GPG14M User Mannual

ManualsBrandsGOODMAN ManualsAir Conditioners2 Ton 14 SEER 81% AFUE 40,000 BTU Heating R-410A Multi-Position Package Air Conditioner with Gas

F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION

MAY RESULT CAUSING PROPERTY DA

AGE, PERSONAL INJURY

OR LOSS OF LIFE.

–

O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE

VICINITY OF THIS OR ANY OTHER APPLIANCE.

–

WHAT

SMEL

GAS

•

T TRY TO LIGHT ANY APPLIANCE.

•

NOT TOUCH ANY ELEC

TRICAL SWITCH; DO NOT

USE ANY PHONE IN YOU

UILDING.

•

MME

IATELY CALL

YOUR GAS

SUPPLIER FR

OM A NEIGHB

R’S PHONE.

LLOW THE GAS

SUPPLIER’S INSTRUCTIONS.

•

F YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.

–

NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER, SERVI

AGENCY

OR THE GAS SUPPLIER.

WARNING

Goodman Manufacturing Company, L.P.

19001 Kermier Rd., Waller, TX 77484

www.goodmanmfg.com

USER’S INFORMATION MANUAL

Package Gas-Electric

Installer - Ax this manual, Installation Guide, and Warranty adjacent to the appliance.

Owner - Read and keep all product literature in a safe place for future reference.

RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.

HI-116G

5/2020

WARNING

HOU

LD OVERHEATING OCCUR, OR THE GAS SUPPLY FAIL TO SHUT OFF,

SHUT OFF THE MANUAL GAS VALVE TO THE FURNACE BEFORE SHUTTING OFF

THE ELECTRICAL SUPPLY.

WARNING

O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DO NOT USE

THIS

FURNACE

NY PART OF

THE FURNA

HAS BEEN

NDER WAT

MMEDIATELY CALL A

QUALIFIED SERVICE TECHNICIAN TO INSPECT THE

FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY

GAS CONTROL HAVING BEEN UNDER WATER.

WARNING

PROP 65 WARNING

FOR CALIFORNIA CONSUMERS

Cancer and Reproductive Harm -

www.P65Warnings.ca.gov

0140M00517-A































WARNING

Summary of content (12 pages)

PAGE 1
Package Gas-Electric USER’S INFORMATION MANUAL WARNING IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. – DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. – WHAT TO DO IF YOU SMELL GAS: • DO NOT TRY TO LIGHT ANY APPLIANCE. • DO NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE ANY PHONE IN YOUR BUILDING.
PAGE 2
General Information Signal Words Dear Homeowner, please recognize the following safety information. This information will alert you to the potential for personal injury. WARNING - Indicate hazards or unsafe practices which COULD result in severe personal injury or death. WARNING THIS PRODUCT CONTAINS OR PRODUCES A CHEMICAL OR CHEMICALS WHICH MAY CAUSE SERIOUS ILLNESS OR DEATH AND WHICH ARE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
PAGE 3
AVERTISSEMENT FIRE OR EXPLOSION HAZARD Failure to follow the safety warnings exactly could result in serious injury, death or property damage. — Do not store or use gasoline or other flammable vapors and liquids in the vacinity of this or any other appliance. — WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Leave the building immediately. • Immediately call your gas supplier from a neighbor’s phone.
PAGE 4
No matter the type or style, thermostat operation is basically the same. The most widely used types will control both heating and cooling functions and will have a Fan Switch with Auto and ON settings. On Auto, the Circulating Air Blower will cycle on/off, but if switched to ON it will run constantly. Propane (LP) Gas Installations Only For units operating on propane gas, please review the following warnings before use.
PAGE 5
Heating Start Up Gas Valve On/Off Selector Switch To put your unit into operation, follow the steps listed below. INLET 2. Turn off the electrical power to the unit. ON OFF 1. Close the external manual gas shutoff valve. * * * * 3. Set the room thermostat to the lowest possible setting. 4. Remove the heat exchanger door on the side of the unit by removing screws. * 5. This unit is equipped with an ignition device which automatically lights the burner. Do not try to light the burner by hand.
PAGE 6
supply when burner box temperature exceeds designed set point. The limit will automatically reset when the burner box temperature drops below designed set point. The control would enter a one hour lockout if the limit exceeds maximum recovery time of 5 minutes or if the limit has tripped three times in same heating call. Safety Circuits A number of safety circuits are employed to ensure safe and proper unit operation.
PAGE 7
Indoor Air Circulator Blower • Return Air Connection. Check for physical soundness and ensure that the connection is firmly sealed to the package unit casing. Keep the blower access door panel in place except for inspection and maintenance. Routine Maintenance • Heat exchanger. Check for corrosion and/or obstructions within the heat exchanger passageways.
PAGE 8
Safety Labels NOTE: If safety labels are missing or illegible, contact the installing dealer. To obtain the proper safety labels, the Model and Serial Number of the unit must be supplied. These numbers are recorded on the nameplate of the unit. For convenience, record this information here: MODEL NUMBER:_____________________________________ SERIAL NUMBER:_____________________________________ WARNING HAZARD OF ELECTRIC SHOCK. DISCONNECT THE ELECTRIC POWER BEFORE SERVICING.
PAGE 9
SAFETY LABELS F OR YOUR S AF E TY R E AD B E F OR E OP E R ATING If you do not follow thes e ins tructions exactly, a fire or explos ion may res ult caus ing property damage, pers onal injury or los s of life. A. T his appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burners . Do not try to light the burners by hand. B . B E F OR E OP E R AT ING s mell around the appliance area for gas .
PAGE 10
SAFETY LABELS FOR YOUR SAFETY READ BEFORE OPERATING If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burners. Do not try to light the burners by hand. B. BEFORE OPERATING smell all around the appliance area for gas.
PAGE 11
SAFETY LABELS because some gas is heavier than air and will 11
PAGE 12
CUSTOMER FEEDBACK We are very interested in all product comments. Please fill out the feedback form on one of the following links: Goodman® Brand Products: (http://www.goodmanmfg.com/about/contact-us). Amana® Brand Products: (http://www.amana-hac.com/about-us/contact-us). You can also scan the QR code on the right for the product brand you purchased to be directed to the feedback page. GOODMAN® BRAND AMANA® BRAND For Additional Information Most questions can be answered by your local dealer.