ESSENTIALS GUIDE 1
TABLE OF CONTENTS 2 MEET THE ELITE 1-BURNER 2-ZONE OUTDOOR GRIDDLE 04 FEATURES OF YOUR ELITE 1B 06 TURN UP THE HEAT WITH DUAL COOKING ZONES 08
OWNERS MANUAL CSA - EN PRODUCT RECORD CONNECTING 1 LB. CYLINDER CONNECTING 20 LBS.
MEET THE Taking your outdoor cooking skills above and beyond never felt so simple. With the Elite 1B, enjoy true wall to wall cooking with the industry’s first and only dual zone, single burner outdoor griddle. Propane fueled and with features like a unique wind proof design, rear grease disposal and spatula clean off, when it comes to innovation and an elite outdoor cooking experience, we’ve got you covered. We strive to Rise Above in both who we are and what we create.
FEATURES OF YOUR SEASON YOUR GRIDDLE IN 30 MINUTES Season the Elite 1B's 273 in 2 total cooking surface within 30 minutes. EASY LIFT OFF Attach the handles to easily remove the griddle top. WALL TO WALL COOKING SURFACE No more cold zones! WIND-PROOF DESIGN N o gap wi th o ur i nset gri dd l e s u rfa c e . Fl a me stays li t! DUAL ZONE BURNER SYSTEM Innovative burner design for cooking and keeping foods warm. Control 2 zones with 1 burner.
QUICK WARM UP TIME Re a dy to c ook i n 10 m i n u tes . GREASE MANAGEMENT SYSTEM Extra l a rge c a p a c i ty gre a se c u p i nc lu de d . BUILT IN UTENSIL CLEAN OFF Cl e a n u te n s i l s a s you c ook . PROPANE FUELED Designed to connect a 1 lb or a 20 lb adjustable propane tank. Perfect for on-the-go or in the backyard.
WITH DUAL COOKING ZONES 88 ZONE 1
The Elite 1B Outdoor Griddle has two zones within one burner, designed to give you the benefit of precise control over your cooking surface.
OWNERS MANUAL MODEL NO: HZ-1007-ANA SCAN FOR Product Registration Online Owner’s Guide Assembly Videos 10
IMPORTANT SAFETY INFORMATION WARNING FOR OUTDOOR USE ONLY and shall not be used in a building, garage, or any other enclosed area. DANGER If you smell gas: • Shut off gas to the appliance. • Extinguish any open flame. • Open lid. • If odor continues, keep away from the appliance and immediately call your fire department. Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death. DANGER • Never operate this appliance unattended.
INSTALLATION SAFETY PROTECTIONS • Use Halo 2-Zone Countertop Griddle as purchased. • Use Halo 2-Zone Countertop Griddle installation must conform with local codes, or in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
CSA - ENGLISH • Stainless Steel Cleaning Tips: Step 1: Dip a soft cloth in warm water mixed with a mild dish detergent. Wipe the surface, rinse the cloth and wipe again, then dry with a towel to prevent water spots. Step 2: If you still see fingerprints, spray a glass cleaner onto a soft cloth and wipe fingerprints away. Step 3: To remove baked-on food and grease, make a paste of baking soda and warm water. Gently rub onto the surface using a soft cloth or sponge. Wipe with a clean wet cloth and towel dry.
CSA - ENGLISH HOW TO CHECK IF MEAT IS DONE ON THE GRIDDLE • Use a meat thermometer to ensure food has reached a safe internal temperature. • Whole poultry should reach 165° F/ 73.8 °C for dark meat, 160°F/ 71°C for white meat. • Hamburgers made of any ground meat or poultry should reach 160°F/71°C and be brown in the middle with no pink juices. Beef, veal and lamb steaks, roasts and chops can be cooked to 145°F/63°C. All cuts of pork should reach 160°F/71°C.
CONNECTING 1 LB. CYLINDER NOTICE: To perform a leak test of your gas connections, mix a 50/50 solution of soap and water and brush around regulator and other gas connections. If growing bubbles appear, there is a leak. Re-tighten connections. If leaks cannot be stopped do not try to repair. Call for replacement parts at 1-833-572-1688. WARNING For your safety, when not in use remove the cylinder and the regulator. Cap the cylinder, the insert fitting and the quick disconnect. CONNECTING 1 LB.
DISMANTLING DISPOSABLE PROPANE CYLINDER 1. Turn control knob to OFF position and make sure all flames are extinguished then release the coupling at the quick connect body to release the insert. 2. Make sure your griddle is turned OFF and cooled down. 3. Disconnect the regulator from Quick Connect fitting by pull back the spring-loaded coupling back to release from the insert fitting, then unscrew the bottle from the regulator.
CONNECTING 20 LBS. TANK WARNING The LP tank used with this Flat Top Griddle must meet the following requirements: • Use appliance only with LP (propane) gas and the regulator/valve assembly supplied. • Installation must conform with local codes, or in their absence with National Fuel Gas Code, NFPA 54/ANSI Z223.1. Handling and storage of LP cylinders must conform to LP Gas Code NFPA/ANSI 58. • Do not modify this appliance. Modifications will result in a safety hazard.
HOW TO SET REGULATOR SETTING • Pull back the spring-loaded coupling to release regulator cap to achieve 8.5" water column. • Pull back the spring-loaded coupling then push the regulator cap firmly and release. The regulator cap will snap in and lock in place to reset the regulator to 11" water column. LEAK TEST PROCEDURE 1. Attach hose assembly to cylinder. 2. Slowly open cylinder valve. 3.
9. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior to the appliance being put into operation. See product tag for hose & regulator information. 10. Do not block holes in bottom or sides of appliance. 11. Never operate appliance with LP tanks out of correct position specified in Assembly Instructions. 12.
LIGHTING INSTRUCTIONS LIGHTING THE PIZZA OVEN 1. Open lid during lighting. Symbol Represents Burner being lit 2. Push and turn any control knob to . Press electronic igniter and hold for 3-5 seconds then turn to . Symbol Represents Burner already lit 3. If ignition does not occur in 5 seconds, turn the burner control off, wait 5 minutes, and repeat the lighting procedure.
MATCH LIGHTING INSTRUCTIONS 1. Open Lid 1 2. Make sure the control knob is in the OFF position (Push control knob down and turn clockwise to make sure that it is in the OFF position.) 3. Light burner with match lighting stick or with an 11” long match, then place the match on top of the burner. 4. Push and turn control knob to setting to light the burner. Match lighting hole 2 4 5. Make sure the burner lights and stays on then. 3 WARNING Do not lean over the open barbecue.
GREASE CUP POSITION POSITIONING THE GREASE CUP Make sure the lip of grease cup is positioned under the griddle drip ledge when installing the grease cup to avoid grease leakage. Check the grease cup often and clean out after each use. WARNING Make sure the griddle is cooled before remove grease cup FOLDING THE GREASE CUP HANDLE 1. Pull-out spring-loaded knurl knob. 2. Rotate the handle back to empty the grease.
SEASONING YOUR GRIDDLE INITIAL GRIDDLE SEASONING The simple idea behind your initial seasoning is to coat the griddle with oil and heat the oil above its smoke point to polymerize the oil and create a bond with the griddle top. You will end up with a dark coating surface that is easy to clean. 1. Apply small amount of oil to the surface of the griddle top and spread it around with a cloth or paper towel (use tongs or metal spatula to hold the cloth or paper towel). 2. Turn your griddle on medium-high heat.
CARING FOR YOUR ELITE 1B UNIQUE FEATURE Your 2-Zone Countertop Griddle also includes the stationary squeegee bar for your convenience, located above grease drain opening to allow you to clean your spatula during cooking or cleanup. USING CARE ■ Regularly clean your Halo 2-Zone Countertop Griddle between uses and especially after extended periods of storage ■ Make certain that the Halo 2-Zone Countertop Griddle and its components are adequately cool before start cleaning.
TROUBLESHOOTING BURNER WILL NOT LIGHT USE THE ELECTRONIC IGNITION POS S I BLE CAUSE: SO LUT I O N: ■ Faulty regulator ■ Check he regulator or needs to be replaced ■ Obstructions in burner Venturis ■ Clean venturis and burner with small size round wire brush ■ Obstructions in gas orifice or gas hose ■ Clean orifice and gas hose ■ Electrode is damaged/faulty igniter ■ ■ Empty LP Cylinder Change electrode assembly and ignitor wire or change igniter module ■ Replace a new LP Cylinder BURNE
ELITE 1B PARTS LIST 1 2 3 29 4 7 4.
ITEM 1 2 3 4 4.1 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 PART DESCRIPTION PART NO. QUANTITY Lid Assembly Lid Handle Griddle Plate Bracket-Squeegee Blade Squeegee Blade Electrode Assembly Burner Assembly Hinges-Set Fire Box Assembly Flexible Gas Line-Long Flexible Gas Line-Short Orifice Holder-Set Control Panel Valve and Manifold Assembly Regulator Assembly-1 lb.
24.76 629.00 25.00 635.03 25.00 635.03 ASSEMBLED DIMENSIONS 24.76 629.00 12.84 326.19 24.76 629.
FIVE (5) YEAR LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
FIVE (5) YEAR LIMITED WARRANTY ITEMS MANUFACTURER WILL NOT PAY FOR 1. Shipping cost, standard or expedited, for warranty and replacement parts. 2. Service calls to your home. 3. Repairs when your product is used for other than normal, single-family household or residential use. 4.
THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
STAY CONNECTED WITH US! SCAN TO REGISTER YOUR PRODUCT H A LO Pro d uc t s G rou p @ha l o p ro d uc t s gro u p @ha l o p ro d uc t s gro u p H a l o Pro d u c t s G rou p 32 © 2021 Halo Products Group LLC Halo and the Halo flame are registered trademarks of Halo Products Group LLC www.halo-pg.
