Owner manual

ManualsBrandsHeatStream ManualsRadiatorsHS-150V-GFA

Consumer: Please Read These Instructions And Keep For Your Reference

Model Numbers: HS-40-GFA, HS-60V-GFA,

HS-125V-GFA, HS-150V-GFA

User’s Manual and

Operating Instructions

668 Stony Hill Road #302 Yardley, PA 19067 USA Toll Free: (800) 641-6996

Fax: (215) 891-8461 • Web: www.pinnacleint.com • Email: info@pinnacleint.com

221000162-12

FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS

HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS OR

DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN. ASPHYXIATION, CARBON

MONOXIDE POISONING AND / OR ELECTRIC SHOCK.

ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW THE INSTRUCTIONS SHOULD USE

OR SERVICE THIS HEATER.

IF YOU NEED ASSISTANCE OR HEATER INFORMATION SUCH AS AN INSTRUCTIONS

MANUAL, LABEL, ETC. CONTACT THE MANUFACTURER.

Carbon Monoxide Hazard This heater produces carbon monoxide, which has no odor. Burning the heater in an

enclosed space can kill you. Never use the heater in enclosed spaces such as a tent, a camper, any vehicle or

recreational vehicle (RV), enclosed shelter, or any other enclosed areas.

Not for use in residential living areas or in non-adequately ventilated enclosed spaces. Never bring or store a

propane cylinder indoors.

Summary of content (12 pages)

PAGE 1
User’s Manual and Operating Instructions Model Numbers: HS-40-GFA, HS-60V-GFA, HS-125V-GFA, HS-150V-GFA Consumer: Please Read These Instructions And Keep For Your Reference FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN. ASPHYXIATION, CARBON MONOXIDE POISONING AND / OR ELECTRIC SHOCK.
PAGE 2
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Table of Contents Safety Information........................................... 2-3 Unpacking ...........................................................3 Features ............................................................ 4 Propane Information ....................................... 4-5 Pre-Lighting Instructions .................................... 5 Ventilation .................................
PAGE 3
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Safety Information (continued) grounding connection must comply with National Electrical Code - ANSI/NFPA 70 (USA) and CSA C22.1 Canadian Electrical Code, Part 1 (Canada). This is a direct-fired, forced-air construction heater for either indoor or outdoor use. It's intended use is primarily for the temporary heating of buildings under construction, alteration or repair.
PAGE 4
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Features - Portable, stable and fully assembled. - 100% safety shut-off system. - Wind resistant and rain protected. - Adjustable input ratings (Except HS-40-GFA). - Continuous spark ignition or piezo spark ignition. - Adjustable Height Controller.
PAGE 5
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Propane Supply / Information (Continued) Propane is safe to use when properly handled. Careless handling of the LP cylinder could result in a fire and/or an explosion. Therefore: - Tightly close the gas shutoff valve on the LP cylinder after each use. CAUTION - All fittings must be protected when disconnected from the LP cylinder.
PAGE 6
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Ventilation - a two-car garage door open 6 inches, or Always provide a fresh air opening in the heated space of at least three square feet (2,800 sq. cm.) for each 100,000 BTU/Hr of heater output. For example, a HS-150V-GFA will require: CAUTION - a single car garage open 9 inches, or - two thirty two inch wide windows open 15 inches. Lighting Instructions TO START .SHUTDOWN INSTRUCTIONS 1.
PAGE 7
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Wiring Diagrams NOTE: If any original wiring as supplied with the heater must be replaced, it must be with type AWG 105°C wire or its equivalent, except as indicated. Figure 5: Wiring Diagram for Piezo/Manual Spark Models NOTE: If any original wiring as supplied with the heater must be replaced, it must be with type AWG 105°C wire or its equivalent, except as indicated.
PAGE 8
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE 28 25 15 4 24 2 10 11 9 6 26 7 8 18 3 1 21 27 12 23 22 5 19 20 13 14 16 17 Exploded View Figure 7: Exploded View for all models © 2012, Pinnacle Products International, Inc.
PAGE 9
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Parts Breakdown Reference Number Description Part Number for Models: HS-40-GFA HS-60V-GFA HS-125V-GFA HS-150V-GFA Quantity 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Outer Shell Inner Shell Assembly Base Height Controller Base Cover Inner Shell Cap Multi Bracket Assembly Thermal Switch Tubing Assembly Nozzle Nozzle Nut Handle Flange Hex Nut Fan Cushion Pad Mot
PAGE 10
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE Troubleshooting Symptom Possible Cause(s) 1. No electric power to heater. Fan does not turn when electricity is connected 2. Blades of fan in contact with heater housing. 3. Fan blades bent. 4. Fan motor defective. 1. No spark at module. 1. Inspect module wire. Re-attach, or tighten if loose. Inspect Spark module, and replace if necessary. Inspect all other electrical components. 2.
PAGE 11
NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE, OR WHILE CONNECTED TO A FUEL SOURCE LIMITED WARRANTY Pinnacle Products International, Inc. warrants this heater to the original retail purchaser only, to be free from defects in material and workmanship for a period of one (1) year from the date of initial purchase. This product must be properly installed, maintained and operated in accordance with the instructions provided. Pinnacle Products International, Inc.
PAGE 12