User Guide

ManualsBrandsHatco ManualsOtherFSHC17WM-0506(1)

Model FSHC-17W1

Model FSHC-17W1D

Model FSHC-17W2

Model FSHC-17W2D

This manual contains important safety information

concerning the maintenance, use and operation of this

product. Failure to follow the instructions contained in

this manual may result in serious injury. If you’re unable

to understand the contents of this manual, please bring

it to the attention of your supervisor. Do not operate this

equipment unless you have read and understood the

contents of this manual.

Este manual contiene importante información sobre

seguridad concerniente al mantenimiento, uso y

operación de este producto. Cualquier falla en el

seguimiento de las instrucciones contenidas en este

manual puede resultar en un serio daño. Si usted no

puede entender el contenido de este manual por

favor pregunte a su supervisor. No opere este

equipo al menos que haya leído y comprendido el

contenido de este manual.

FLAV-R-SAVOR

Tall Humidified Holding Cabinet

FSHC-17W1 & FSHC-17W2 Series

Installation &

Operating Manual

I&W #07.05.169.00

Summary of content (16 pages)

PAGE 1
FLAV-R-SAVOR ® Tall Humidified Holding Cabinet FSHC-17W1 & FSHC-17W2 Series Installation & Operating Manual I&W #07.05.169.00 Model FSHC-17W1 Model FSHC-17W1D This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor.
PAGE 2
CONTENTS Important Owner Information ............................... i Introduction..............................................................i Important Safety Instructions............................... 1 Model Description ................................................. 2 All Models .................................................... 2 Model FSHC-17W1 ......................................2 Model FSHC-17W1D ................................... 2 Model FSHC-17W2 ......................................
PAGE 3
IMPORTANT SAFETY INSTRUCTIONS IMPORTANT! Read the following important safety instructions to avoid personal injury or death, and to avoid damage to the equipment or property. WARNINGS WARNINGS Genuine Hatco Replacement Parts are specified to operate safely in the environments in which they are used. Some aftermarket or generic replacement parts do not have the characteristics that will allow them to operate safely in Hatco equipment.
PAGE 4
MODEL DESCRIPTION ALL MODELS Flav-R-Savor® Tall Humidified Holding Cabinets are made from sturdy stainless steel with tubular frame welded construction. Features include thermostatically controlled heat and humidity, a digital temperature display and see-thru door(s) or insulated stainless steel door(s). The door(s) can be hinged left or right. Electrical components, controls and the water pan are easily accessible. Units are equipped with swivel casters with wheel locks for easy portability.
PAGE 5
SPECIFICATIONS ELECTRICAL RATING CHART Model Voltage Hertz FSHC-17W1 120 208-240 220 240 240 220-240 220-230 (CE) 220-230 (CE) 60 60 50 50 50 50 50 50 FSHC-17W1D 120 208-240 220 240 240 220-240 220-230 (CE) 220-230 (CE) FSHC-17W2 FSHC-17W2D Watts Amps Plug Configuration Shipping Weight 1410 1250 - 1670 1408 1680 1680 1403 - 1670 1403 - 1670 1403 - 1670 11.8 6.0 - 7.0 6.4 7.0 7.0 6.4 - 7.0 6.4 - 7.0 6.4 - 7.
PAGE 6
SPECIFICATIONS DIMENSIONS Width (A) Depth (B) Height (C) FSHC-17W1 25-3/8'' (645 mm) 35'' (889 mm) 73-3/8'' (1864 mm) FSHC-17W1D 25-3/8'' (645 mm) 35'' (889 mm) 73-3/8'' (1864 mm) Model Width (A) Depth (B) Height (C) FSHC-17W2 25-3/8'' (645 mm) 35-3/8'' (899 mm) 73-3/8'' (1864 mm) FSHC-17W2D 25-3/8'' (645 mm) 35-3/8'' (899 mm) 73-3/8'' (1864 mm) Model Dimensions for units with Transport Package, Bumpers and Handles: 31-1/2'' W (800 mm) x 36-1/2'' D (927 mm) Dimensions for units with
PAGE 7
INSTALLATION ALL MODELS The Flav-R-Savor® Tall Humidified Holding Cabinets are shipped with most components installed and ready for operation. The following installation instructions must be performed before plugging in and operating the cabinet. 3. Remove tape and protective packaging from all surfaces of unit. Remove Rack Slide Assembly. 4. Unpack the adjustable steel rack slides from the carton, and install them to the rack as shown in Figure 11. 1. Remove unit from box. 5.
PAGE 8
INSTALLATION REVERSIBLE ACCESS DOOR Doors are shipped from the factory mounted on the cabinet left side, opening from the right. Doors can be reversed to open from the left, as follows: 1. Remove screws securing door to hinges. (See Figure 12.) 2. Remove the screws securing hinges to cabinet. 3. Remove screw plugs from right side of cabinet and insert in left side. 4. Rotate the door 180° and install on the right side using the original mounting hardware.
PAGE 9
OPERATION 1. Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration. See SPECIFICATIONS for details. 2. Turn the Power Switch on the control panel to the ON position. 3. Fill the water pan with softened or distilled water. To fill the bottom mounted reservoir, slowly pour the water into the water pan until is full.
PAGE 10
OPERATION FOOD HOLDING GUIDE Food Product Cabinet Temperature Humidity Setting 5.5 4 to 4.25 2 to 4 5 5 6 5 5 4.5 to 5.5 5 4.5 to 5.25 5 Low Medium Medium Medium Medium Off High Medium Low Off High Medium 4 4.25 4.5 5 Medium Medium Medium Medium 4 to 4.5 4 4.5 to 5.25 5 4.5 to 5.
PAGE 11
MAINTENANCE GENERAL DRAINING THE WATER PAN ® Hatco Flav-R-Savor Tall Humidified Holding Cabinets are designed for maximum durability and performance, with minimum maintenance. WARNING To avoid any injury, turn the power to the unit OFF and allow to cool before draining. WARNING To avoid any injury, turn the power switch OFF, unplug the unit from the power source and allow to cool completely before performing any maintenance or cleaning.
PAGE 12
MAINTENANCE REMOVING LIME & MINERAL DEPOSITS 1. Turn the power switch off and unplug the unit from its power source. 2. After the unit has cooled down, drain all remaining water out of the unit. See DRAINING THE RESERVOIR. 3. With pan removed from the unit, fill the pan with a mixture of water and delimer. NOTE: The delimer used should be a safe, nontoxic, non-corrosive solution. Follow the delimer’s instruction for proper mixture of water and delimer solution. 4.
PAGE 13
ACCESSORIES TRANSPORT OPTIONS Model FSHC-17W2D (Shown with optional Transport Package features.
PAGE 14
HATCO LIMITED WARRANTY 1. PRODUCT WARRANTY Hatco warrants the products that it manufactures (the “Products”) to be free from defects in materials and workmanship, under normal use and service, for a period of one (1) year from the date of purchase when installed and maintained in accordance with Hatco’s written instructions or 18 months from the date of shipment from Hatco.
PAGE 15
NOTES 13 Form No.
PAGE 16
HATCO AUTHORIZED PARTS DISTRIBUTORS ALABAMA INDIANA NEW YORK TENNESSEE Jones McLeod Appl. Svc. Birmingham 205-251-0159 GCS Service Indianapolis Acme American Repairs, Inc. Brooklyn 718-456-6544 Camp Electric Memphis ARIZONA IOWA TEXAS Auth. Comm. Food Equip. Phoenix 602-234-2443 Electric Motor Service Co. Davenport 319-323-1823 Alpro Service Co. Brooklyn Byassee Equipment Co.