Product Manual

ManualsBrandsGuardian Fall Protection ManualsFall ProtectionCross Arm Strap — 6ft.L

Product Name: Cross Arm Strap/Cable Choker

Instruction Manual

Part #: 10785; 10786; 10787; 10788; 10790; 10791; 10792; 10793; 10794; 10420; 10421;

10422; 10460; 10461; 10462; 10430; 10431; 10432; 10470; 10471; 10472; 10410; 10411;

10412; 10450; 10451; 10452; 10400; 10401; 10402; 10440; 10441; 10442; 01640; 01630;

01625; 01620

Do not throw away these instructions!

Read and understand these instructions before using equipment!

Introduction

Applicable Safety Standards

Worker Classifications

Safety Information

6-7

Product Specific Applications

Limitations

2-3

Components and Specifications

3-4

Maintenance, Cleaning, and Storage

Inspection

Installation and Use

4-5

Inspection Log

Labels

Summary of content (8 pages)

PAGE 1
Product Name: Cross Arm Strap/Cable Choker Instruction Manual Part #: 10785; 10786; 10787; 10788; 10790; 10791; 10792; 10793; 10794; 10420; 10421; 10422; 10460; 10461; 10462; 10430; 10431; 10432; 10470; 10471; 10472; 10410; 10411; 10412; 10450; 10451; 10452; 10400; 10401; 10402; 10440; 10441; 10442; 01640; 01630; 01625; 01620 Do not throw away these instructions! Read and understand these instructions before using equipment! Introduction 1 Applicable Safety Standards 1 Worker Classifications 1 Product
PAGE 2
User Information Date of First Use: Serial #: Trainer: User: Applicable Safety Standards When used according to instruction specifications, this product meets or exceeds all applicable OSHA 1926 Subpart M, OSHA 1910, ANSI Z359.1-2007, and ANSI A10.32-2012 standards for fall protection. Applicable standards and regulations depend on the type of work being done, and also might include state regulations if applicable.
PAGE 3
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 6305 S. 231st St., Kent, WA 98032 Guardian Fall Protection Product Specific Applications ! WARNING Use of equipment in unintended applications may result in serious injury or death. Maximum 1 attachment per connection point. Personal Fall Arrest: Cross Arm Strap/Cable Choker may be used to support a MAXIMUM 1 PFAS for use in Fall Arrest applications.
PAGE 4
Two connectors to same D-ring. NO. Application that places load on gate. NO. Incompatible or irregular application, which may increase risk of roll-out. NO. Connector directly to horizontal lifeline. NO. Correct Anchorage Positioning: This chart details allowable working zones required to reduce risk of swing falls and improper side loading. ALWAYS adhere to information specified by chart.
PAGE 5
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 6305 S. 231st St.
PAGE 6
If Cross Arm Strap/Cable Choker fails inspection in any way, immediately remove it from service, and contact Guardian to inquire about its return or repair. Cleaning after use is important for maintaining the safety and longevity of Cross Arm Strap/Cable Choker. Remove all dirt, corrosives, and contaminants from Cross Arm Strap/Cable Choker before and after each use. If Cross Arm Strap/Cable Choker cannot be cleaned with plain water, use mild soap and water, then rinse and wipe dry.
PAGE 7
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 Inspection Log Date of First Use: __________________. Product lifetime is 5 years from Date of First Use, or, if not recorded, from Date of Manufacture, as long as it passes pre-use and Competent Person inspections. User must inspect prior to EACH use. Competent Person other than user must complete formal inspection at least every 6 months. Competent Person to inspect and initial.
PAGE 8
NEVER use fall protection equipment of any kind to hang, lift, support, or hoist tools or equipment, unless explicitly certified for such use. Equipment subjected to forces of fall arrest must immediately be removed from use. Age, fitness, and health conditions can seriously affect the worker should a fall occur. Consult a doctor if there is any reason to doubt a user’s ability to withstand and safely absorb fall arrest forces or perform set-up of equipment.