MODEL 1200 2000 Air Purification System installation and operation General Filters, Inc. 43800 Grand River Ave., Novi, Michigan 48375 Toll Free: (866) 476-5101 | Phone: (248) 476-5100 | Fax: (248) 349-2366 www.generalaire.
Table of Contents TERSus Installation & Maintenance Instructions TERSus Air Purification System Table of Contents Important Safety Instructions . Specifications . . . . . . . . . . . . . . Operation . . . . . . . . . . . . . . . . . . Cycle Times . . . . . . . . . . . . . . . . 1 . . 2 2-3 2-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIFICATIONS Model Tersus 1200: Model Tersus 2000: MFG: GeneralAire Model: TERSus1200 Power: 120V/60 Hz .6 Amps 49.2 Watts Fuse: Replace only with AGC-2 fuse Application: 3 Ton Drive Air Handler / Furnace Max Face Velocity: 500 FPM Max Air Flow: 1200 CFM Service: U.V. Lamps - 1 year / Filter – 6/12 months Replace: Only with LT016 UV lamps. Replace: Filter with only FI018 MERV-13 U.V. Range: 254 NM (germicidal) Catalyst: Metal Oxides 56 Sq.
OPERATION CONTINUED AIR CYCLES PER DAY Fan unit on for 10 minutes per hour Air cycled(24) ------ times per day Fan unit on for 15 minutes per hour Air cycled(31) ------ times per day Fan unit on for 20 minutes per hour Air cycled(42) ------ times per day Fan unit on for 30 minutes per hour Air cycled(63) ------ times per day Note: In the event, the existing thermostat does not have the capability to operate the air-handler fan unit independently of a demand for eating or air-conditioning, it is highly recom
Fig. 1 Fig. 2 Locking Knobs Changing the UV lamps 1. Unplug the power cord from the GeneralAire TERSus air purification system. Unscrew the two locking knobs and remove the door. (Fig. 3) 2. Remove Photocatalytic module. (Fig. 4) 3. Unplug UV lights, loosen retaining knobs, and remove UV lights. (Fig. 5, 6) 4. Replace UV Lights, re-tension retaining knobs, and replace plug-ins. 5.
For Replacement Filters and Ultraviolet Lamps Contact your local HVAC wholesaler or contractor. Or call, General Filters, Inc., 43800 Grand River Ave., Novi, MI 48375 at 866-476-5101. Installation Make sure to install the GeneralAire TERSus air purification system so that the inlet or return air enters the side containing the MERV13 particle filter first. Filter Side Catalyst Side Air Flow Typical vertical and horizontal installation 1.
Fig. 8 Fig. 9 5. Tape all seams between the air handler and the outlet side of the GeneralAire TERSus 1200/2000 so that there can be no air bypassing the system. 6. Attach the air handler to the outlet side of the GeneralAire TERSus 1200/2000 and fasten with #10 x 3/8 self- drilling sheet metal screws. Note: only 1/2 inch of clearance has been provided between the outer and inner case. 7. Slide the inner module into the outer encasement and tighten locking knobs finger tight.
5 Year Limited Warranty The TERSus1200 and TERSus2000 is delivered to you with a GeneralAire Five Year Limited Warranty. The MERV13 High Efficiency Filter Media is an expendable service item that is not covered under this warranty. The MERV13 Filter Media is recommended to be changed every 6 to 12 months as needed per your HVAC equipment operation. Serviceable replacement UVC Lamps are covered with a one year warranty free from defects or premature failure for a period of one year from the date of purchase.
Performance data Tersus Performance Data and approvals: For TERSus1200 11/2 - 3 Ton Drive Systems Air Flow & Resistance Data At MERV13: 400 800 1200 1600 0.09 0.18 0.30 0.38 144 288 433 577 For TERSus2000 31/2 - 5 Ton Drive Systems Air Flow & Resistance Data At MERV13: 1000 1500 2000 2500 0.18 0.30 0.38 0.
Wiring Diagram Model Tersus1200 & Tersus2000 Brand Decal Placement Air Flow Top to Bottom Brand Decal Placement Here Brand Decal Placement Here Air Flow Right to Left 9 Air Flow Left to Right Air Flow Bottom to Top
TERSus1200 / Tersus 2000 Air purification parts list Replacement UV Lamp (2 Required) for TERSus1200 and TERSus2000 Part Number LT016 GFI # 4564 Replacement MERV13 Electrostatic Filter for TERSus1200 for TERSus2000 Part Number FI021 FI020 GFI # 4572 4562 Electronic Lamp Ballast for TERSus1200 and TERSus2000 Part Number BL014 GFI # 4565 12 Vold Transformer for TERSus1200 and TERSus2000 Part Number BL007 GFI # 4566 Titanium/Honeycomb Catalyst for TERSus1200
General Filters, Inc. Canadian General Filters, LTD. Toll Free: (866) 476-5101 Phone: (248) 476-5100 Fax: (248) 349-2366 Toll Free: (866) 476-5101 Phone: (416) 757-3691 Fax: (416) 757-4687 www.generalaire.com www.cgfproducts.com 43800 Grand River Ave., Novi, Michigan 48375 400 Midwest Rd.