Technical Specifications

Spec Sheet #S00208
CLOROBEN PRODUCTS
Hercules Chemical Company, Inc.
111 South Street, Passaic, NJ 07055-9100
Phone: [phone] • Fax: [phone]
e-mail: [e-mail]
©2000 WRZ
APPROVALS AND LISTINGS
SPECIFIC USES
SPECIFIC APPLICATIONS*
Cloroben PT-4 can be used to improve flow of gravel absorption beds around
cesspools, drywells, leach tanks and drain field laterals. Can be used to clean lines to
and from grease traps, cleans main lines or soil stacks/vents of apartment buildings,
condominiums and hotels or for commercial applications; controls grease caking and
fouling in clarifiers, lines and digesters and helps maintain good percolation in aeration
basins of municipal waste treatment plants.
PHYSICAL PROPERTIES
Density: 7.95 lb./ gallon
Solubility in water: Complete in water or oil
Flash Point: TCC 1000 PPM. Solution: Greater than 160° F
Freeze Point: 10°F
Fragrance: Pine
pH: 7.5 - 8.5
Appearance and color: Clear gold liquid
WARNINGS OR CAUTIONS
• Cautions-concentrate is a combustible liquid-keep away from sparks, heat
and flames.
• Read all cautions and directions carefully before using this product.
• Avoid contact with eyes, skin and clothing. May cause skin irritation. Do not wear
contact lenses.
• Harmful or fatal if swallowed.
• Use with adequate ventilation. Avoid prolonged or repeated inhalation of
concentrated fumes in confined areas.
• Do not reuse container. Dispose of container in accordance with applicable
regulations.
• Avoid contact with food.
• In the event of a spill, pick up and discard in accordance with local, state, and
federal regulations. Waste material may become combustible. Wash down spill
area with water.
• Do not mix with other chemicals.
• Avoid contact with painted surfaces, linoleum, asphalt, and rubber. Prompt washing
with plenty of water will minimize damage if spilled on the preceding materials.
USDA Authorized
Use Cloroben PT-4 to improve flow and reduce odors caused by deposits of grease,
sludge, and hard water soap scum. PT-4 also disperses food residue, coffee grounds,
and other particulate matter. May be used as a cleaner/degreaser/emulsifier during
mechanical snaking.
PT-4
™
Flow Improver
MATERIAL SAFETY INFORMATION
FOR MORE INFORMATION ON THIS PRODUCT, REQUEST MATERIAL
SAFETY DATA SHEET (MSDS) #208
HMIS Hazard warning 1-2-1-G
INGREDIENTS CAS#
Biochemical Terpene Microemulsion
Terpene Hydrocarbon Mixture 68956-56-9
Triethanolaminedodecylbenzenesulfonate 27323-41-7
NJ-T.S.R. #12810000000 1001P, 1002P
* For special applications which may not be covered on this or other
Cloroben literature, please contact Cloroben Technical Services
Department by phone at 1-800-221-9330 or
send a fax to 1-800-333-3456.
DIRECTIONS FOR USE
Do not use PT-4 on clogged drains. There must be some flow through the line
before treatment. For slow drains/drain odor mix 2 ounces of product with 8
ounces of hot water, or fill to lines on mixing jar. Add the solution to the drain
nightly until flow is restored and odors are gone, typically one to three daily appli-
cations. For best results, allow to work overnight or at least two hours before
resuming drain use.
For preventive maintenance - Use 1 ounce of product mixed with 4 ounces of
water weekly for each 2 household occupants. Treat a different drain each week.
LINE SNAKING- 1) Blend 1 part product with 4 parts warm water. 2) Begin using
a mechanical snake while adding this solution to the line. The product’s emulsify-
ing action helps keep grease and sludge from redeposition on pipe walls for faster
more complete cleaning. 3) Flush out the line with hot water while still running the
snake. 4) Begin a preventative maintenance program.
COMMERCIAL PREVENTATIVE MAINTENANCE- Dispense product daily using
1 oz. for each inch of line diameter and 50 feet of drain line, or use 2 oz. for every
100 meals served. For best results add before the longest period of non-use.
Flush with warm water the following day. When adding manually into sink traps,
follow with 1 pint of warm water to flush the product past the trap.
For Delivery by Fax Call 1-800-942-4636
Internet See MSDS section of www.cloroben.com
Mail Contact Cloroben at address below
or any Cloroben representative
For Commercial Use - Can be used with Cloro-Doser
®
to
automatically dispense upstream of grease traps or directly
into sewage ejectors and drain lines.
(See Cloro-Doser Spec Sheet #S01005)