User Guide

ManualsBrandsGOODMAN ManualsForced Air Furnaces96% AFUE 120,000 BTU Multi Positional 2-Stage Variable Speed Natural Gas Furnace with 24.5 in. Cabinet

GAS-FIRED WARM AIR FURNACE

USER’S INFORMATION MANUAL

Installer - Affix this manual, Installation Guide, and Warranty adjacent to the appliance.

Owner - Read and keep all product literature in a safe place for future reference.

RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.

Due to policy of continual product

improvement, the right is reserved to

change specifications and design

without notice.

HOULD

OVERHEATING

OCCUR

THE

GAS

SUPPLY

FAIL

SHUT

OFF

TURN

OFF

THE

MANUAL

GAS

SHUTOFF

VALVE

EXTERNAL

THE

FURNACE

BEFORE

TURNING

OFF

THE

ELECTRICAL

SUPPLY

WARNING

PREVENT

POSSIBLE

PROPERTY

DAMAGE

PERSONAL

INJURY

DEATH

DUE

ELECTRICAL

SHOCK

THE

FURNACE

MUST

LOCATED

PROTECT

THE

ELECTRICAL

COMPONENTS

FROM

WATER

WARNING

RODUCT

CONTAINS

FIBERGLASS

WOOL

. D

ISTURBING

THE

INSULATION

THIS

PRODUCT

DURING

INSTALLATION

MAINTENANCE

REPAIR

WILL

EXPOSE

YOU

FIBERGLASS

WOOL

. B

REATHING

THIS

MAY

CAUSE

LUNG

CANCER

. (F

IBERGLASS

WOOL

KNOWN

THE

TATE

ALIFORNIA

CAUSE

CANCER

.) T

REDUCE

EXPOSURE

FOR

FURTHER

INFORMATION

CONSULT

MATERIAL

SAFETY

DATA

SHEETS

AVAILABLE

FROM

THE

ADDRESS

SHOWN

BELOW

WARNING

THE

INFORMATION

THESE

INSTRUCTIONS

NOT

FOLLOWED

EXACTLY

FIRE

EXPLOSION

MAY

RESULT

CAUSING

PROPERTY

NOT

STORE

USE

GASOLINE

OTHER

FLAMMABLE

VAPORS

AND

LIQUIDS

THE

VICINITY

THIS

ANY

OTHER

APPLIANCE

NOT

TRY

LIGHT

ANY

APPLIANCE

NOT

TOUCH

ANY

ELECTRICAL

SWITCH

;

NOT

USE

ANY

PHONE

YOUR

BUILDING

MMEDIATELY

CALL

YOUR

GAS

SUPPLIER

FROM

NEIGHBOR

’

PHONE

. F

OLLOW

THE

GAS

SUPPLIER

’

INSTRUCTIONS

YOU

CANNOT

REACH

YOUR

GAS

SUPPLIER

CALL

THE

FIRE

DEPARTMENT

NSTALLATION

AND

SERVICE

MUST

PERFORMED

QUALIFIED

INSTALLER

SERVICE

AGENCY

THE

GAS

•

5151 San Felipe Suite 500

Houston, TX 77056

www.goodmanmfg.com • www.amana-hac.com

HI-131

7/2014

Summary of content (12 pages)

PAGE 1
GAS-FIRED WARM AIR FURNACE USER’S INFORMATION MANUAL WARNING IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. • DO NOT TRY TO LIGHT ANY APPLIANCE. • DO NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE ANY PHONE IN YOUR BUILDING. I • MMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR’S PHONE. FOLLOW THE GAS SUPPLIER’S .
PAGE 2
Contents IMPORTANT NOTE TO THE OWNER REGARDING PRODUCT WARRANTY .......................................................................... 3 UNIT LOCATION ................................................................................................................................................. 3 UNIT INSTALLATION ............................................................................................................................................. 4 Air Requirements ..............................
PAGE 3
Dear Homeowner, please recognize the following safety information. This information will alert you to the potential for personal injury. 2. Do not store or use chlorine or fluorine products (bleaches, cements, strippers, aerosols) near the unit. They can corrode the heat exchanger. 3. Do not use the furnace closet as storage for brooms, mops, brushes and oily rags or cloths. The area must be kept clear, clean and free of lint.
PAGE 4
1. Headaches, Nausea, Dizziness, Flu-like symptoms. AIR REQUIREMENTS 2. Excessive humidity, heavily frosted windows or a moist “clammy” feeling in the home. WARNING 3. Smoke from a fireplace will not draw up the chimney. TO AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, SUFFICIENT FRESH AIR FOR PROPER COMBUSTION AND VENTILATION OF FLUE GASES MUST BE SUPPLIED. MOST HOMES REQUIRE OUTSIDE AIR BE SUPPLIED INTO THE FURNACE AREA. 4. Flue gases that will not draw up the appliance vent pipe.
PAGE 5
ing functions. The level of this control depends on the type of thermostat applied. Outdoor Humidity Temperature Single -Paned Double-Paned Glass Glass +30°F 30% 50% +20°F 20% 40% +10°F 15% 35% 0°F 10% 30% -10°F 5% 25% -20°F 5% 20% -30°F 3% 18% Room Temperature Thermostat Cool/Heat Temperature Control Dials PROPANE (LP) GAS INSTALLATIONS ONLY For furnaces operating on propane gas, please review the following warnings before use.
PAGE 6
5. This furnace is equipped with an ignition device which automatically lights the burner. Do not try to light the burner by hand. 6. Move the furnace’s gas valve ON/OFF switch to the OFF position. 7. Wait five minutes to clear out any gas. Then smell for gas, including near the floor as some types of gas are heavier than air. 8. If you smell gas following the five minute waiting period in step 7, immediately follow the instructions on the cover of this manual.
PAGE 7
ROUTINE MAINTENANCE • Drainage system. Check for blockage and/or leakage. Check hose connections at and internal to furnace. Maintenance is to be performed by a qualified service technician only. User maintenance is to be restricted to frequent air filter changes and to ensure the warnings and notices found elsewhere in this manual be followed.
PAGE 8
To remove all other filter configurations, consult with the installing contractor. • Check thermostat for proper operation. Verify that it is set on HEAT and that temperature (above room temperature) setting is appropriate. MEDIA AIR FILTER OR ELECTRONIC AIR CLEANER REMOVAL • Check the electrical panel for tripped circuit breakers or failed fuses. Reset the circuit breakers or replace fuses as necessary. High efficiency filters are available in both electronic and nonelectronic types.
PAGE 9
SAFETY LABELS NOTE: If safety labels are missing or illegible, contact the installing dealer or our Customer Service Department for ordering information.
PAGE 10
SAFETY LABELS WARNING RISK OF ELECTRIC SHOCK. CAN CAUSE INJURY OR DEATH: DISCONNECT ALL REMOTE ELECTRIC POWER SUPPLIES BEFORE SERVICING. THIS COMPARTMENT MUST BE CLOSED EXCEPT WHEN SERVICING. AVERTISSEMENT DANGER DE CHOC ELETRIQUE OU DE MORT. COUPEZ TOUT LE COURANT AVANT TOUT ENTRETIEN OU REPARATION. LE COMPARTEMENT DOIT RESTER FERMER SAUF PENDANT LENTRETIEN.
PAGE 11
THIS PAGE INTENTIONALLY LEFT BLANK 11
PAGE 12
Most questions can be answered by your local dealer. For additional information, please call: CONSUMER INFORMATION LINE TOLL FREE 1-877-254-4729 (U.S. only) email us at: customerservice@goodmanmfg.com fax us at: (731) 856-1821 (Not a technical assistance line for dealers.) Outside the U.S., call 1-713-861-2500. (Not a technical assistance line for dealers.) Your telephone company will bill you for the call. To obtain the proper labels, the Model Number and Serial Number of the unit must be supplied.