COOKERS INSTALLATION AND OPERATING INSTRUCTIONS All Glem and Emilia cooker models Glem Gas Australasia P/L 48 Percy Street Auburn NSW 2144 tel 1 300 307 917 fax +61 (02)9643 3599 info@glemgas.com.au www.glemgas.com.au IMPORTANT: This cooker is for domestic applications. It is NOT suitable for commercial applications of any kind. Do not install the cooker if there is any doubt. Contact Glem Gas Australasia if you require clarification.
Dear Customer, FIRST TIME USE Thank you for purchasing our product. IMPORTANT This manual has been written to assist you and instruct you in the operation of this appliance. It will help you get the best performance and make full use of the appliance's features. Remove all packing material and literature from the upright cooker before connecting the gas and electrical supply. The safety precautions and warnings are listed for your safety and the safety of others when operating this appliance.
MOVING THE COOKER When moving the cooker always use two people. ADJUSTABLE FEET (SOME MODELS) – before installing the cooker level the appliance using the adjustable feet or legs. When installed this cooker complies with all safety requirements however care must be taken when moving the cooker as some sharp edges and corners that are not intended to be touched could cause injury. DO NOT LIFT USING THE HANDLE – open the oven door and hold inside the top of the oven cavity.
INSTALLATION OF ANTI TILT BRACKET Install the legs to the cooker and adjust the height to the desired level. Make sure that this height is absolutely correct to what you require. On the rear of the cooker there is a covering panel. Accurately measure the distance from the top of this panel to the floor Height H. After the cooker is unpacked make sure that it is not damaged. If unsure please contact Glem Gas Australasia on 1 300 307 917. All packaging materials should be disposed of appropriately.
CLICK AND SLIDE INNER GLASS REMOVAL - SOME MODELS The models with the click and slide inner glass removal can be identified by the two circular press points located towards the top of the inner door. This allows for easy glass removal to clean the inside of the door.
OPERATION OF GAS HOB OPERATING THE GAS OVEN GAS BURNERS The oven is equipped with a gas thermostat. Its purpose is to keep the temperature at a constant heat. The oven is fitted with electronic spark ignition and a safety shut off device. The combination of high-speed burners with those of a standard type allows all types of cooking to be achieved. Burner Locations Lighting the Oven First open the oven door and remove the grill tray. Leave the grill tray out while operating the oven.
GAS Oven Preheating OPERATING THE ELECTRIC OVEN After the oven has been switched on, keep the door open for a minute then close the door gently so there is no risk of extinguishing the flame. Set the oven knob to the required temperature and wait for about 20 minutes before introducing the food. Comply with the cooking indication chart in these instructions to get the best out of the oven and choose the right shelf position. Multifunction Electric Oven - some models Remove the grill tray.
Oven operation notes: OVEN COOKING TABLE Dish Shelf Position (1 = Top Cakes Static Fan oven Static Fan oven 2 3 1 3 2 3 1 2 2 23 23 12 23 23 23 12 23 23 180 - 190 130 - 150 190 - 200 175 - 190 185 - 200 190 - 200 190 - 230 195 - 210 195 - 200 180 130 180 - 190 165 - 180 185 - 200 180 - 190 180 - 190 185 185 - 200 35 - 40 30 - 35 18 - 20 (35 cakes) 35 - 45 40 - 50 40 - 45 17 (35 scones) 35 - 45 35 - 45 3 2 3 3 23 2 23 23 190 - 200 180 220 - 240 230 - 250 180 - 190 165 190 - 220 200 - 230 25
GRILL COOKING TABLE Dish Toasted Sandwiches Hamburgers Fish Kebabs Shellfish Sausage Pork Chops Meat Kebabs Steaks Chicken Shelf Position CLEANING AND MAINTENANCE Temperature Degrees C 1 1 1 1 1 1 1 1 1 Cooking Time in minutes 250 250 250 250 250 250 250 250 250 3 -4 5 -7 6-8 6-8 7 - 10 7 - 10 8 - 10 8 - 12 8 - 12 • For recipes where this is required, a preheating period of 4-5 minutes will be sufficient. • The times indicated in the table refer to grilling one side of food only.
5. Cleaning of Oven Door: The outer glass should be cleaned with a specific glass and mirror cleaner. Soapy water will remove stains and but may leave streaks. Do not use abrasive or aggressive cleaners on aluminium door frame components, if in doubt contact Glem Gas for advice. INSTALLATION INSTRUCTIONS These instructions are for the use of a qualified installer only! 6.
1.Location of gas inlet Rangehoods Rangehoods and overhead exhaust fans must be installed according to manufacturers’ instructions. Rangehoods should be installed not lower than 650mm above the cooktop. Ventilation A cooker should not be installed in any room which has a volume less than 5.6 cu. m. (200 cu. ft.). If the room is between 5.6 Cu. m. (200 cu. ft.) and 11.2 cu. m. (400 Cu. ft.) in volume, provision must be made for permanent ventilation. Above 11.2 cu. m. (400 cu. ft.
Before connecting the plug into the power socket, follow these instructions: • The electrical supply for the upright cooker must be a 240 Volt 50 Hz. • The fuse and electrical wiring of the dwelling must support the load of the appliance. • The 3-pin plug, used to connect the electricity, must be easily reached when the upright cooker is in its installed position.
NOTE! CONVERSION TO OPERATE ON ULPG This must be done by a licensed Gas Fitter. COMPULSORY Included with the cooker is a conversion kit for converting the cooker to operate on ULPG (LPG in Aust.). The kit consists of replacement injectors for all burners, including oven burner for gas models. The kit also includes a test point for checking gas pressure and a replacement label identifying the type of gas the cooker is connected to.
FINAL CHECK QUICK REFERENCE FAULT FINDING CHART Operate all cooker burners on high and low flames and check that each burner ignites properly and has a stable flame. The following may be considered to be abnormal: GAS COOKTOP • If the burners have yellow tipping. • If the pots are sooting up underneath. • If the burners are extinguished by opening and closing the oven door. • If the burners fail to ignite properly. • If the burners fail to remain alight.
CORRECT COOKTOP BURNER ASSEMBLY PRODUCT WARRANTY Sometimes when a burner is difficult to light is it simply due to the burner not being correctly assembled. See the assembly procedure below. All parts must be aligned correctly for the burner to operate. Thank you for choosing a Glem Gas Appliance, the purchase of this appliance is an important investment in your home and so to protect your investment we urge you to complete the registration card attached, please return it immediately.
h) If you live outside the service area of the Glem Gas Australasia service agents this warranty does not cover the cost of transport of the appliance for service or the service agent’s travelling time. INSTALLER’S CHECK LIST 3. This warranty does not cover any glass damage or replacement of light bulbs. The following checks have to be made to commission the cooker and to activate the warranty: 4.