565G (Regular) - 565PG (Petite) - 565WG (Wide) Ortho-Biotic Preferred Care® Recliners Operating Instructions GF0500043RevA05 © Graham-Field Health Products 2005 IMPORTANT: READ THIS MANUAL BEFORE OPERATING YOUR ORTHO-BIOTIC PREFERRED CARE RECLINER
WARNINGS Warning: Read entire sheet before assembly or operation. Warning: Casters must be locked at all times, except during transit. Warning: This product should not be used without proper instruction from a health care professional. Warning: GF/Lumex assumes no responsibility for damage or injury caused by the improper installation, assembly or use of these products. Warning: The 565G Regular and 565PG Petite Note: All dimensions and specifications are subject to change without notice.
UNPACKING INSTRUCTIONS 1. Unpack and damage or damaged or immediately. should be: inspect contents for shipping • Two (2) Pins with wire rings. missing parts. If parts are missing, contact your dealer 2. Do not remove the shipping support which is attached to the recliner’s upholstered back The contents of this package until after the recliner’s upholstered back has been assembled to the chair. • One (1) Recliner frame with upholstered seat. 3.
Upholstered Back Cushion BACK ASSEMBLY Elastic Band Figure 1 NOTE: Do not remove the shipping support which is attached to the recliners upholstered back until after the recliner's upholstered back has been assembled to chair. Shipping Support 1. Obtain upholstered back assembly. Remove the upholstered cushion from the metal back frame (See fig. 1). 2. Remove pins and wire rings from frame (See fig 1). 3.
CASTER OPERATION FOR 565WG ONLY To unlock To lock swivel and wheel Figure 4 NOTE: This chair is equipped with four swivel casters for improved maneuverability. The rear casters are also equipped with locking features. Lock: To prevent the rear casters from swiveling and wheel turning, step on the rear pedal of the caster until it latches (See fig 4). Unlock: Step on middle button to unlatch (See fig. 4).
CORRECT SEAT POSITIONING OCCUPANT OPERATED To recline, place hands on armrests and lean against the back until the desired position is obtained (See fig. 7). To return to seated position, place hands on armrests and lean forward while pressing legs down against the legrest. ATTENDANT OPERATED Release the recliners position stop. Use handgrip to adjust recliner to desired position. Engage recliner stop. Figure 7 OPERATION OF THE POSITION MECHANISM NOTE: Casters must be locked. 1.
565G UPHOLSTERY REMOVAL AND REPLACEMENT BACK CUSHION To remove: Release the two elastic straps which hold the button of the cushion to the back frame with small wire rings (See fig. 10). Frame Key Ring Grip top of cushion near back frame handgrips and slide up and off. To replace: Reverse procedure. Strap Hook Figure 10 SEAT-LEG CUSHION To remove: Release the two elastic straps which hold the cushion to the back frame with small wire rings (See fig. 10). Adjust the chair into the semi-recline position.
RECLINER POSITIONING MECHANISM TROUBLE-SHOOTING Clevis ring and wire ring ADJUSTMENT INSTRUCTIONS FOR POSITION MECHANISM NOTE: Never lubricate the position mechanism assembly. 1. Turn the position adjustment handle down to the release position, and remove clevis pin and wire ring from top of assembly (See fig. 13). 2. Slide positioning plate up, and turn square washer clockwise until snug (See fig. 13). 3. Slide the positioning plate down over square washer. Replace clevis pin and wire ring.
FOR YOUR CONVENIENCE, LUMEX OFFERS THE FOLLOWING ACCESSORIES WHICH MAY BE PURCHASED FROM YOUR LOCAL LUMEX DEALER. Part # 56461* 56462* 56471* 5645G* 5782G 2100A/2101A LX5640G 5657G* 5644G 5644PG 5644WG Items with Description 565 Reg 565-Petite 565-Wide 565-Drop 565-Tilt Head Bolster X X – X X Head Bolster – – X – – Body Bolster X X – X X Drainage Bag Holder X X X – – I.V. Pole Holder X X X X X I.V.
U.S.A., Corporate Headquarters: Graham-Field Health Products 2935 Northeast Parkway Atlanta, Georgia 30360 telephone: 800-347-5678, 770-447-1609 fax: 800-726-0601, 678-291-3232 http://www.grahamfield.