GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 1 OWNER’S MANUAL Model: GP324SS GEORGE FOREMAN Portable Stainless Steel Propane Grill ®
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 2 FOR YOUR SAFETY If you smell gas: 1. 2. 3. 4. Shut off gas to the appliance. Extinguish any open flame. Open Lid. If odor continues, immediately call your gas supplier or your fire department. WARNING 1. Do not store spare LP cylinder within 10 feet (3.05 m) of this appliance. 2. Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance. FOR YOUR SAFETY 1.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 3 IMPORTANT SAFEGUARDS WARNING: A risk of fire or explosion exists in all propane grills. Read this manual before use. Failure to follow all instructions may result in serious personal injury, property damage, or death. When using propane grills, basic safety precautions should always be followed to reduce the risk of fire and injury to persons, including the following: 1. Read all instructions before using the grill. 2. Do not touch hot surfaces.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 4 Additional Important Safeguards 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. CAUTION: This grill generates heat and escaping steam during use. Proper precautions must be taken to prevent the risk of burns, fires or other damage to persons or property. Use of protective oven mitts or gloves is recommended. All users of this grill must read and understand this Owner's Manual before operating or cleaning this grill.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 5 Special Instructions for the Use of Regulator and LP (Propane) Cylinders • The propane grill is equipped with a regulator CGA No. 600 having a CGA No. 600 cylinder connection device which is for connecting to a one pound PROPANE cylinder ONLY. See Illustration. • Grill installation must conform with local codes, or in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 6 Getting To Know Your GP324SS Portable Stainless Steel Propane Grill 1 2 3 4 5 6 7 8 14 9 15 12 10 11 13 16 1 Grilling Rack (P/N 22522) 2. Flame Diffuser/Drip Tray (P/N 22523) 3. Handle (P/N 22524) 4. Lid 5. Warming Rack Assembly (P/N 22525) 6. Flame Diffuser Support 7. Grilling Rack Support 8. 9. 10. 11. 12. 13. 14. 15. 16.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 7 Take-It and Grill-It Positions The GP324SS Portable Propane Grill is compact enough to transport to any grilling location. Take-It from storage to patio, to a picnic in the park, or off on a camping trip. The portable Propane Grill easily transforms from the Take-It to the Grill-It position. Storage and Transport In this position the Grill is compact enough for space saving storage and easy carrying.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 8 Before First Use 1. Remove the grill and any packaging materials from the shipping carton. 2. Place the Grill on a flat, level surface. 3. Pull out the front Leg in a sideways motion then swing it down while lifting up on the Grill. The Leg will 'snap' into place when properly positioned. Repeat this procedure with the rear Leg. Raise the Lid and remove the Warming Rack, the Grilling Rack and the Flame Diffuser. 4. Wash these parts in warm, soapy water.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 9 Attaching Regulator Assembly and Propane Gas Cylinder 1. Securely screw the Regulator Assembly onto the Venturi Tube. 2. Turn the Temperature Control Knob to the LOCK/OFF Position. Push the one pound propane cylinder slightly into the valve while turning counterclockwise until a snug fit is obtained. Do not turn the propane cylinder upside down while attaching to the Regulator Assembly.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 10 How To Use the George Foreman® GP324SS Propane Grill Checking the Ignitor: NOTE: Always open Lid before lighting your Grill. The Temperature Control Knob must be in the “LOCK/OFF” position. Press the Ignitor button rapidly. A “CLICK” should be heard and a spark seen through the Flame Viewing Hole. Lighting Burner with Ignitor: 1. Turn Temperature Control Knob counterclockwise to “OFF“, push in, and then turn the Temperature Control knob to "HIGH". 2.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 11 How To Use the George Foreman® GP324SS Propane Grill (Cont.) Grilling Instructions: 1. Light burner and turn the Temperature High Control Knob from HIGH to LOW. Check the flame through the Flame Viewing Low Hole, making sure the burner is lit. 2. To preheat: Close the Lid and preheat on HIGH for 8 minutes. During the first use, you may notice a slight odor caused by the curing of manufacturing oils.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 12 Instructions For Cleaning CAUTION: Grill surfaces are hot during use. Allow Grilling Rack, Flame Diffuser, Lid and Grill Body to cool completely before handling and cleaning. 1. Turn the Temperature Control Knob to the LOCK/OFF position and allow the Grill to cool before disassembling and cleaning. 2. Remove the propane cylinder and Regulator Assembly. 3 Remove the Grilling Rack and the Flame Diffuser/Drip Tray. Empty the Drip Tray compartments. 4.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 13 PLEASE NOTE: The United States Department of Agriculture recommends that meat and poultry be cooked to the following internal temperatures to be sure any harmful bacteria has been killed. Ground turkey and chicken should be cooked to an internal temperature of 165˚ F and ground beef, veal, lamb and pork should be cooked to an internal temperature of 160˚ F.
GR_GP324SS_IB_1-4-04 04/01/2004 18:06 Page 14 LIMITED ONE YEAR WARRANTY Warranty: This George Foreman® product is warranted by Salton, Inc. to be free from defects in materials or workmanship for a period of (1) year from the original purchase date. This product warranty covers only the original consumer purchaser of the product.