Product Manual
Table Of Contents
- Section 1: Introduction and Safety
- Section 2: General Information
- Section 3: Operation
- Pre-start Checklist
- Manually Starting the Unit
- AUTO (Remote) Starting the Unit
- Wet Stacking
- Cold Weather Operation
- Using a Booster Battery or Charger (if equipped)
- Generator Output Connections
- Generator Cam Lock Connections (If Equipped)
- Using the Voltage Selector Switch
- Fine Voltage Adjustment
- Voltage Regulator
- Achieving 240V Three-Phase in 208V Three-Phase (Parallel Low Wye) Configuration
- Customer Convenience Receptacles
- Main Circuit Breaker
- Transfer Switch
- AUTO Exercise Timer
- Shutting Down the Unit
- Emergency Stop Switch
- Idle Switch
- Using the ECU Override Switch
- Towing the Unit
- Lifting the Unit
- Section 4: Maintenance
- Section 5: Troubleshooting
- Section 6: Wiring Diagrams and Service Log
- Wiring Diagram - 3 Position AC Box
- Wiring Diagram - 4 Position AC Box
- Wiring Diagram - Receptacles
- Wiring Diagram - Engine Heater
- Wiring Diagram - Wiring Buck (If Equipped)
- Wiring Diagram - Power Zone PMG
- Wiring Diagram - Power Zone Control Box
- Wiring Diagram - Trailer Lights
- Wiring Diagram - Brake Wiring
- Wiring Diagram - 12V Battery Charger
- Wiring Diagram - Power Zone Low Oil Level (If Equipped)
- Service Log
4 Owner’s Manual for MDG25IF4
Introduction and Safety
Battery Hazards
Always recycle batteries in accordance with local laws
and regulations. Contact your local solid waste collection
site or recycling facility to obtain information on local
recycling processes. For more information on battery
recycling, visit the Battery Council International website
at: http://batterycouncil.org
Fuel Hazards
• DO NOT fill fuel tank near an open flame, while
smoking, or while engine is running. DO NOT fill
tank in an enclosed area with poor ventilation.
• DO NOT operate with the fuel tank cap loose or
missing.
Engine Safety
Internal combustion engines present special hazards
during operation and fueling. Failure to follow the safety
guidelines described below could result in severe injury or
death. Read and follow all safety alerts described in the
engine operator's manual. A copy of this manual was
supplied with the unit when it was shipped from the factory.
• DO NOT run engine indoors or in an area with poor
ventilation. Verify engine exhaust cannot seep into
closed rooms or ventilation equipment.
• DO NOT clean air filter with gasoline or other types
of low flash point solvents.
• DO NOT operate the unit without a functional
exhaust system.
• Shut the engine down if any of the following
conditions exist during operation:
• Abnormal change in engine speed.
• Loss of electrical output.
• Equipment connected to the unit overheats.
• Sparking occurs.
• Engine misfires or there is excessive engine/
generator vibration.
• Protective covers are loose or missing.
• Ambient air temperature is above 120°F (49°C).
(000188)
DANGER
Electrocution. Do not wear jewelry while
working on this equipment. Doing so will
result in death or serious injury.
(000137a)
WARNING
Explosion. Batteries emit explosive gases while charging.
Keep fire and spark away. Wear protective gear when
working with batteries. Failure to do so could result in
death or serious injury.
(000162)
WARNING
Explosion. Do not dispose of batteries in a fire. Batteries
are explosive. Electrolyte solution can cause burns and
blindness. If electrolyte contacts skin or eyes, flush with water
and seek immediate medical attention.
(000163a)
WARNING
Risk of burn. Do not open or mutilate batteries.
Batteries contain electrolyte solution which can
cause burns and blindness. If electrolyte contacts
skin or eyes, flush with water and seek immediate
medical attention.
WARNING
Environmental Hazard. Always recycle batteries at an
official recycling center in accordance with all local
laws and regulations. Failure to do so could result in
environmental damage, death or serious injury.
(000228)
(000192)
DANGER
Explosion and fire. Fuel and vapors are extremely
flammable and explosive. No leakage of fuel is
permitted. Keep fire and spark away. Failure to do
so will result in death or serious injury.
(000174)
DANGER
Risk of fire. Allow fuel spills to completely dry
before starting engine. Failure to do so will
result in death or serious injury.










