User Guide

ManualsBrandsHatco ManualsOtherFSHC67M-1104

FLAV-R-SAVOR

Portable Holding Cabinets

FSHC-6W & FSHC-7 Series

Installation &

Operating Manual

I & W #07.05.152.00

This manual contains important safety

information concerning the maintenance, use

and operation of this product. Failure to follow

the instructions contained in this manual may

result in serious injury. If you’re unable to

understand the contents of this manual, please

bring it to the attention of your supervisor. Do not

operate this equipment unless you have read

and understood the contents of this manual.

Ester manual contiene importante información

sobre seguridad concerniente al mantenimiento,

uso y operación de ester producto. Cualquier

falla en el seguimiento de las instrucciones

contenidas en ester manual puede resultar en un

serio daño. Si usted no puede entender el

contenido de ester manual por favor pregunte a

su supervisor. No opere ester equipo al menos

que haya leído y comprendido el contenido de

ester manual.

Summary of content (16 pages)

PAGE 1
FLAV-R-SAVOR ® Portable Holding Cabinets FSHC-6W & FSHC-7 Series Installation & Operating Manual I & W #07.05.152.00 This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor.
PAGE 2
CONTENTS Installation..........................................................5 All Models .....................................................5 Reversible Access Door ...............................6 Location ........................................................6 Operation............................................................7 Food Holding Guide......................................8 Maintenance.......................................................9 General .....................................
PAGE 3
IMPORTANT SAFETY INSTRUCTIONS IMPORTANT! Read the following important safety instructions to avoid personal injury or death, and to avoid damage to the equipment or property. WARNINGS WARNINGS Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration. If the plug and receptacle do not match, contact a qualified electrician to determine the proper voltage and size and install the proper electrical outlet.
PAGE 4
MODEL DESCRIPTION ALL MODELS Flav-R-Savor® Portable Holding Cabinets are made of sturdy stainless steel and powdercoat painted top, sides and back. Features include thermostatically controlled heat and humidity, a digital temperature readout and a large aluminum framed tempered glass door or insulated stainless steel door. The access door can be hinged left or right. Electrical components, controls and water reservoir are easily accessible.
PAGE 5
SPECIFICATIONS ELECTRICAL RATING CHART Model Voltage Hertz Watts Amps Plug Configuration FSHC-6W-1 120 220 240 240 220-230 (CE) 230-240 (CE) 60 50 50 50 50 50 1697 1697 1697 1697 1697 1697 14.1 7.7 7.1 7.1 7.1 7.1 NEMA 5-15P* CEE 7/7 Schuko BS-1363 AS-3112 CEE 7/7 Schuko BS-1363 175 175 175 175 175 175 lbs. lbs. lbs. lbs. lbs. lbs. (79 (79 (79 (79 (79 (79 kg) kg) kg) kg) kg) kg) FSHC-6W-2 120 220 240 240 220-230 (CE) 230-240 (CE) 60 50 50 50 50 50 1697 1697 1697 1697 1697 1697 14.1 7.
PAGE 6
SPECIFICATIONS DIMENSIONS Model Width (A) Depth (B) Height† (C) FSHC-6W-1 25-3/8" (645 mm) 29-1/2" (749 mm) 32-1/8" (816 mm) FSHC-6W-2 25-3/8" (645 mm) 32" (813 mm) 32-1/8" (816 mm) FSHC-6W-2 Only B B A C Top Surface: 25-3/8"W x 25-7/8"D (645 x 657 mm) Cabinet Opening: 20-7/8"W x 19"H (530 x 483 mm) FSHC-6W Series Model FSHC-7-1 FSHC-7-2 Width (A) Depth (B) Height* (C) 22-3/4" (578 mm) 29-1/2" (749 mm) 35-1/8" (892 mm) 22-3/4" (578 mm) 32" (813 mm) FSHC-7-2 Only B B A 35-1/8" (892
PAGE 7
INSTALLATION ALL MODELS The Flav-R-Savor® Portable Holding Cabinets are shipped with most components installed and ready for operation. The following installation instructions must be performed before plugging in and operating the cabinet. 5. Carefully lay the unit on its side. Thread one leg or mount caster using hardware provided onto the cabinet bottom and tighten securely. (See Figure 4.) Return cabinet to the upright position. 1. Remove unit from box.
PAGE 8
INSTALLATION REVERSIBLE ACCESS DOOR Doors are shipped from the factory mounted on the cabinet left side, opening from the right. Doors can be reversed to open from the left, as follows: 1. Remove screws securing door to hinges. (See Figure 5.) 2. Remove the screws securing hinges to cabinet. 3. Remove screw plugs from right side of cabinet and insert in left side. 4. Rotate the door 180° and install on the right side using the original mounting hardware.
PAGE 9
OPERATION 1. Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration. See SPECIFICATIONS for details. WARNING Some exterior surfaces on the Holding Cabinet will get hot. Use caution when touching these areas to avoid injury. 2. Turn the Power Switch on the control panel to the ON position. The Humidity Cycle and Low Water indicators will light up at this time. (See Figure 6.) NOTE: On the initial fill, the water reservoir capacity is one gallon (3.
PAGE 10
OPERATION FOOD HOLDING GUIDE Type of Food Bagels Biscuits Chicken - Parts Chicken - Whole Croissants Fish Frankfurters Fruit Pies Hot Dogs (Appetizers) Onion Rings Pizza Pretzels Ribs Wrapped Sandwiches Maximum Holding Time 3 Hours 2 Hours 5 Hours 2 Hours 3 Hours 1 Hour 2 Hours 3.5 Hours 4 Hours 1 Hour 1 Hour 3 Hours 2 Hours 2 Hours Humidity Setting Low Medium High High Low Medium High Medium High Low Medium Medium High Medium Setting 4 3 5 5.5 4 5.5 6 4 5 4 6 4 6 4.
PAGE 11
MAINTENANCE GENERAL Hatco Flav-R-Savor® Portable Holding Cabinets are designed for maximum durability and performance, with minimum maintenance. WARNING To avoid any injury, turn the power switch OFF, unplug the unit from the power source and allow to cool completely before performing any maintenance or cleaning. Water Outlet WARNING To prevent any injury, discontinue use if power cord is frayed or worn. Drain Hose Figure 7.
PAGE 12
MAINTENANCE REMOVING LIME & MINERAL DEPOSITS WARNING If service is required on this unit, contact your Authorized Hatco Service Agent, or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966 or International fax 414-671-3976. CAUTION Water Quality Requirements - Incoming water in excess of 3.0 grains of hardness per gallon (GPG) (.75 grains of hardness per liter) must be treated and softened before being used. Water containing over 3.0 GPG (.
PAGE 13
ACCESSORIES STACKING KIT A special stacking bracket is available for stacking one FSHC-7 unit on top of another FSHC-7 unit or one FSHC-6W unit on top of another FSHC-6W unit. The stacking hardware secures the top unit to the bottom unit. 1. Carefully lay top unit upside down. NOTE: Place a piece of cardboard between the cabinet and floor to prevent marring the cabinet finish. 2. Attach stacking bracket to underside of top unit using hardware supplied. (See Figure 8.) 3.
PAGE 14
HATCO LIMITED WARRANTY THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR PATENT OR OTHER INTELLECTUAL PROPERTY RIGHT INFRINGEMENT.
PAGE 15
NOTES 13 Form No.
PAGE 16
HATCO AUTHORIZED PARTS DISTRIBUTORS ALABAMA INDIANA NEW YORK TENNESSEE Jones McLeod Appl. Svc. Birmingham 205-251-0159 GCS Service Indianapolis Acme American Repairs, Inc. Brooklyn 718-456-6544 Camp Electric Memphis ARIZONA IOWA TEXAS Auth. Comm. Food Equip. Phoenix 602-234-2443 Electric Motor Service Co. Davenport 319-323-1823 Alpro Service Co. Brooklyn Byassee Equipment Co.