Instruction Manual

ManualsBrandsGolden Blount ManualsKilnSizzler Jr

TEXAS SIZZLER “JR”

INFRA-RED GAS GRILL

OWNER’S MANUAL

FOR OUTDOOR USE ONLY

CONTENTS:

▪ Location Requirements. . . . . . . . . . . 1

▪ Assembly . . . . . . . . . . . . . . . . . . . . . . 1

▪ Gas Connection . . . . . . . . . . . . . . . . . 3

▪ Operation . . . . . . . . . . . . . . . . . . . . . . 4

▪ Maintenance and Cleaning . . . . . . . . 6

▪ Replacement Parts. . . . . . . . . . . . . . . 7

▪ Troubleshooting . . . . . . . . . . . . . . . . . 7

▪ Warranty . . . . . . . . . . . . . . . . . . . . . . . 8

FOR YOUR

SAFETY

If you smell gas:

1. Shut off gas to the

appliance.

2. Extinguish any open

flame.

3. Open lid.

4. If odor continues,

immediately call

your gas supplier

or your fire

department.

FOR YOUR

SAFETY

1. Do not store or use

gasoline or other

flammable vapors

or liquids in the

vicinity of this or

any other

appliance.

2. An LP Cylinder not

connected for use

shall not be stored

in the vicinity of

this or any other

appliance.

Golden Blount Inc.

4301 Westgrove Dr., Addison, Texas 75001

(972) 250-3113

Summary of content (9 pages)

PAGE 1
TEXAS SIZZLER “JR” INFRA-RED GAS GRILL OWNER’S MANUAL FOR OUTDOOR USE ONLY FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. CONTENTS: ▪ ▪ ▪ ▪ ▪ ▪ ▪ ▪ Location Requirements . . . . . . . . . . . 1 Assembly . . . . . . . . . . . . . . . . . . . . . . 1 Gas Connection . . . . . . . . . . . . . . . . . 3 Operation . . . . . . . . . . . . . . . . . . . . . .
PAGE 2
LOCATION REQUIREMENTS: WARNING: This appliance should not be located closer than 10 inches to any adjacent combustible surface or under any unprotected combustible construction. WARNING: This appliance is designed for outdoor use only. This appliance must be on a level, stable surface in an open area. Do not locate this appliance in a confined space. Heat and smoke will rise from this appliance so covered locations should be avoided. Minimum clearances must be maintained when using this appliance.
PAGE 3
Optional Pedestal Base With Shelves: 1. 2. 3. 4. 5. Carefully remove grill from carton. Remove pedestal base from carton and locate hardware to attach grill to pedestal. Position pedestal on flat surface and locate (4) holes on each corner of “x” brace on top of pedestal. (Figure 3.) Position grill on top of “x” brace and align holes in grill bottom with holes in “x” brace. Attach (4) bolts with washers in each hole and tighten. (Figure 4.) 6.
PAGE 4
GAS CONNECTION: The Texas Sizzler “JR” is offered in one of two gas types: LP or Natural Gas. LP models include pressure regulator and quick connect adapter for disposable LP cylinders. (Pressure regulator, hose assembly and quick connect adapter for 20 lb. cylinder included with optional pedestal base or can be purchase separately.) Natural Gas models include pressure regulator and quick connect adapter. LP Gas Cylinder Safety: NOTE: An LP gas cylinder is not provided with this grill. Only D.O.T.
PAGE 5
Connecting the Cylinder (20 lb) 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. Turn cylinder valve hand wheel clockwise until it stops. Make sure burner control knob is in the “OFF” position. Position grill in open area that is level. Position cylinder in safe location and where hose will be positioned to prevent tripping. Remove protective cap from gas connection plug on side of grill. Attach the hose end of the regulator to the grill using “QUICK DISCONNECT” instructions. (Figure 6.
PAGE 6
. If flame is not present, turn burner control knob to “OFF” position, leave cover open and wait 5 minutes. Repeat steps 3 through 6 until ignition occurs. 7. Rotate burner control knob to desired cooking level. 8. To turn off grill, push in and turn burner control knob to the “OFF” position. Lighting Burner Without Igniter: If the igniter is not working properly, the burner can be lit manually using a long match or extended nozzle butane lighter. Manual Lighting Procedure: 1. 2. 3. 4. Open cover.
PAGE 7
Cooking Hints: 1. When handling meat, use a spatula or tongs, instead of a fork. When meat is pierced the natural juices will leak out. 2. Upon initial use, start off with hamburgers or hot dogs to become familiar with infra-red cooking. 3. To reduce excessive flare-ups: A. Trim excess fat. B. Pre-heat on high at least 5 minutes. C. Keep cooking grids clean after each use. Cooking Guidelines: Meat Temperature Setting Cooking Time Steak 1 1/2” Thick High fire 3 min. each side. High fire 2 min.
PAGE 8
REPLACEMENT PARTS LIST: Item Description jr-cerelm Ceramic element kit w/gasket jr-burn Burner housing jr-scrn Burner screen jr-bcv Burner control valve jr-ldhdl Lid handle jr-bck Burner control knob jr-elec Electrode jr-ign Igniter jr-cgrid Cooking grid jr-dpan Drip pan jr-orinat Natural orifice jr-orilp LP orifice jr-regnat Natural regulator jr-reglp LP regulator TROUBLESHOOTING: Problem Probable Cause Remedy Burner will not light when igniter is pushed A. Lack of gas B.
PAGE 9
TEXAS SIZZLER INFRA-RED STAINLESS STEEL GAS GRILLS WARRANTY ALL STAINLESS STEEL CABINET PARTS ARE WARRANTED AGAINST DEFECTIVE MATERIAL AND/OR WORKMANSHIP FOR LIFETIME TO THE ORIGINAL CONSUMER BUYER UNDER THE TERMS STATED BELOW. DISCOLORATION OR OXIDATION IS EXCLUDED. *IGNITER WARRANTED FOR 1 YEAR. ALL OTHER PARTS ARE GUARANTEED FOR 10 YEARS UNDER NORMAL USE.