INSTRUCTION, USE & CARE MANUAL WM-530SS-30B | WM-530SS-30P
Table of Contents Table of Contents .......................................................... 2 Safety lnformation ......................................................... 2 Warranty ......................................................................... 4 Pre-installation .............................................................. 5 Installation ..................................................................... 8 Operation .....................................................................
Safety Information A READ AND SAVE THESE INSTRUCTIONS FOR DOMESTIC COOKING ONLY A INSTALLER: Leave this manual with the homeowner. HOMEOWNER: Use and Care information on Page If hood is to be installed Non-Ducted (Recirculation) , then purchase a set of (2) non-ducted charcoal filters from your local distributor or retailer and attach them to the motor. WARNING WARNING SUITABLE FOR USE IN HOUSEHOLD COOKING AREA.
Warranty This range hood is warranted to the original purchaser to be free of defects in material and workmanship for two(2)year from the date of purchase. Our obligation shall be limited to the repair or replacement of a unit (at our discretion) that may prove, by our sole examination, to be defective under normal use and service during the warranty period.
Pre-installation TOOLS REQUIRED □ � Measuring tape f !1,::::Q:::ll::: ::: ::e!i,::8 Level Utility knife Tape Adjustable wrench Flathead screwdriver Needle nose pliers Pencil e Phillips screwdriver � � Hammer Electric drill CD � Safety gloves HARDWARE INCLUDED I� AA NOTE, Haroware not shown to actual sl,e.
Pre-installation (continued) PACKAGE CONTENTS AA E � B AA BB Part Description Quantity A Range hood (including filters and lamps) C Chimney mounting bracket D Bottom chimney E Top chimney B Damper (located with the outlet adapter) 1 1 Hauslane 267 Wattis Way, San Francisco, CA 94124 Tel: 1-800-929-0168 E-mail: info@hauslane.
Pre-installation {continued) SPECIFICATIONS Dimensions WM-530SS: 760mm(29.4 in)W 480 mm (18.9 in.) D Volts 120 Hertz FanCFM 60 Base: 400 Pro: 750 675-1150mm(26.5-45.2 in.)H Speeds High Medium Low .E 0 ..,, ,.._ Hauslane 267 Wattis Way, San Francisco, CA 94124 Tel: 1-800-929-0168 E-mail: info@hauslane.
Installation 1 1. 2. 3. 2 INSTALLATION DRILLING AND LINING Draw a vertical line on the supporting wall up to the ceiling, or as high as practical, at the center of the area in which the hood will be installed. Draw a horizontal line at minimum 24 in and maximum 30 in above the cooking surface. Place chimney mounting bracket (C) on the wall as shown about 1 in. from the ceiling or upper limit aligning the center (notch) with the vertical reference line. 1.
Installation (continued) 3 DUCT FIXING ;% CAUTION: To reduce the risk of fire, metal ductwork is preferred. � (Metal duct should be sourced locally.) □ DUCTED MODE ;% CAUTION: To reduce the risk of fire, metal ductwork is preferred. � (Metal duct should be sourced locally.) Attach an adequate length of cp 6 in. round duct (not included) on the top the outlet adapter. Check and properly tape all joints on duct work to ensure proper connections. □ 1. 4 CONNECTIONS 1. 2.
Installation (continued) NON-DUCTED MODE A CAUTION: Do not use plastic or rigid metal ducting. 1. Install the charcoal filter (not included). 2. Please note that the air will flow out from the two grids on the two sides of the chimney top. t t ELECTRICAL CONNECTION WARNING: Electrical wiring must be done by a qualified person(s) in accordance with all applicable codes and standards. Tum off electrical power at service entrance before wiring.
Operation 1 OPERATION OF CONTROLS Settings: 0-0N/OFF 1- LOW SPEED 2- MEDIUM SPEED 3 - HIGH SPEED 4- LIGHT 4 3 2 1 0 Hauslane 267 Wattis Way, San Francisco, CA 94124 Tel: 1-800-929-0168 E-mail: info@hauslane.
Maintenance STAINLESS STEEL GREASE BAFFLE FILTER □ The grease filters should be cleaned frequently (every two months of operation, or more frequently for heavy use). Use a warm detergent solution. Grease filters are washable. □ ( 1) PUSH DOWN ( 2) LIFT OUT 1. Remove the grease filters one by one by pushing down each handle. This will disengage the filter from the hood. Tilt the filter downward and remove. 2. Wash the filters, taking care not to bend them. Allow them to be dry before refitting. 3.
Maintenance (continued) NON-DUCTED RECIRCULATION CHARCOAL FILTER {NOT INCLUDED) □ This charcoal filter(not included) is not washable, cannot be regenerated, and should be replaced approximately every 3 months of operation, or more frequently in the case of heavy usage. 1. Remove the outer filters. 2. The charcoal filters(not included) must be applied to the suction unit in side the hood, centering them inside of it and turning them 90 °until they snap into place. 3.
Care and Cleaning J.\ WARNING: Failure to maintain basic standards of care and � cleaning of the range hood will increase the risk of fire . The range hood should be cleaned regularly internally and externally to preserve its appearance and performance. Do □ □ □ □ □ Do Not □ Do not use corrosive or abrasive detergents, or any products containing chloride, fluoride, iodide, or bromide on this product, as they will deteriorate the surface rapidly.
Troubleshooting A DANGER: Tum off the power circuit breaker or the power switch on the Junction box before Installing or servicing this unit. Touching circuitry inside the range hood while it is energized will result in death or serious injury. Problem The range hood will not operate. The range hood vibrates when the fan is operating. The fans seem weak. The lights work, but the fan is not spinning, is stuck, or is rattling. The range hood is not venting properly. A light does not work.
Wiring Diagram For models: WM-530SS-30B and WM-530SS-30P KEY SWITCH HIGH LAMP @ L ;:'i � �0 2 (i) ;a:;, m -< :;;: GREEN "' ► " "' ► " 0 "' ► " C ii1 GREEN WHITE :;;: I ii1 - WHITE BLUE Hauslane 267 Wattis Way, San Francisco, CA 94124 @) ;a:;, m -< :;;: I Tel: 1-800-929-0168 E-mail: info@hauslane.