User Information

ManualsBrandsGOODMAN ManualsAir Conditioners3 Ton 34,200 BTU 14 SEER 81% AFUE 60,000 BTU Heating R-410A Multi-Position Package Air Conditioner with Gas

Goodman Manufacturing Company, L.P.

5151 San Felipe, Suite 500, Houston, TX 77056

www.goodmanmfg.com

USER’S INFORMATION MANUAL

ACKAGE

-E

LECTRIC

F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION

MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

–

O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE

VICINITY OF THIS OR ANY OTHER APPLIANCE.

–

WHAT

YOU

SMELL

GAS

•

DO NOT TRY TO LIGHT ANY APPLIANCE.

•

O NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE ANY PHONE IN YOUR BUILDING.

•

MMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR’S PHONE.

OLLOW THE GAS

SUPPLIER’S INSTRUCTIONS.

•

F YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.

–

NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER, SERVICE AGENCY

OR THE GAS SUPPLIER.

WARNING

Installer - Affix this manual, Installation Guide, and Warranty adjacent to the appliance.

Owner - Read and keep all product literature in a safe place for future reference.

WARNING

HOULD OVERHEATING OCCUR, OR THE GAS SUPPLY FAIL TO SHUT OFF,

SHUT OFF THE MANUAL GAS VALVE TO THE FURNACE BEFORE SHUTTING OFF

THE ELECTRICAL SUPPLY.

WARNING

O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DO NOT USE

THIS FURNACE IF ANY PART OF THE FURNACE HAS BEEN UNDER WATER.

MMEDIATELY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE

FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY

GAS CONTROL HAVING BEEN UNDER WATER.

WARNING

RODUCT CONTAINS FIBERGLASS WOOL.

ISTURBING THE INSULATION IN

THIS PRODUCT DURING INSTALLATION, MAINTENANCE, OR REPAIR WILL

EXPOSE YOU TO FIBERGLASS WOOL.

REATHING THIS MAY CAUSE LUNG

CANCER. (

IBERGLASS WOOL IS KNOWN TO THE

TATE OF

ALIFORNIA TO

CAUSE CANCER.)

IBERGLASS WOOL MAY ALSO CAUSE RESPIRATORY, SKIN,

AND EYE IRRITATION.

O REDUCE EXPOSURE OR FOR FURTHER

INFORMATION, CONSULT MATERIAL SAFETY DATA SHEETS.

RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.

HI-116E

7/15

Summary of content (12 pages)

PAGE 1
PACKAGE GAS-ELECTRIC USER’S INFORMATION MANUAL WARNING IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. – DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. – WHAT TO DO IF YOU SMELL GAS: • DO NOT TRY TO LIGHT ANY APPLIANCE. • DO NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE ANY PHONE IN YOUR BUILDING.
PAGE 2
SIGNAL WORDS GENERAL INFORMATION Dear Homeowner, please recognize the following safety information. This information will alert you to the potential for personal injury. UNIT LOCATION This unit is approved only for an outdoor installation. See the installation instructions for the required clearances to the unit. It is important that safety measures are taken in the surrounding area of the unit. WARNING - Indicate hazards or unsafe practices which COULD result in severe personal injury or death.
PAGE 3
WARNING WARNING PERSONAL INJURY OR DEATH FROM ASPHYXIATION CAN RESULT FROM CARBON MONOXIDE OR “CO” IS A TO AVOID PERSONAL INJURY OR FIRE, MINIMUM CLEARANCES TO EXPOSURE TO CARBON MONOXIDE. COMBUSTIBLE SURFACES MUST BE FOLLOWED. COLORLESS AND ODORLESS GAS PRODUCED WHEN FUEL IS NOT BURNED AIR REQUIREMENTS COMPLETELY OR WHEN THE FLAME DOES NOT RECEIVE SUFFICIENT OXYGEN.
PAGE 4
6. Move the gas control switch to the OFF position. Do not use excessive force. THERMOSTAT This unit will not operate properly without a good quality, correctly installed thermostat. It is very important that the thermostat be located where it can best “sense” the average room temperature. Be sure the thermostat is not exposed to hot or cold drafts or to hot or cold spots on the wall, such as those received from outside walls, walls with pipes inside, or from openings into the attic. 7.
PAGE 5
SECONDARY LIMIT The secondary limit control is located on the blower housing and monitors blower compartment temperatures. It is a normally closed (electrically), automatic reset, temperature activated sensor. This limit guards against overheating as a result of insufficient conditioned air passing over the heat exchanger. It deenergizes the gas valve if the blower fails.
PAGE 6
COMPRESSOR PROTECTION DEVICES This gas/electric package unit includes components which are designed to protect the compressor against abnormal operating conditions. ANNUAL INSPECTION Your package unit should be inspected by a qualified installer, or service agency at least twice every year. This check should be performed before the heating and cooling seasons begin. This will ensure that adequate combustion air is being drawn and the vent system is working properly.
PAGE 7
REPLACING OR CLEANING FILTER CLEAN OUTSIDE COIL (QUALIFIED SERVICER ONLY) IMPORTANT NOTE: Never operate unit without a filter installed as dust and lint will build up on internal parts resulting in loss of efficiency, equipment damage and possible fire. WARNING A return air filter is not supplied with this unit; however, there must be a means of filtering the return air. The filter(s) may be located in the return air duct(s).
PAGE 8
SAFETY LABELS RISQUE D'EMPOISONNEMENT AU MONOXYDE DE CARBONE Advertencia especial para la instalación de calentadores ó manejadoras de aire en áreas cerradas como estacionamientos ó cuartos de servicio. Las emisiones de monóxido de carbono pueden circular a través del aparato cuando se opera en cualquier modo. CO can cause serious illness including permanent brain damage or death.
PAGE 9
SAFETY LABELS F OR Y OUR S AF E TY R E AD B E F OR E OP E R ATING If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burners. Do not try to light the burners by hand. B . BE FOR E OPE R AT ING smell around the appliance area for gas.
PAGE 10
SAFETY LABELS FOR YOUR SAFETY READ BEFORE OPERATING If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burners. Do not try to light the burners by hand. B. BEFORE OPERATING smell all around the appliance area for gas.
PAGE 11
SAFETY LABELS because some gas is heavier than air and will 11
PAGE 12
Goodman Manufacturing Company, L.P. 5151 San Felipe, Suite 500, Houston, TX 77056 www.goodmanmfg.