Product Manual
Table Of Contents
- Section 1: Introduction and Safety
- Section 2: General Information
- Section 3: Operation
- Unit Setup
- Raising the Mast—Manual Winch
- Raising the Mast—Electric Winch (If Equipped)
- Prestart Checklist
- Starting Unit—Analog Controls
- Starting Unit—Power Zone Controls (MANUAL Mode)
- Starting Unit—Power Zone Controls (AUTO Mode)
- Operating Lights—Analog Controls
- Operating Lights—Power Zone Controls (MANUAL Mode)
- Operating Lights—Power Zone Controls (AUTO Mode)
- Shutting Down Unit—Analog Controls
- Shutting Down Unit—Power Zone Controls (MANUAL Mode)
- Shutting Down Unit—Power Zone Controls (AUTO Mode)
- Automatic Shutdown
- Starting Utility Mode (If Equipped)—Analog Controls
- Starting Utility Mode (If Equipped—Power Zone Controls
- Stopping Utility Mode (If Equipped)—Analog Controls
- Stopping Utility Mode (If Equipped)—Power Zone Controls
- Dusk-to-Dawn Sensor (If Equipped)
- Customer Convenience Receptacles (If Equipped)
- Removing Loads from Receptacles (If Equipped)
- Storing the Unit
- Lowering the Mast—Manual Winch
- Lowering the Mast—Electric Winch (If Equipped)
- Positive Air Shutdown (PAS) (If Equipped)
- Lower Radiator Hose Heater (If Equipped)
- Tandem Tow (If Equipped)
- Telemetry (If Equipped)
- Spark Arrester (If Equipped)
- Heated Fuel Filter (If Equipped)
- Towing the Unit
- Lifting the Unit
- Tying Down the Unit
- Section 4: Maintenance
- Section 5: Troubleshooting
- Section 6: Wiring Diagrams
iv Owner’s Manual for Mobile Light Tower
Load Limit and Overload ........................................... 36
Removing Loads from Receptacles
(If Equipped) .......................................................36
Storing the Unit ..................................................36
Lowering Mast—Manual Winch ........................36
Lowering Mast—Electric Winch (If Equipped) 37
Manually Lowering Electric Mast .............................. 37
Positive Air Shutdown (PAS)
(If Equipped) .......................................................37
Test the PAS ............................................................. 37
Reset the PAS .......................................................... 38
Lower Radiator Hose Heater
(If Equipped) .......................................................38
Tandem Tow (If Equipped) ................................38
Telemetry (If Equipped) .....................................38
Spark Arrester (If Equipped) .............................38
Heated Fuel Filter (If Equipped) ........................38
Towing the Unit ..................................................39
Lifting the Unit ...................................................40
Tying Down the Unit ..........................................40
Section 4:Maintenance
Emissions Information ......................................41
Daily Walk-Around Inspection ..........................41
General Maintenance .........................................41
Preparing for Service ................................................ 41
Cleaning the Unit ...................................................... 41
Inspecting the Unit .................................................... 41
Basic Maintenance Schedule ...........................42
Manual Winch: Use, Operation, and
Maintenance .......................................................43
Prior to Use ............................................................... 43
Operation .................................................................. 43
Maintenance ............................................................. 43
Electric Winch (If Equipped): Use,
Operation, and Maintenance .............................43
Winch Mechanical Brake .......................................... 43
Trailer Wheel Bearings ......................................44
Jack Maintenance ..............................................44
Section 5: Troubleshooting
General Troubleshooting .................................. 45
Troubleshooting the Lights .............................. 46
Troubleshooting Controller Fault
Indicators ........................................................... 47
Section 6:Wiring Diagrams
Mast Junction Box Wiring and Light
Connections ....................................................... 49
AC Wiring (1 of 3) ..............................................50
AC Wiring (2 of 3) ..............................................51
AC Wiring (3 of 3) ..............................................52
DC Wiring ........................................................... 53
AC Wiring—Power Zone (If Equipped)
(1 of 3) ................................................................. 54
AC Wiring—Power Zone (If Equipped)
(2 of 3) ................................................................. 55
AC Wiring—Power Zone (If Equipped)
(3 of 3) ................................................................. 56
DC Wiring—Power Zone (If Equipped) ........... 57
Trailer Lights ...................................................... 58