203FOMSL.EPS 203FE, omslag Service Manual SVART 960130 May 1997 Victor Hasselblad AB Göteborg Sweden COPYRIGHT © 1996 Copyright © 1997 by Victor Hasselblad AB. All rights reserved. No parts of this material may be reproduced, stored in retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopy, recording, or ANDERS ENGSTRÖM otherwise, without the prior written permission of the Company.
Contents list Camera body 203FE - 205FCC - 205TCC 1. General description 2. Specifications 3. Checks & Adjustments 4. Tools & ServiceTest System 5. Exploded view: Shell 6. Exploded view: Control panel, mechanics 7. Exploded view: Control panel, electronics 8. Exploded view: Display flex and main circuit board 9. Exploded view: Contact flex and transport mechanism plate 10. Exploded view: Transport mechanism plate 11. Exploded view: Front bayonet plate 12.
Related Service Infos 203FE - 205FCC - 205TCC 1.
Related Service Infos 203FE - 205FCC - 205TCC 14/00 Discontinued parts - 200 series cameras 01/01 Modified magazine hook - 203FE and 205FCC 04/01 New CD-ROM - Version 2.0 Revision 0 2.
General description 1:1 Camera body 203FE - 205FCC - 205TCC Design: Medium format single reflex camera with built-in TTL selective meter electronically connected to FE lenses and E magazines. Interchangeable lenses, film magazines, viewfinders and focusing screens. Shutter: (203FE/205FCC) Electronically controlled mechanical focal plane shutter with release solenoid system. Horizontally running textile curtains. Shutter speed range 90 s - 1/2000 s and B. In manual mode up to 34 minutes.
General description 1:2 Camera body 203FE - 205FCC - 205TCC Exposure meter: (203FE) TTL metering at full aperture with FE lenses. High sensitivity silicon photocell. Selective meter area approximately 20% of the image area. Metering range EV 0.5 to EV 21.5 at ISO 100/21° and f 2.8. Activated 16 s after release of any operational button. Exposure meter: (205FCC/205TCC) TTL metering at full aperture with FE lenses. High sensitivity silicon photocell. Spotmeter area approximately 1% of the image area.
General description 1:3 Camera body 203FE - 205FCC - 205TCC Flash control: (203FE/205FCC) Center weighted TTL/OTF flash exposure meter. Full dedicated flash control with inhibited flash triggering at shutter speeds faster than 1/90 s. Flash control film speed range ISO 25 - 1000. Flash control: (205TCC) Center weighted TTL/OTF flash exposure meter. Full dedicated flash control with automatic shutter speed reset to 1/90 s at faster speed settings.
Specifications 2:1 Camera body 203FE - 205FCC - 205TCC 71.4 mm ± 0.03 mm Focal length: Front key angle: Cocked position Overtravel 8° - 9° 3 Ncm 12° - 14° 14 Ncm Front gear: Pre-tension of spring 3 turns (released position) Magnets: Minimum hold 2 Ncm Shutter: Accelerating stretch Slot Travel times Speeds 1 sec - 1/60 Speeds 1/90 - 1/2000 6.5 - 8.1 mm 0.2 - 1.0 mm 9.5 - 9.7 ms at 1/2000 s (0 ± 0.07 ms) ± 0.1 EV ± 0.3 EV Light meter: All settings ± 0.3 EV Flash meter: All settings ± 0.
Specifications 2:2 Camera body 203FE - 205FCC - 205TCC Switch functions PPS = Pressure point switch Makes when the release button is pressed to the pressure point. Activates the camera. A pre-locked light value is unlocked when the button is released. LRS = Late release switch Makes when the release button is fully pressed. Starts together with PPS an exposure. HPS = Home position switch Makes when the camera is fully cocked. Indicates together with FSS that the camera is tensioned.
Specifications 2:3 Camera body 203FE - 205FCC - 205TCC Switch functions AS+ = Adjustment switch + Exposure compensation etc. AS- = Adjustment switch Exposure compensation etc. VFS = View finder switch Is switched off when a prism finder is mounted on to the camera and at the same time mirror turns the display. 203SWTC BLS = Back light switch ON/OFF display illumination. FSS SSS TC1.
Checks & Adjustments 3:1 Camera body 203FE - 205FCC - 205TCC Link to: VHABSTS CAUTION! When handling the circuit boards a grounded bench mat and a wrist strap must be used to prevent ESD damage. Carry out the following checks/adjustments when a camera body is reassembled after a repair. Note! Point 1 - 7 without camera shell. 1. The camera body focal length is checked by using the gauge V-2229 together with the ruler and indicator clock. The focal length is 71.40 mm ± 0.03 mm.
Checks & Adjustments 3:2 Camera body 203FE - 205FCC - 205TCC containing the PRS. Untighten the two screws (Pos. No. 12, page 9) and carefully change the position of the flex in the direction required. Tighten the screws and recheck. 7:2 PANEL. Check the control panel functions. 7:3 SPEED RING. Make sure all speed ring settings are indicating correctly. 7:4 DISPLAY. Check the display indications. Note! To get the flash indicator to light up, the sync cable must be connected. 7:5 CURRENT.
Checks & Adjustments 3:3 Camera body 203FE - 205FCC - 205TCC 8. Remove the control panel. Make sure the four centering screws (Pos. No. 16 and 19, page 11) are screwed in and put the camera body in to the shell. Do not forget the pre-release button. 9. After aligning the rear plate/shell tighten the two rear screws (Pos No. 32, page 5) and adjust, if necessary, the horizontal relationship between the speed ring and the shell by the screws (Pos No. 16, page 11) which are accessible through the shell. 10.
Checks & Adjustments 3:4 Camera body 203FE - 205FCC - 205TCC 203FADJM.
Checks & Adjustments 3:5 Camera body 203FE - 205FCC - 205TCC Magnet hold capability 250 250 1 200 1 1 50 200 GRAM 50 1 The magnet hold capability can be checked according to the diagram below. A suitable scale, like the ZZ88, should be used. When measuring, it must indicate minimum 2 NCM (200 gram) before each latching lever is released. If indicating less then 2 NCM, the magnets should be cleaned and then rechecked. If still less then 2 NCM after cleaning the Bottom mechanism plate, compl.
Tools 4:1 Camera body 203FE - 205FCC - 205TCC Tool No.
Tools 4:2 Camera body 203FE - 205FCC - 205TCC Tool No.
Tools 4:3 Camera body 203FE - 205FCC - 205TCC The PC based Service Test System has been developed for testing the 200 series cameras in Hasselblad authorized service centres. In addition it can be used for testing some functions on the 500 and 2000 series cameras and in the PME viewfinder. The Service Test System contains the following: 970 663 970 630 970 610 663 83 970 711 970 649 970 648 55034/23 Diskette (3.
5 203FE - 205FCC - 205TCC BOD20301.
5 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
6 203FE - 205FCC - 205TCC BOD20302.
6 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
7 203FE - 205FCC - 205TCC BOD20303.
7 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No. Description 1 2 3 4 5 1 1 2 1 1 105 021 107 394 105 861 828 301 105 524 Control panel Sync terminal Soldering tag Nut Circuit board 6 7 8 9 10 1 2 1 1 2 105 918 105 622 107 405 105 896 105 916 Holder Screw Insulation tape Insulation plate Insulation plate 11 12 1 1 105 866 105 520 SCA flex Screw Revision 1 Remark Mode sign not incl.
8 203FE - 205FCC - 205TCC COPYRIGHT © 1997 ANDERS ENGSTRÖM BOD20304.
8 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
9 203FE - 205FCC - 205TCC BOD20305.
9 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Description Spare Part No.
BOD20306.
10 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Description Spare Part No. 1 2 3 4 5 1 1 1 1 2 105 670 828 901 103 482 103 231 817 119 Cam Nut Gear Gear Clip 6 7 8 9 10 2 1 1 1 1 103 228 810 940 103 498 105 053 810 948 Gear Teflon washer, 0.15mm Ring Transport mechanism plate Teflon washer, 0.
11 203FE - 205FCC - 205TCC BOD20307.
11 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
11 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No. Description 54 55 56 57 58 1 1 2 1 1 814 505 814 807 817 112 105 946 103 117 Spring Spring Clip Release lever, rear Release lever, front 59 60 61 62 63 64 1 1 1 1 1 1 822 430 105 836 105 835 107 407 816 716 105 947 Screw Spring Exposure catch Shaft Spring Release bridge 105 023 Front bayonet plate, compl. Revision 1 Remark Incl. Display flex, Part No.
12 203FE - 205FCC - 205TCC BOD20308.
12 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No. Description 1 2 3 4 5 1 6 1 2 1 22 423 829 535 107 359 103 854 103 837 Magazine hook Screw Curtain set Screw Nut 6 7 8 9 10 1 3 1 1 1 103 080 103 839 103 858 105 933 103 838 Holder Bearing Holder Screw Nut 11 12 13 14 15 1 1 2 2 1 103 079 103 081 829 316 830 620 105 301 Holder Holder Screw Screw Rear plate 16 17 2 1 105 943 103 735 Light seal Light seal Revision 0 Remark Please state serial No.
BOD20309.EPS COPYRIGHT © 1997 ANDERS ENGSTRÖM 970214 13 ANDERS ENGSTRÖM, ILLUSTRATÖR Östra vägen 46 430 91 HÖNÖ tel/fax 031- 96 84 64 anders@aeillustr.
13 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
14 203FE - 205FCC - 205TCC BOD20310.
14 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No. Description 1 2 3 4 5 1 2 1 1 1 105 941 829 435 105 459 105 940 105 358 Light seal Screw Light seal Light seal Display prism 6 7 8 9 10 1 1 1 4 1 105 350 105 458 105 474 830 235 Prism holder Holder, right Holder, left Screw Acute-Matte D 203 Acute-Matte D 205 Revision 0 Remark Sales code No. 42210 Sales code No.
15 203FE - 205FCC - 205TCC BOD20311.
15 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
COPYRIGHT © 1997 ANDERS ENGSTRÖM BOD20317.
16 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
17 203FE - 205FCC - 205TCC BOD20312.
17 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
18 203FE - 205FCC - 205TCC BOD20313.
18 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
19 203FE - 205FCC - 205TCC BOD20314.
19 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
20 203FE - 205FCC - 205TCC BOD20315.
20 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
21 203FE - 205FCC - 205TCC BOD20316.
21 Camera body 203FE - 205FCC - 205TCC Pos Pcs No. Spare Part No.
203FE 205FCC 22 COPYRIGHT © 1997 ANDERS ENGSTRÖM BOD20318.EPS From serial No. 18ET10992 ANDERS ENGSTRÖM, ILLUSTRATÖR Östra vägen 46 430 91 HÖNÖ tel/fax 031- 96 84 64 anders@aeillustr.se 970513 From serial No.
22 Camera body 203FE - 205FCC Pos Pcs No. Spare Part No.
