Instructions / Assembly

ManualsBrandsHathaway ManualsOutdoor TrampolinesXT 14 ft. Round Blue Trampoline

V3: 0124

Questions, problems, missing parts?

Before returning to your retailer, call our Consumer Hotline at 1-800-759-0977,

Monday – Friday, 8 a.m. – 5 p.m. (CST).

TR1005 / TR1010

HATHAWAY XT

12-FT AND 14-FT ROUND TRAMPOLINE - BLUE

Assembly, Installation, Care, Maintenance, and Use Instructions

Trampolines and safety enclosures are

susceptible to winds. Be sure to secure

trampoline and enclosure. Wind damage is

not covered by trampoline warranty.

CAUTION

Read these materials prior to assembling and using

this trampoline. Save this manual for future reference.

WARNING

DO NOT attempt or allow somersaults. Landing on the head

or neck can cause serious injury, paralysis, or death, even

when landing in the middle of the bed (jumping mat).

DO NOT allow more than one person on the

trampoline. Use by more than one person at the

same time increases the chance of injury.

Use trampoline only w

ith mature, knowledgeable supervision. Enforce all safety

rules. All trampoline users require supervision regardless of their age and experience.

Maximum user weight for the trampoline should not exceed 220-lbs (100-kg).

Overloading trampoline above recommended user weight limit may cause damage

to jumping mat or springs that is not covered by trampoline warranty.

Trampolines not for children under 6 years.

Summary of content (20 pages)

PAGE 1
TR1005 / TR1010 HATHAWAY XT 12-FT AND 14-FT ROUND TRAMPOLINE - BLUE Assembly, Installation, Care, Maintenance, and Use Instructions WARNING DO NOT attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or death, even when landing in the middle of the bed (jumping mat). WARNING Read these materials prior to assembling and using this trampoline. Save this manual for future reference. CAUTION Trampolines and safety enclosures are susceptible to winds.
PAGE 2
TABLE OF CONTENTS THANK YOU! .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 SAFETY INFORMATION SIGNAL WORDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSTALLATION AND ASSEMBLY .......................................... TRAMPOLINE PLACEMENT .. . . . . . . .
PAGE 3
THANK YOU! Thank you for purchasing this product! We work around the clock and around the globe to ensure that our products maintain the highest possible quality. However, in the rare case of issues during assembly or use of this product, please contact our Consumer Hotline at 1-800-759-0977 for immediate assistance before contacting your retailer. Please read the warranty information at the back of this User Manual for further details.
PAGE 4
INSTALLATION AND ASSEMBLY TRAMPOLINE PLACEMENT LOCATION • Adequate overhead clearance is essential. A minimum of 24 feet from ground level is recommended. Provide clearance for wires, tree limbs, and other possible hazards. • Lateral clearance is essential. Place the trampoline and trampoline enclosure away from walls, structures, fences, and other play areas. Maintain a clear space on all sides of the trampoline and trampoline enclosure.
PAGE 5
INSTALLATION AND ASSEMBLY TRAMPOLINE PARTS LIST PART DESCRIPTION TR1005 PART NUMBER TR1005 12-FT 4 LEGS PART QTY TR1010 PART NUMBER TR1010 14-FT 6 LEGS PART QTY A Top Rail TRP1100 8 TRP1108 12 B Safety Pad TRP1101 1 TRP1109 1 C Jumping Mat TRP1102 1 TRP1110 1 D Spring TRP1103 72 TRP1103 84 E Leg Extension TRP1104 8 TRP1122 12 F Leg Base TRP1105 4 TRP1111 6 G Screw ITEM IMAGE 16 TRP1106 24 TRP1106 H Washer I Spring Fixing Tool TRP1107 1 TRP1107 1 J Acce
PAGE 6
INSTALLATION AND ASSEMBLY TRAMPOLINE ASSEMBLY A A STEP 1: FRAME LAYOUT E Lay out the trampoline parts on the ground so that the top rail sections start to form a circle. When laying out the top rail sections, make sure that each section is arranged so that it will properly connect with adjacent sections. A E E F F F F E A A E E E A E A A STEP 2: LEGS ASSEMBLY E H G Assemble each leg base to the leg extensions, ensuring that the screw holes align.
PAGE 7
INSTALLATION AND ASSEMBLY TRAMPOLINE ASSEMBLY (continued) A A STEP 4: CONNECTION OF LEG BASES TO TOP RAIL CIRCLE Attach the leg supports assembled in Step 2 to the top rails, ensuring that the screw holes align, as shown on the right. Repeat this step until the full frame is standing. Tightly secure the leg extensions to the top rail frame with the screws and washers provided.
PAGE 8
INSTALLATION AND ASSEMBLY TRAMPOLINE ASSEMBLY (continued) STEP 6: SAFETY PAD ASSEMBLY A) Lay the safety pad over the outer edge of the circular frame. Be sure to cover all the springs, as shown on the right. B) S everal sets of straps are attached to the underside of the safety pad. Fasten these straps to the jumping mat by threading them through the triangular rings of the mat and tying them in a knot.
PAGE 9
INSTALLATION AND ASSEMBLY SAFETY ENCLOSURE PARTS LIST PART DESCRIPTION TR1005 PART NUMBER TR1005 12-FT 4 LEGS PART QTY TR1010 PART NUMBER TR1010 14-FT 6 LEGS PART QTY A Quick Clamp TRP1112 16 TRP1112 12 B Pole Cap TRP1113 8 TRP1113 6 C Pole Bottom Plug TRP1114 8 TRP1114 6 D Upper Pole Tube TRP1115 8 TRP1115 6 E Lower Pole Tube TRP1116 8 TRP1116 6 F Foam Tube TRP1117 16 TRP1117 12 G Safety Net TRP1118 1 TRP1119 1 H Spanner TRP1121 1 TRP1121 1 ITEM IMAGE
PAGE 10
INSTALLATION AND ASSEMBLY SAFETY ENCLOSURE ASSEMBLY B WARNING F • The trampoline enclosure is only to be used as an enclosure for a trampoline of a size for which the enclosure is designed. • Failure to exactly follow all instructions for assembling the safety D enclosure properly could result in the enclosure not functioning, as intended, to keep the trampoline user from falling off the edge of the trampoline, which may result in serious injury.
PAGE 11
INSTALLATION AND ASSEMBLY SAFETY ENCLOSURE ASSEMBLY (continued) STEP 2: SAFETY NET ASSEMBLY A) Ensure that the zippered entrance to the safety net is located between two trampoline support legs, and then place the safety net pole covers entirely over the installed enclosure pole tubes. Starting from the entrance, go left in a clockwise direction from one tube to the next. Repeat until all the pole tubes are covered.
PAGE 12
INSTALLATION AND ASSEMBLY TRAMPOLINE LADDER PLACEMENT Hook the pre-assembled access ladder onto the frame of the trampoline at the entrance to the safety enclosure net. No additional hardware is required. When the trampoline is not in use, always store the access ladder in a secure place so that unsupervised children cannot play on the trampoline. WARNING • The ladder lets children climb onto the trampoline. • Maximum user weight for the ladder should not exceed 220-lbs (100-kg).
PAGE 13
INSTALLATION AND ASSEMBLY WARNING LABEL PLACEMENT With the exception of the Safety Instructions placard, the remaining warning labels on this page have already been attached to the trampoline in the places indicated. The owner will need to place the Safety Instructions placard on the trampoline enclosure net to the right of the entrance zipper. The placard contains four drill holes that can be used to attach it to the net with the zip ties provided.
PAGE 14
TRAMPOLINE AND SAFETY ENCLOSURE DISASSEMBLY If you need to disassemble the trampoline, follow Safety Enclosure Assembly instructions (Steps 1–2) in reverse order and Trampoline Assembly instructions (Steps 1–6) in reverse order. DO NOT attempt to disassemble any frame components before the springs and the jumping mat have been removed. Use gloves to protect hands from pinch points during disassembly. Take special care to retain all parts. Retain the original packaging for transport and storage purposes.
PAGE 15
PRODUCT USE WARNING • DO NOT attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or death, even when landing in the middle of the bed (jumping mat). • DO NOT allow more than one person on the trampoline. Use by more than one person at the same time increases the chance of serious injuries. • Use trampoline only with mature, knowledgeable supervision. • Trampolines over 20-in (51-cm) tall are not for children under 6 years.
PAGE 16
PRODUCT USE SAFE USE INSTRUCTIONS (continued) SUPERVISION • Allow use of trampoline only with mature, knowledgeable supervision. Enforce all safety rules. • Supervise all trampoline users regardless of their age and experience. • Keep spectators at a safe distance of at least 10 feet from the trampoline while it is in use. • Maintain a clear area around the trampoline. • Keep objects away that could interfere with the jumper.
PAGE 17
PRODUCT USE SAFE USE INSTRUCTIONS (continued) SAFE USE PRACTICES FOR JUMPERS (continued) • DO NOT jump into the trampoline from an outside source. Hitting the frame or safety pad, or incorrectly landing on the trampoline can lead to injury. • DO NOT hang from, kick, cut, or climb on the safety net enclosure. • DO NOT try to jump over the enclosure or crawl under the safety net enclosure.
PAGE 18
PRODUCT USE FUNDAMENTAL BOUNCE TECHNIQUES Initially, get accustomed to the feel and bounce of the trampoline. The focus must be on body position. Each fundamental bounce should be practiced until it can be executed with skill before moving on to more difficult and advanced bounces. DO NOT bounce recklessly on the trampoline; focus on good control and mastering various bounce techniques. It is recommended that all trampoline jumpers become skilled at performing these basic bounces.
PAGE 19
CARE AND MAINTENANCE GENERAL CARE • Inspect the trampoline before each use and replace any worn, defective, or missing parts to avoid potential hazards, such as: - Missing, improperly positioned, or insecurely attached safety pad - Punctures, frays, tears, or holes worn in the jumping mat or safety pad - Deterioration in the stitching or fabric of the jumping mat or safety pad - Ruptured springs - A bent or broken frame - A sagging jumping mat - Sharp protrusions on the frame or suspension system •
PAGE 20
PRODUCT WARRANTY 1-YEAR LIMITED WARRANTY These products (models TR1005 and TR1010) are warranted to the original purchaser to be free from defects in material or workmanship for a period of one (1) year from the date of the original retail purchase. This warranty does not cover defects or damage due to improper installation, alteration, accident, or any other event beyond the control of the manufacturer. Defects or damage resulting from misuse, abuse, or negligence will void this warranty.