Owner manual

ManualsBrandsGeneralAire ManualsRadiatorsDH95 Dehumidifier

DH95 - Crawl Space, Attic or Basement

Whole House Dehumidiﬁer

Installation & Owners Manual

Read the installation operation and maintenance instructions carefully before installing and using this unit.

Proper adherence to these instructions is essential to obtain maximum beneﬁt from the DH95 system.

Installation contrary to these guidelines or lack required maintenance will void warranty.

Speciﬁcations

• Model:DH95

• Capacity:95pints/day,(4.14lbs./hr)@80°/60%RH

• Electrical:110-120VAC,9.6FLAAmps,60Hz,grounded

• OperatingReturnAirTemp.Range:50°Fmin.,90°Fmax.

• AirFlow:

• 375CFMwithoutexternalducting

• 295CFM@.30IWGexternalstatic

• 234CFM@.50IWGexternalstatic

• RefrigerantCharge:17.5oz.R-410A

• Ductconnections:Returnductange:10”Round,Outlet10”Round,

• FilterSize:HighEfciency(MERV11):Pleated13-3/8”X13-3/8”X2”

• Size(Clearance):14.5”Heightx30”Widthx15.5”Depth,14”minimumfrontorrearclearanceforlterservice.

• Weight:73pounds(ShippingWeight94pounds),(16”H,32.5”W,20”D)

Read and Save These Instructions

FORMNO.DH95REVA

Unit Location

TheDH95canbeinstalledinavarietyoflocationstomeettheowner’sneedsaslistedbelow.Inallcaseskeepthe

followingcautionsinmind:

• Theunitisdesignedtobeinstalledindoorsinaspacethatisprotectedfromrain,oodingand/orotherforms

ofexcesswater.Unitisnotdesignedtobeexposedtochlorinatedpoolconditionsorspaceswhereunitwillbe

exposedtocorrosivechemicalsorconditions.

• Installtheunitwithspacetoaccessthefrontpanelformaintenanceandservice.Alsoalloweasyaccessto

theltercoverpanel.DO NOT INSTALL THE UNIT WITH THE FRONT PANEL OR FILTER COVER PANEL

INACCESSIBLE.

• Avoiddischargingtheairdirectlyatpeople,overthewaterinpoolareas,orotherareasorobjectswhere

dehydrationorevaporationofmoistureisnotdesired.

• Ifusednearwetareas,becertainthereisNOchancetheunitcouldfallintothewaterorbesplashedandthatitis

wiredintoaGROUNDFAULTINTERRUPTERprotectedcircuit.

• AsecondarydrainpanMUSTbeplacedundertheunitifinstalledabovealivingareaoraboveanareawhere

waterleakagecouldcausedamage(seelocalcodesforotherrequirements).

• DO NOTpositiontheDH95directlyonstructuralmemberswherenoiseorvibrationmaybeobjectionable.The

DH95isequippedwithadjustablesupportfeettoraiseandleveltheunitfromthemountingsurface,these

adjustablefeetshouldbeutilizedtoprovideimproveddrainagefromthedrainpanandshouldbeadjustedtotilt

slightlytowardthedrainutilized.

• TheDH95shouldbelocatedneartheexistingairhandlingsystemtominimizetherequiredductworkfor

connectingoftheDH95totheexistingairhandlingsystem.Whentheremotecontroloptionisused,thecontrol

(humidistat)unitmustbelocatedinthespacethatistobeconditioned.Thecontrol(humidistat)maybelow

voltage(24volt)andshouldbeconnectedtotheDH95withcodeapproved,lowvoltagethermostatcable.

• WhenlocatingtheDH95inareasofextremeheatorhighhumidity,>120-degrees/90%humidity,additional

externalinsulationmayberequiredtopreventundesiredcondensationontheexterioroftheunit.

By GeneralAire

Summary of content (8 pages)

PAGE 1
Read and Save These Instructions By GeneralAire® DH95 - Crawl Space, Attic or Basement Whole House Dehumidifier Installation & Owners Manual Specifications • • • • • • • • • • Model: DH95 Capacity: 95 pints/day, (4.14lbs./hr) @ 80°/60%RH Electrical: 110-120 VAC, 9.6 FLA Amps, 60 Hz, grounded Operating Return Air Temp. Range: 50°F min., 90°F max. Air Flow: • 375 CFM without external ducting • 295 CFM @ .30 IWG external static • 234 CFM @ .50 IWG external static Refrigerant Charge: 17.5 oz.
PAGE 2
Electrical Requirements • The DH95 is equipped with an appliance cord and may be plugged directly into a 120 volt, 15 amp household type convenience outlet. If used in a wet area such as an indoor pool, spa room, or an area prone to flooding (basement or crawlspace), a ground fault interrupter protected circuit is required. In all cases local codes precede over all installation and wiring recommendations.
PAGE 3
• Connecting to Existing HVAC Systems: For proper operation, connecting to existing air handler and duct systems requires the fans of each system to be interlocked utilizing the low voltage interlock method provided in the DH95 low voltage connection diagram. Refer to low voltage connection diagram in this document and on the unit. C.
PAGE 4
Wiring Unit Schematic Wiring Connections Line and Low Voltage * OPTIONAL Humidistat / Ventilation Control OPTIONAL * Remove Jumper If Control Is Used Low Voltage Terminal R C D * G GT GF RF * N/C Saftey Switch 120 Volt 60Hz 15 Amp 1 Phase Power Supply JUMPER *C C Org Blu Brn Gry Wht Yel Red Humidistat Transformer Fan Relay 1 Blower Motor 2 3 4 5 6 7 8 Compressor Relay 6 2 8 4 7 3 Molex 50-84-1040 Blower Motor Run Capacitor Compressor Compressor Run Capacitor 1 Fr
PAGE 5
Wiring Unit Schematic When a remote Humidistat is utilized, set the unit mounted humidistat to the “OFF” position.
PAGE 6
Remote Humidity Control (Wall Mounted) When a remote Humidistat is utilized, set the unit mounted humidistat to the “OFF” position. This control provides the same control functions as above but with greater precision and can be located in the space for easier access, and may included additional features. Available as an accessory item these controls may have different features; refer to instructions included with the control.
PAGE 7
Limited Warranty Applies in U.S.A. and Canada Only FAILURE TO MAINTAIN YOUR EQUIPMENT WILL VOID THIS WARRANTY COVERED EQUIPMENT The following General Filters, Inc. equipment is covered by the Limited Warranty: Whole House Dehumidifier Units: DH95 (“Covered Equipment”) TWO (2) YEARS COVERAGE - RESIDENTIAL APPLICATIONS DH95 Parts are warranted by General Filters, Inc.
PAGE 8
LIMITATIONS OF REMEDIES OWNER’S SOLE AND EXCLUSIVE REMEDY UNDER THE ABOVE LIMITED WARRANTY AND COMPANY’S ENTIRE LIABILITY THEREUNDER, SHALL BE, AT THE SOLE OPTION OF COMPANY, REPLACEMENT OR REPAIR OF SUCH COVERED OR EXTENDED COVERAGE EQUIPMENT AND ITS COMPONENTS (“COMPONENTS”) BY COMPANY OR COMPANY’S AGENTS ONLY. REFRIGERANT, PIPING, SUPPLIES, TRANSPORTATION COSTS, LABOR COSTS INCURRED IN REPAIR OR REPLACEMENT OF SUCH COMPONENTS ARE NOT INCLUDED.