OWNER’S MANUAL Room Air Heat Pump with R-410A: RAH-183G Heat Controller, Inc. • 1900 Wellworth Ave. • Jackson, MI 49203 • (517)787-2100 • www.heatcontroller.
Heat Controller, Inc. Room Air Heat Pump with R-410A Contents Owner’s Manual Comfort ZoneTM Room Air Conditioner & Heat Pump Use and Care Manual Introduction. ............................................................. Introduction ..................................................................1 1 Safety Information................................................... Safety Information .......................................................1 1 Normal Care & Maintenance.............................
Room Air Heat Pump with R-410A Owner’s Manual WARNING WARNING To avoid death, personal injury or property damage due to electrical shock: HIGH TEMPERATURE STRESS HAZARD This room air conditioner is not meant to provide unattended cooling or life support for persons or animals that are unable to react to failure of the product. • • • • The failure of an unattended air conditioner may result in extreme heat in the conditioned space causing overheating or death of persons or animals.
Room Room Air Air Heat Heat Pump Pump with with R-410A R-410A Heat Heat Controller, Controller, Inc. Inc. Unit Unit Plug Plug Type Type Receptacle Receptacle Required Required Circuit Circuit Rating, Rating, Breaker, Breaker, Time Time Delay Delay Fuse Fuse Room Heat Pumps Voltage Voltage Rating Rating On On Nameplate Nameplate NEMA NEMA No. No. 5-15P 5-15P NEMA NEMA No. No. 5-15R 5-15R 125V-15AMP 125V-15AMP 115V 115V NEMA NEMA No. No. 6-15P 6-15P NEMA NEMA No. No.
Owner’s Manual Room Air Heat Pump with R-410A Front Grille and Filter Removal The front contains a removable grille that provides easy access to the air filter. To clean the filter use one of the following methods for filter removal: Heat Controller, Inc. Optional Air Filter Installation Remove air filter from plastic bag. Insert three tabs on right side of filter into three slots on filter frame. Carefully bow middle of filter until two tabs on filter can be inserted into two slots on filter frame.
Room Air Heat Pump with R-410A Heat Controller, Inc. from outer case. Use both hands to grasp basepan and pull remaining chassis from outer case. PLASTIC FRONT BASEPAN CLIP Owner’s Manual Drain Cup Installation and Use (on some models) Your air conditioner uses a system where the water removed from the indoor air (condensate) is channeled to the outdoor side of the unit.
IMPORTANT — Save these ● of this air conditioner. Aluminum house wiring may present special problem s —consult a qualified electrician. instructions for local inspector's use. IMPORTANT — Observe all ● Owner’s Manual governing codes and ordinances. Room Air Heat Pump with R-410A ● Installation Ins tructions ● ● ● ● ● ● Heat Controller, Inc. Note to Installer — Be sure to leave these instructions with the Consum er.
Room Air Heat Pump with R-410A Heat Controller, Inc.
Room Air Heat Pump with R-410A Owner’s Manual Heat Controller, Inc. Installation Instructions 1 WINDOW REQUIREMENTS ● ● ● ● 3 REMOVE THE AIR CONDITIONER FROM THE CASE These instructions are for a standard double-hung window. You will need to modify them for other types of windows. T he air conditioner can be ins talled without the accordion panels if needed to fit in a narrow window. See the window opening dim ens ions . All supporting parts must be secured to firm wood, m as onry or m etal.
Room Air Heat Pump with R-410A Heat Controller, Inc. Owner’s Manual Installation Instructions 6 INSTALL THE CASE 5 PREPARE THE CASE IN THE WINDOW A Install the top mounting rail with 4 type B screws from the inside of the case. A Carefully slide the case into the window and center the case. Lower the window behind the top mounting rail. Pull the bottom of the case forward so that the bottom mounting rail is tight against the back of the window stool.
Room Air Heat Pump with R-410A Owner’s Manual Heat Controller, Inc. Ins tallation Ins tructions BRACKETS 7 INSTALL INSTALLSUPPORT SUPPORT BRACKETS 6 INSTALL THE CASE AND FOAM GASKET ANDTOP THEWINDOW FOAM TOP WINDOW IN THE WINDOW (cont.) GA S K E T D Adjust the leveling bolts and nuts against the outside wall so that the case has a slight tilt to the outside. Tighten nuts with an adjustable wrench. Use a level; about a 1/2 bubble will be the correct case slant to the outside.
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Ins tallation Ins tructions 8 INS INSTALL CONDITIONER TALLTHE THEAIR AIR CONDITIONER 8 INSTALL THE AIR CONDITIONER A Slide the air conditioner into the case. Do not push on the controls or the finned coils. Make sure the air conditioner is firmly seated. G Pull the coiled power cord from its shipped IN THE IN THECASE CASE IN THE CASE CASE(cont.) (cont.) position in the air discharge area.
Room Air Heat Pump with R-410A Owner’s Manual Room Air Heat Pump with R-410A Owner’s Manual Operating Controls(For Electronic units) Operating your air conditioner properly helps you to obtain the best possible results. For Electronic units Electronic units This section explains proper For air conditioner operation. Operating your air conditioner properly helps you to obtain the IMPORTANT: best possible results.
Room Air Heat Pump with R-410A Heat Controller, Inc. Owner’s Manual Timer/Delay OFF—the When air conditioner TIMER OFF—When airthe conditioner is on,is on, Cooling Descriptions it can be set to automatically turn off in 0.5 to 24 hours. For Normal Cooling—Select the Cool mode and High or Med fan with a middle set temperature. How to set: For Maximum Cooling—Select the Cool mode and High fan with a lower set temperature. Press the TIMER TIMER 0.
Temperature Control blowing Slide this control to the left for a warmer room temperature, before Owner’s to the right for a cooler room temperature. Manual Room Air Heat Pump with R-410A the fan d dehus setting the fan d dehus setting the fan while the etting for the fan while the s setting Vent Control Choose one of the following two settings by sliding the vent control under the appropriate marking: OPEN – Exhausts room air to the outdoors. Also circulates and filters room air.
Heat Controller, Inc. Room Air Heat Pump with R-410A Owner’s Manual Troubleshooting Before Calling Service WARNING To reduce the risk of electric shock, personal injury, or death, turn the fan control to the off position and remove the unit plug from the wall outlet before doing any inspection or maintenance work. The following is a list of problems that are sometimes encountered when using a room air conditioner. Possible cause and suggested remedies are given for each problem.
Owner’s Manual Room Air Heat Pump with R-410A This Page was Left Intentionally Blank 16 Heat Controller, Inc.
Heat Controller, Inc.
07/2010 04/2009 66129905195