Oxygen Concentrator User Manual Model Numbers JB0160-010B, JB0160-010, JB0160-010B-220, JB0160-010-220 and JB0160-015B, JB0160-015, JB0160-015B-220, JB0160-015-220 with O2 Sensor Important: Do not operate this concentrator without first reading and understanding this manual! Save this manual for future use.
Contents 1 Safety.................................................................................... 3 2 Features............................................................................... 8 3 Handling............................................................................... 9 4 Operation and Installation....................................... 11 5 Maintenance..................................................................... 13 6 Troubleshooting Guide.................................
Federal Law (USA) restricts this device to sale by or on the order of a physician. This product should not be used unless the operator has been instructed by a qualified health care professional. WARNING: Users who require continuous oxygenation must plan for alternate reserve sources of power and oxygen in the event of a failure or loss of power and oxygen. This device is to be used ONLY as an oxygen supplement device and is NOT intended to be a lifesupporting or life-sustaining device.
s Damage: If the electrical power source becomes unstable, discontinue use and find an alternate source. s Damage: The oxygen concentrator cabinet contains no serviceable parts! The oxygen concentrator cabinet should ONLY be opened by an authorized equipment provider. Placement ATTENTION: The oxygen concentrator is intended to be rolled from room to room. Do not place the oxygen concentrator in surroundings where its airflow is obstructed.
WARNING: To reduce the risk of fire, special care must be taken when using oxygen concentrators. DO NOT SMOKE while using this device. Keep all matches, lighted cigarettes or other sources of ignition out of the room in which this concentrator is located. In public settings or when used in hospital or long-term care environments, prominently display NO SMOKING signs. WARNING: Textiles and other materials that normally would not easily burn, can ignite and burn with great intensity in oxygen enriched air.
Additional Safety Warnings WARNING: TO REDUCE THE RISK OF BURNS, ELECTROCUTION, FIRE OR INJURY TO PERSONS, avoid using while bathing. If continuous usage is required by the direction of a physician, the concentrator must be located in another room at least 9 feet (2.8m) from the bath. WARNING: DO NOT reach for a concentrator that has fallen into water. UNPLUG IT IMMEDIATELY. WARNING: In certain circumstances, oxygen therapy can be hazardous.
ATTENTION: ALWAYS supervise closely when this product is used near children or those who require close supervision. ATTENTION: Only use this device as intended and described in this manual. ATTENTION: DO NOT use parts, accessories or adapters other than those authorized by manufacturer. ATTENTION: DO NOT connect the concentrator in parallel or series with other oxygen concentrators or oxygen therapy devices.
2 Features Summary The John Bunn O2 Premier oxygen concentrator is intended for use as an oxygen supplement device in a home or care facility. Use the concentrator only as prescribed by a physician. The concentrator separates oxygen from ambient air, providing the user a high concentration of oxygen. Oxygen concentrator usage is therapeutically equivalent to other types of oxygen delivery systems. Characteristics • • • • • • Reliable, safe, complete plastic outer shell.
3 Handling GF Health Products, Inc. Freight Policy For Your Protection, Read Carefully The carrier accepted this merchandise “in good condition” and is responsible for safe delivery. Before signing the freight bill, inspect the shipment carefully for damage or missing pieces. Apparent Loss or Damage Should visual inspection show loss or damage, this MUST be noted on the freight bill and signed by the carrier’s agent. Failure to do so may result in the carrier failing to honor the claim.
Inspection Examine exterior of the oxygen concentrator for nicks, dents, scratches or other damages. Inspect all components. Storage Store the repackaged oxygen concentrator in a dry area. DO NOT place anything on top of the repackaged concentrator.
4 Operation and Installation Preparing the Concentrator (refer to above picture) 1. Unscrew the humidifier bottle cover, if so equipped (humidifier bottle is optional). 2. Fill the humidifier bottle with purified water (or distilled water) between the maximum and minimum water level lines. If needed, add medication to the water, as prescribed by physician. 3. Screw the cover back on the humidifier bottle. 4. Screw the humidifier bottle adapter into the humidifier bottle cover. 5.
trator’s AC connector into a properly grounded power outlet. Turning the Concentrator On 1. Press the power switch to start the concentrator. There will be a brief delay before the concentrator starts. The alarm system emits a tone of one second duration, the word HELLO appears on the hour meter LED panel, and the green power indicator light illuminates. ATTENTION: Every time the concentrator starts, the alarm system performs a self test, and emits a brief tone.
5 Maintenance Cleaning the Cabinet Clean the cabinet at least once a month. 1. Turn off the power switch. 2. Clean the cabinet with a mild household cleaner and a non-abrasive cloth or sponge. Do not spill liquid inside the cabinet. Cleaning or Replacing the Filters (3 Types) Clean or replace the filters as often as specified in the following paragraphs in order to protect the compressor and extend the concentrator’s life. Replacement filters are available from your Graham-Field equipment provider.
Side filters Note: For earlier models only, you will need a small blade screwdriver to open the side filter access door. For later models, the filter grill simply pulls out. If this operation is too difficult for you to perform, please contact your equipment provider to perform this for you. Clean the side filters weekly. There are two side filters, one located on each side of the concentrator cabinet. Perform the following steps on both side filters. 1.
• A wood stove is used • Kerosene or oil is used • Pets are present • Tobacco is used Intake filter Note: Please have your Graham-Field equipment provider replace the intake filter. This operation requires opening the intake filter access door. Replace, do not clean, the intake filter annually (or more often, if the intake filter turns black). The frequency of replacement depends on usage and condition of the environment where the concentrator is used.
6 Troubleshooting Guide SYMPTOM CHECK / ACTION Concentrator power is on and alarm is on, but concentrator doesn’t work Check if concentrator is unplugged; plug in. Check if circuit breaker is tripped; fix circuit breaker. If concentrator still doesn’t work, contact Graham-Field equipment provider. SYMPTOM CHECK / ACTION Concentrator works, but little or no oxygen from outlet Inspect tubes and cannula to ensure that they are not kinked or blocked. Smooth tubes to unblock.
SYMPTOM CHECK / ACTION Concentrator doesn’t work; alarm sounds; optional O2 sensor red warning light illuminates (JB0160-015B, JB0160-015, JB0160-015B-220, JB0160-015-220 only) Discontinue use; contact Graham-Field equipment provider immediately. Oxygen concentration is too low for safe use. Note: If you experience a problem with your concentrator and are unable to service it yourself, contact the equipment provider from whom you purchased the concentrator.
7 Bill of Materials Your concentrator includes the following components: • Oxygen concentrator (one each) • User manual (one each) • Humidifier bottle hose (one each) • Humidifier bottle adapter (one each) The concentrator comes with one bottom filter, two side filters, and one intake filter already installed; Model Nos. JB0160-015B, JB0160-015, JB0160-015B-220 and JB0160-015-220 come with one O2 sensor already installed.
8 Specifications • Flow Range: 1 to 5L/min • Oxygen Concentration: 1-4 LPM 94% ± 2% 5 LPM 92% ± 2% • Maximum Outlet Pressure: 6.52 psi ± .065 psi (45kPa ± 4.5kPa) • Pressure Relief Mechanism Operational at: 36.26 psi ± 3.63 psi (250kPa ± 25kPa) • Altitude: Up to 5,997 feet (1,828 meters) above sea level without degradation of concentration levels. Efficiency of 90% from 5,997 to 13,123 feet (1,828 to 4,000 meters) above sea level.
9 Limited Warranty This warranty is extended only to the original purchaser of our products. This warranty gives you specific legal rights and you may also have other legal rights which may vary from state to state. GF Health Products, Inc.
as identification, within thirty (30) days of the return authorization date. Do not return products to GF Health Products, Inc. or its Authorized Equipment Providers, without prior consent. C.O.D. shipments will be refused. All return shipments must prepay shipping charges, unless otherwise authorized by GF Health Products, Inc.
10 Index A ATTENTION, significance 3 B Before installation, safety 3 Bill of materials 18 C CAUTION, significance 3 Cleaning the cabinet 13 D Damage, significance 3, 14 F Features 8 Filters, cleaning or replacing 13 Fire warning & explosion, safety 4 Freight policy, Graham-Field’s 9 H Handling 9 R Radio Frequency Interference (RFI) 5 Replacement parts and optional accessories 18 Replacing the battery 15 S Safety 3 Safety warnings, additional 6 Specifications 19 Storage 10 T Troubleshooting guide 16 Turning
Notes John Bunn O2 Premier Oxygen Concentrator 23
REGISTER ® YOUR PRODUCT! The benefits of registering: • Safeguard your investment. • Ensure long-term maintenance and servicing of your purchase. • Receive updates with product information, maintenance tips, and industry news. • GF Health Products, Inc. can contact your or your provider, if servicing is needed on your product. • It will enable GF Health Products, Inc. to improve product designs based on your input and needs.
Questionnaire 1. Method of purchase: (check all that apply) �Medicare �Insurance �Medicaid �Other 2. This product was purchased for use by: (check one) �Self �Parent �Spouse �Other 3. This product was purchased for use at: �Home �Facility �Other 4. I purchased a Graham-Field product because: �Price �Features (list features) �Other 5.
Affix first-class postage here GF Health Products, Inc.
USA, Corporate Headquarters: Graham-Field Health Products 2935 Northeast Parkway Atlanta, Georgia 30360 telephone: 800-347-5678, 770-447-1609 fax: 800-726-0601, 678-291-3232 http://www.grahamfield.com GF0600004RevH07 ©GF Health Products, Inc. printed in China John Bunn, O2 Premier, GF, and Graham-Field are registered trademarks of GF Health Products, Inc.