Installation Guide
3
G
OODMAN
DAMAGE
ARISING
FROM
IMPROPER
SERVICE
OR
SERVICE
PROCEDURES
.
I
F
YOU
INSTALL
OR
PERFORM
SERVICE
ON
THIS
UNIT
,
YOU
ASSUME
RESPONSIBILITY
FOR
ANY
PERSONAL
INJURY
OR
PROPERTY
DAMAGE
WHICH
MAY
RESULT
. M
ANY
JURISDICTIONS
REQUIRE
A
LICENSE
TO
INSTALL
OR
SERVICE
HEATING
AND
AIR
CONDITIONING
EQUIPMENT
.
WILL
NOT
BE
RESPONSIBLE
FOR
ANY
INJURY
OR
PROPERTY
WARNING
S
AFETY
C
ONSIDERATIONS
Adhere to the following warnings and cautions when installing,
adjusting, altering, servicing, or operating the furnace. To ensure
proper installation and operation, thoroughly read this manual
for specifics pertaining to the installation and application of this
product.
This furnace is manufactured for use with natural gas. It may be
field converted to operate on L.P. gas by using the appropriate L.P.
conversion kit listed in the PROPANE GAS/HIGH ALTITUDE
INSTALLATIONS section of this manual
Install this furnace only in a location and position as specified in
LOCATION REQUIREMENTS & CONSIDERATIONS section and
INSTALLATION POSITIONS section of this manual.
Provide adequate combustion and ventilation air to the furnace
as specified in COMBUSTION & VENTILATION AIR REQUIREMENTS
section of this manual.
Combustion products must be discharged to the outdoors. Connect
this furnace to an approved vent system only, as specified in
CATEGORY 1 VENTING section of this manual.
Never test for gas leaks with an open flame. Use a commercially
available soap solution made specifically for the detection of
leaks to check all connections, as specified in GAS SUPPLY AND
PIPING section of this manual.
Always install a furnace to operate within the furnace’s intended
temperature-rise range with a duct system which has external
static pressure within the allowable range, as specified on the
furnace rating plate and OPERATIONAL CHECKS section of these
instructions.
When a furnace is installed so that supply ducts carry air circulated
by the furnace to areas outside the space containing the furnace,
the return air shall also be handled by duct(s) sealed to the furnace
casing and terminating outside the space containing the furnace.
A gas-fired furnace for installation in a residential garage must
be installed as specified in the LOCATION REQUIREMENTS AND
CONSIDERATIONS section of this manual.
This furnace may be used as a construction site heater only if
certain conditions are met. These conditions are listed in the
PRODUCT APPLICATION section of this manual.
T
O
PREVENT
PERSONAL
INJURY
OR
DEATH
DUE
TO
IMPROPER
INSTALLATION
,
ADJUSTMENT
,
ALTERATION
,
SERVICE
OR
MAINTENANCE
,
REFER
TO
THIS
MANUAL
. F
OR
ADDITIONAL
ASSISTANCE
OR
INFORMATION
,
CONSULT
A
QUALIFIED
INSTALLER
,
SERVICER
AGENCY
OR
THE
GAS
SUPPLIER
.
WARNING
FIRE OR EXPLOSION HAZARD
F
AILURE
TO
FOLLOW
THE
SAFETY
WARNINGS
EXACTLY
COULD
RESULT
IN
SERIOUS
INJURY
,
DEATH
OR
PROPERTY
DAMAGE
. N
EVER
TEST
FOR
GAS
LEAKS
WITH
AN
OPEN
FLAME
. U
SE
COMMERCIALLY
AVAILABLE
SOAP
SOLUTION
MADE
SPECIFICALLY
FOR
THE
DETECTION
OF
LEAKS
TO
CHECK
ALL
CONNECTIONS
. A
FIRE
OR
EXPLOSION
MAY
RESULT
CAUSING
PROPERTY
DAMAGE
,
PERSONAL
INJURY
OR
LOSS
OF
LIFE
.
RISQUE D’INCENDIE OU D’EXPLOSION
S
I
L
ES
C
ONSIGNES
D
E
S
ÉCURITÉ
N
E
S
ONT
P
AS
S
UIVIES
À L
A
L
ETTRE
, C
ELA
P
EUT
E
NTRAÎNER
L
A
M
ORT
, D
E
G
RAVES
B
LESSURES
O
U
D
ES
D
OMMAGES
M
ATÉ RIELS
. N
E
J
AMAIS
V
É RIFIER
L
A
P
RÉ SENCE
D
E
F
UITES
D
E
G
AZ
A
U
M
OYEN
D'
UNE
F
LAMME
N
UE
. V
É RIFIER
T
OUS
L
ES
R
ACCORDS
E
N
U
TILISANT
U
NE
S
OLUTION
S
AVONNEUSE
C
OMMERCIALE
C
ONÇUE
S
PÉ CIALEMENT
P
OUR
L
A
D
ÉTECTION
D
E
F
UITES
. U
N
I
NCENDIE
O
U
U
NE
E
XPLOSION
R
ISQUE
D
E
S
E
P
RODUIRE
, C
E
Q
UI
P
EUT
E
NTRAÎNER
L
A
M
ORT
, D
ES
B
LESSURES
O
U
D
ES
D
OMMAGES
M
ATÉ RIELS
.
I
F
THE
INFORMATION
IN
THESE
INSTRUCTIONS
IS
NOT
FOLLOWED
EXACTLY
,
A
FIRE
OR
EXPLOSION
MAY
RESULT
CAUSING
PROPERTY
DAMAGE
,
PERSONAL
INJURY
OR
LOSS
OF
LIFE
.
D
O
NOT
STORE
OR
USE
GASOLINE
OR
OTHER
FLAMMABLE
VAPORS
AND
LIQUIDS
IN
THE
VICINITY
OF
THIS
OR
ANY
OTHER
APPLIANCE
.
D
O
NOT
TRY
TO
LIGHT
ANY
APPLIANCE
.
D
O
NOT
TOUCH
ANY
ELECTRICAL
SWITCH
;
DO
NOT
USE
ANY
PHONE
IN
YOUR
BUILDING
.
I
MMEDIATELY
CALL
YOUR
GAS
SUPPLIER
FROM
A
NEIGHBOR
’
S
PHONE
. F
OLLOW
THE
GAS
SUPPLIER
’
S
INSTRUCTIONS
.
I
F
YOU
CANNOT
REACH
YOUR
GAS
SUPPLIER
,
CALL
THE
FIRE
DEPARTMENT
.
I
NSTALLATION
AND
SERVICE
MUST
BE
PERFORMED
BY
A
QUALIFIED
INSTALLER
,
SERVICE
AGENCY
OR
THE
GAS
SUPPLIER
.
WHAT TO DO IF YOU SMELL GAS:
WARNING
T
HIS
PRODUCT
CONTAINS
OR
PRODUCES
A
CHEMICAL
OR
CHEMICALS
WHICH
MAY
CAUSE
SERIOUS
ILLNESS
OR
DEATH
AND
WHICH
ARE
KNOWN
TO
THE
S
TATE
OF
C
ALIFORNIA
TO
CAUSE
CANCER
,
BIRTH
DEFECTS
OR
OTHER
REPRODUCTIVE
HARM
.
WARNING