 2.8 ADDITIONAL INFORMATION ◆ 2.8.1 25-HOUR BREAK-IN PERIOD The first 25 hours of operation is the break-in period for the generator.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator ◆ 2.8.4 OPERATION IN HIGH GRASS Figure 3.1 – Oil Maintenance Features OR BRUSH Never operate the generator while the vehicle is parked over high grass, weeds, brush, leaves, or other combustible substance. Such materials can ignite and burn from the heat of the exhaust system. The generator exhaust system becomes extremely hot during operation and remains hot for a long time after it has shut down.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator 9. Remove the dipstick, and wipe it dry with a clean, lint-free cloth. This will be used later to check the oil level. 10. Remove the oil-fill plug, and slowly add the proper type and amount of recommended oil (see Section 1.5.3, Page 6). Periodically use the dipstick to check the oil level and continue to fill the crankcase until the oil reaches the dipstick “FULL” mark. DO NOT FILL ABOVE THE “FULL” MARK. 11.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator Figure 3.3 – Spark Arrestor Muffler Maintenance 3/8" NPT HEX PIPE CAP • Check the battery fluid level of unsealed batteries and, if necessary, fill with Distilled Water Only. Do not use tap water in batteries. • Have the state of charge and condition checked by a Generac Authorized Service Dealer. NOTE: Servicing of the battery is to be performed or supervised by knowledgeable personnel, according to the required precautions.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator • Immediately wash with water all skin areas that come into contact with the electrolyte. • If the electrolyte contacts the eyes, immediately flush eyes thoroughly with water, and seek medical attention. • Spilled electrolyte is to be washed down with an acid-neutralizing agent. A common practice is to use a solution of 1 pound (500 grams) bicarbonate of soda to 1 gallon (4 liters) of water.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator ◆ 3.12.2 RETURN TO SERVICE To return the unit to service after storage, proceed as follows: 1. Check the tag on the engine for oil viscosity and classification. Verify that the correct recommended oil is used in the engine (see Section 1.5.3, Page 6). If necessary, drain and refill with the proper oil. 2. Check the state of the battery. Fill all cells of unsealed batteries to the proper level with distilled water.
Section 3 – Maintenance QUIETPACT™ 65D Recreational Vehicle Generator 3.13 SERVICE SCHEDULE ATTENTION: It is recommended that all service work be performed by your nearest Generac Authorized Service Dealer. SYSTEM/COMPONENT X = Action R = Replace/Adjust as Needed * = To Be Completed by a Generac Authorized Service Dealer.
PART II – INSTALLATION INSTRUCTIONS ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Safety Rules QUIETPACT™ 65D Recreational Vehicle Generator DANGER: For fire safety, installation of a generator into a recreational vehicle must comply strictly with NFPA 70 (latest edition), “National Electrical Code”, Article 551, and NFPA 1192 (latest edition), “Standard for Recreational Vehicles”. In addition, installation must comply with the manufacturer’s instructions and recommendations.
Safety Rules QUIETPACT™ 65D Recreational Vehicle Generator ELECTRICAL HAZARDS FIRE HAZARDS • The generator covered by this manual produces dangerous electrical voltages that can cause fatal electrical shock. Avoid contact with bare wires, terminals, connections, etc., while the unit is running. Ensure all appropriate covers, guards, and barriers are in place before operating the generator. If you must work around an operating unit, stand on an insulated, dry surface to reduce shock hazard.
Section 1 – General Information QUIETPACT™ 65D Recreational Vehicle Generator 1.1 PURPOSE AND SCOPE OF THE MANUAL These Installation Instructions have been prepared especially for the purpose of familiarizing installers and owners of the applicable equipment with the product's installation requirements. Give serious consideration to all information and instructions in the manual, both for safety and for continued reliable operation of the equipment.
45 [1.77"] F 421 [16.57"] 371 [14.61"] 63 [2.48"] 26 [1.02"] [.94"] 567 [22.32"] OVER SCREWS 2 [1.16"] EXHAUST OUTLET 99 [3.90"] 516.5 [20.33"] 536.3 [21.12"] [11.38"] 3/8-16 UNC MOUNTING HOLES [4 PLCS] BATTERY CONNECTION NEGATIVE (-) BATTERY CONNECTION POSITIVE (+) ] 929 [36.57"] OVER SCREWS FRONT SERVICE DOOR REAR SERVICE PANEL 376.5 [14.82"] HOUR METER COOLANT FILL COO SPARK ARRESTOR CENTER OF GRAVITY 291.5 [11.48"] .
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator 2.1 LOCATION AND SUPPORT ◆ 2.1.1 GENERATOR LOCATION The most desirable location for the generator set is between the vehicle's main frame members. Many recreational vehicles have been factoryequipped with an area for the generator set. Some may even have a generator compartment provided by the vehicle manufacturer.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator ◆ 2.1.4 GENERATOR RESTRAINT Figure 2.3 – Typical Compartment Construction Use four 3/8"-16 hardened steel bolts (Grade 5) to fasten the generator to the supporting frame or the support tubing. These bolts must pass through (a) the generator mounting base, (b) the compartment floor (if a compartment is used), and (c) the supporting framework (Figure 2.2).
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator • Seams and joints of the galvanized steel (whether used as a liner or for the compartment itself) must be lapped and mechanically secured. Such seams may be manufactured, welded, bolted, riveted, or screwed. Manufactured lock seams are shown in Figure 2.4. Installer-constructed compartments typically utilize a standard lap joint. Figure 2.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator Figure 2.5 – Typical Noise Abatement ◆ 2.2.4 COMPARTMENT FLOOR CUTOUTS You must provide openings in the generator compartment for the following items (Figure 2.6): • Engine exhaust and cooling air outlets • Generator cooling air inlet and front service door • Four holes for passage of generator mounting bolts. See Section 2.1.4 (Page 23) • Rear service door.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator 2.3 COOLING AND VENTILATING AIR It is absolutely essential that an adequate flow of air for cooling, ventilation, and engine combustion be supplied to the generator set. Without sufficient airflow, the engine/generator quickly overheats. Such overheating can cause serious operating difficulties and also may cause fire and personal injury.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator Figure 2.10 – Air Inlet Using Ductwork ◆ 2.3.4 TESTING THE INSTALLATION Generac recommends testing the installation to be sure adequate cooling airflow is available to the unit, before placing the unit into service. If the unit shows signs of overheating, you will need to enlarge the air openings. Never place a unit into service until absolutely certain that cooling and ventilation is adequate.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator Dirt that enters the fuel system also may cause problems. Lines and piping must be properly installed and tightened to prevent dirt from entering. Diesel fuel must be kept clean. Factory-installed generator fuel system components include (a) a fuel filter, (b) a 12-volt DC electric pump, (c) an injection pump, and (d) interconnecting lines and fittings.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator 2.5 EXHAUST SYSTEM The generator exhaust system must be safely and properly installed. Only approved exhaust system parts must be used. A properly installed exhaust system must be vapor-tight, quiet, and completely safe. The generator engine gives off DEADLY carbon monoxide gas through its exhaust system. This dangerous gas, if breathed in sufficient concentrations, can cause unconsciousness or even death.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator • Never tee the generator engine exhaust pipe into the vehicle engine exhaust piping. This causes excessive back pressure on the generator engine. Also, water from one engine can damage the other engine. • Plan exhaust system installation carefully. Comply with all applicable codes, standards, and regulations. 2.6 ELECTRICAL CONNECTIONS Be sure to read Section 1.6 on Page 20.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator This generator set is equipped with dual-stator AC power windings. These two-stator windings supply electrical power to customer electrical loads by means of a dual, two-wire connection system. Figure 1.1 – Connections for 230 Volts Only • If you use metallic conduit, vapor-seal the end of the conduit where it enters the junction box. Do this because flexible metallic conduit is not vaporproof along its entire length.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator Figure 2.18 – Installation With Isolation Receptacle ◆ 2.7.2 BATTERY CABLES If the vehicle’s electrical circuits can be powered by any other source of electricity (such as, a “dockside” power receptacle), there must be no possibility of connecting the different power sources to the vehicle’s circuits at the same time.
Section 2 – Installation QUIETPACT™ 65D Recreational Vehicle Generator 2. Connect the battery cable from the battery post, indicated by a NEGATIVE, NEG, or (-), to the vehicle frame ground connection (Figure 2.19). 3. Connect a cable from the vehicle frame ground to the negative post on the generator frame. 4. Connect cables so the connectors are clean and tight. Figure 2.
Section 3 – Post-installation Start-up Checks QUIETPACT™ 65D Recreational Vehicle Generator CHECKS ◆ 2.8.1 REMOTE START/STOP CONNECTIONS The following steps are necessary to connect the remote start/stop option: 1. If the six-wire remote connector is visible below the control panel, as shown in Figure 2.20, skip to step 5. Otherwise, proceed with step 2. 2. Remove the electrical access panel located just below the knock-out labeled “REMOTE.
Section 3 – Post-installation Start-up Checks QUIETPACT™ 65D Recreational Vehicle Generator CHECKS 3.5 INSTALLATION CHECKLIST ◆ LOCATION AND SUPPORT ❑ Generator is properly located. ❑ Generator is properly supported. ❑ Generator is properly restrained. ◆ GENERATOR COMPARTMENT ◆ EXHAUST SYSTEM ❑ Exhaust system complies with all applicable codes. ❑ Exhaust system is properly and safely installed.
Appendix 1 – Troubleshooting QUIETPACT™ 65D Recreational Vehicle Generator TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION The engine will not crank. 1. System control fuse blown 2. Loose corroded or defective battery cables 3. Defective engine Start/Stop switch 4. Defective starter contactor 5. Defective starter motor 6. Low or defective battery 7. Defective engine control board 1. Vehicle fuel shutoff valve closed 2. Out of fuel 3. Defective fuel solenoid (FS) 4. Defective fuel pump (FP) 5.
Appendix 2 — Electrical Data QUIETPACT™ 65D Recreational Vehicle Generator Electrical Schematic – Drawing No. - 0D5037-A Generac® Power Systems, Inc.
Appendix 2 — Electrical Data QUIETPACT™ 65D Recreational Vehicle Generator Wiring Diagram – Drawing No. 0D5036-A 38 Generac® Power Systems, Inc.
Appendix 2 — Electrical Data QUIETPACT™ 65D Recreational Vehicle Generator Wiring Diagram – Drawing No. 0D5036-A Generac® Power Systems, Inc.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Engine, Alternator Drive and Starter Assembly – Drawing No. 0D5057-A 40 Generac® Power Systems, Inc.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Engine, Alternator Drive and Starter Assembly – Drawing No. 0D5057-A ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 PART NO.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Base Frame – Drawing No. D2357-A ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 PART NO. QTY. DESCRIPTION 0D2126 0D2131 0C5088 0C5644 056326 029451 0C7857 070936E 0C6721 0C6722 042907 022129 022097 BASE FRAME WELDMENT DOOR, SERVICE REAR DOOR, SERVICE FRONT SLIDE LATCH FLUSH VINYL TRIM -BLACK 180MM RUBBER TAPE 1/8 X ½" GROMMET 1/8 X 13/32 VIBRATION MOUNT GASKET, CLEANOUT PLATE, CLEANOUT HHCS M8-1.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Enclosure – Drawing No. 0D5059-B 25 12 17 11 24 17 17 2 13 20 34 VIEW "A" 27 10 17 1 30 32 9 31 26 35 8 14 5 15 17 28 21 A 33 29 1 19 23 7 17 6 17 17 4 3 17 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Cooling System – Drawing No. D2360 44 Generac® Power Systems, Inc.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Cooling System – Drawing No. D2360 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Electrical Enclosure Assembly – Drawing No. 0D5056-A 28 29 1 27 18 30 2 31 11 1 3 9 25 26 27 16 20 33 28 17 8 25 19 27 13 12 6 26 7 28 4 15 11 14 32 5 ITEM PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Intake and Exhaust System – Drawing No. D2362 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 PART NO. QTY. DESCRIPTION 075674 0C4879 0C4880 0C5493 0C4727 025145 0C7645 0C5022 035685 0C4878 0C6243 0C6244 039288 071956 EXHAUST GASKET CHAMBER AIR INTAKE AIR FILTER HOSE, AIR INLET MUFFLER WELDMENT U BOLT & SADDLE 1.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Fuel and Electrical Systems – Drawing No. 0D2363-A ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PART NO. QTY. DESCRIPTION 0C6946A 052219 069598B 022097 038750 056739 049813 055934M 022473 040173 028414A 0C7649 047411 0C7968 022237 075763 Fuel Pump Assembly 1/8 NPT x 5/16 Barbed Straight Fitting Bulkhead Adaptor Fitting Washer, Split Lk- ¼ -M6 HHCS M6-1.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator Customer Controls Assembly – Drawing No. 0D5055-A ITEM PART NO. QTY. DESCRIPTION 1 2 3 4 5 6 7 8 9 10 11 12 0D2398 0C4540 0C1457 081904 055920 043181 022159 055927 0C5127 0C7341 049226 0C7340 1 1 1 1 1 2 2 1 1 1 4 1 13 14 15 0D2021A 051714 0C4476 1 2 1 START / STOP SWITCH COVER, ENGINE CONTROL BOX HOUR METER FUSE HOLDER, SFE-14 SWITCH, PUSHBUTTON SPST PPHMS M3-0.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Camshaft – Drawing No. 75677 ITEM 1 2 3 4 5 6 7 PART NO. QTY. DESCRIPTION 0709390232 0709390233 0709390195 0709390234 0709390235 0709390236 0709390237 CAMSHAFT ASSEMBLY CAMSHAFT GEAR KEY GEAR SPACER BALL BEARING SLIDER 1 1 1 1 3 1 1 50 Generac® Power Systems, Inc. ITEM 8 9 10 11 12 13 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Cylinder Block– Drawing No. 75676 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Cylinder Head – Drawing No. D2794 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Crankshaft, Piston and Flywheel – Drawing No. 075679-B ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Oil Pump – Drawing No. 75682 ITEM 1 2 3 4 5 6 PART NO. QTY. DESCRIPTION 0709390250 0709390252 0709390251 0709390253 0709390254 0709390255 0709390532 0709390533 0709390258 IDLER GEAR ASSEMBLY SPRING THRUST WASHER ROTOR OIL PUMP COVER 0.10MM SHIM 0.15MM SHIM 0.20MM SHIM 0.50MM SHIM 1 1 1 1 1 AR AR AR AR 54 Generac® Power Systems, Inc. ITEM 7 8 9 10 11 12 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Rocker Arm Assembly – Drawing No. 075683-A ITEM PART NO. QTY. DESCRIPTION 1 070939-170 1 2 3 4 5 6 070939-171 070939-172 070939-174 070939-173 070939-175 3 3 6 6 3 ROCKER ARM ASSEMBLY (INCLUDES ALL COMPONENTS SHOWN BELOW) INTAKE ROCKER ARM EXHAUST ROCKER ARM NUT STUD ROCKER ARM BRACKET ITEM 7 8 9 10 11 12 PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Injector Pump – Drawing No. 075686-C ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 PART NO. QTY. DESCRIPTION 0709390316 0709390317 0709390318 0709390319 0709390320 0709390298 0709390321 0709390322 0709390323 0709390324 0709390325 0709390326 0709390327 0709390328 0709390329 0709390330 INJECTOR PUMP ASSEMBLY SHIM-0.2MM SHIM-0.3MM SHIM-0.5MM SHIM-1.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Fuel Supply – Drawing No. 075693-C ITEM PART NO. QTY. DESCRIPTION 1 2 3 4 5 6 7 8 9 10 0709390661 069858 0C8008 0C8008 040173 0709390378 0709390379 074808 052233 039450 11 030096 FUEL FILTER SUPPORT FUEL FILTER HOSE, 5/16" SAE 30R7 HOSE, 5/16" SAE 30R7 HOSE CLAMP GASKET BANJO FITTING FUEL BLEED FITTING 1/8" NPT TEE (BRASS) 1/8" NPT X 3/16" 90 DEG.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Timing and Governor – Drawing No. 082067-B 58 Generac® Power Systems, Inc.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Timing and Governor – Drawing No. 082067-B ITEM 1 2 3 4 5 6 7 8 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 PART NO.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Engine Block – Drawing No. 082961-C 24 23 22 25 18 28 17 15 20 13 19 12 14 14 3 33 30 29 1 14 31 2 ITEM PART NO. QTY.
Appendix 3 — Exploded Views and Parts Lists QUIETPACT™ 65D Recreational Vehicle Generator 1.0 Liter Diesel Water Pump – Drawing No. 82962 ITEM 1 2 3 4 5 6 7 PART NO. QTY. DESCRIPTION 0709390265 0709390266 0709390267 0709390268 0709390269 0709390270 0709390271 WATER PUMP ASSEMBLY PLUG THERMOSTAT SPRING GASKET SET PLATE BOLT 1 1 1 1 3 1 1 ITEM 8 9 10 11 12 15 PART NO. QTY.
Appendix 4 – Notes QUIETPACT™ 65D Recreational Vehicle Generator 62 Generac® Power Systems, Inc.
Appendix 4 – Notes QUIETPACT™ 65D Recreational Vehicle Generator Generac® Power Systems, Inc.
Appendix 5 – Warranty QUIETPACT™ 65D Recreational Vehicle Generator FEDERAL AND CALIFORNIA EMISSIONS CONTROL WARRANTY STATEMENT (for non-road Diesel engines rated under 19 kW) YOUR WARRANTY RIGHTS AND OBLIGATIONS The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), Generac Power Systems, Inc. (GENERAC), and the engine manufacturer for this equipment, Ishikawajima Shibaura Machinery Co., Ltd.
Appendix 5 – Warranty QUIETPACT™ 65D Recreational Vehicle Generator OBLIGATIONS AND RIGHTS OF THE MANUFACTURER AND OWNER The new model year, class of diesel engine, and emission application determination for your engine are identified on the emission control information label affixed to the right-hand side of your engine's timing gear case. The warranty period begins on the date the new equipment is sold to the first retail purchaser.
Appendix 5 – Warranty QUIETPACT™ 65D Recreational Vehicle Generator GENERAC POWER SYSTEMS’ THREE-YEAR LIMITED WARRANTY FOR RECREATIONAL VEHICLE GENERATORS NOTE: ALL UNITS MUST BE INSTALLED BY GENERAC POWER SYSTEMS AUTHORIZED SERVICE FACILITIES. For a period of 3 (three) years or 2,000 (two thousand) hours of operation from the date of original sale, whichever occurs first, Generac Power Systems, Inc.
