Safety Data Sheet

ManualsBrandsHercules ManualsChemicals & Compounds16 oz. Medium Body, Fast Set PVC Cement (Clear)

SAFETY DATA SHEET

1. Identification

Hercules PVC Medium Body Fast Set CementProduct identifier

Other means of identification

Part Numbers: 60103, 60113, 60115, 60120

Synonyms

Joining PVC Pipes

Recommended use

None known.

Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

HCC Holdings, Inc. an Oatey Affiliate

Company Name

4700 West 160th Street

Address

Cleveland, OH 44135

216-267-7100

Telephone

info@oatey.com

E-mail

Chemtrec 1-800-424-9300 (Outside the US 1-703-527-3887)

Transport Emergency

1-877-740-5015

Emergency First Aid

MSDS Coordinator

Contact person

2. Hazard(s) identification

Category 2Flammable liquids

Physical hazards

Category 4Acute toxicity, oral

Health hazards

Category 2Skin corrosion/irritation

Category 2ASerious eye damage/eye irritation

Category 3 respiratory tract irritationSpecific target organ toxicity, single exposure

Category 3 narcotic effectsSpecific target organ toxicity, single exposure

Category 1Aspiration hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Highly flammable liquid and vapor. Harmful if swallowed. May be fatal if swallowed and enters

airways. Causes skin irritation. Causes serious eye irritation. May cause respiratory irritation. May

cause drowsiness or dizziness.

Precautionary statement

Prevention

Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep container tightly

closed. Ground/bond container and receiving equipment. Use explosion-proof

electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary

measures against static discharge. Avoid breathing mist/vapors. Wash thoroughly after handling.

Do not eat, drink or smoke when using this product. Use only outdoors or in a well-ventilated area.

Wear protective gloves/eye protection/face protection.

Response

If swallowed: Immediately call a poison center/doctor. Rinse mouth. Do NOT induce vomiting. If

on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. If

inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse

cautiously with water for several minutes. Remove contact lenses, if present and easy to do.

Continue rinsing. Call a poison center/doctor if you feel unwell. If skin irritation occurs: Get

medical advice/attention. If eye irritation persists: Get medical advice/attention. Take off

contaminated clothing and wash before reuse. In case of fire: Use appropriate media to

extinguish.

Hercules PVC Medium Body Fast Set Cement SDS US

948998 Version #: 01 Revision date: - Issue date: 02-April-2019

1 / 12

Summary of content (12 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Hercules PVC Medium Body Fast Set Cement Other means of identification Synonyms Part Numbers: 60103, 60113, 60115, 60120 Recommended use Joining PVC Pipes Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Company Name Address HCC Holdings, Inc. an Oatey Affiliate 4700 West 160th Street Cleveland, OH 44135 Telephone E-mail Transport Emergency Emergency First Aid Contact person 216-267-7100 info@oatey.
PAGE 2
Storage Keep cool. Store in a well-ventilated place. Keep container tightly closed. Store locked up. Disposal Dispose of contents/container in accordance with local/regional/national/international regulations. Hazard(s) not otherwise classified (HNOC) Frequent or prolonged contact may defat and dry the skin, leading to discomfort and dermatitis. May form explosive peroxides. Supplemental information None. 3.
PAGE 3
6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Avoid breathing mist or vapor.
PAGE 4
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Tetrahydrofuran (CAS 109-99-9) PEL Value 590 mg/m3 200 ppm US. OSHA Table Z-3 (29 CFR 1910.1000) Components Fumed Silica (CAS 112945-52-5) Type Value TWA 0.8 mg/m3 Form 20 mppcf Polyvinyl chloride (CAS 9002-86-2) TWA 5 mg/m3 Respirable fraction. 15 mg/m3 Total dust. 50 mppcf Total dust. 15 mppcf Respirable fraction. Form US.
PAGE 5
US.
PAGE 6
Color Clear. Odor Solvent. Odor threshold Not available. pH Not available. Melting point/freezing point Not available. Initial boiling point and boiling range 151 °F (66.1 °C) Flash point 14.0 - 23.0 °F (-10.0 - -5.0 °C) Evaporation rate 5.5 - 8 Flammability (solid, gas) Not applicable. Upper/lower flammability or explosive limits 1.8 Flammability limit - lower (%) Flammability limit - upper (%) 11.8 Explosive limit - lower (%) Not available. Explosive limit - upper (%) Not available.
PAGE 7
Symptoms related to the physical, chemical and toxicological characteristics Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. May cause respiratory irritation. Skin irritation. May cause redness and pain. Information on toxicological effects Acute toxicity Components Harmful if swallowed. May be fatal if swallowed and enters airways.
PAGE 8
Risk of cancer cannot be excluded with prolonged exposure. In 2012 USEPA Integrated Risk Information System (IRIS) reviewed a two species inhalation lifetime study on THF conducted by NTP (1998). Male rats developed renal tumors and female mice developed liver tumors while neither the female rats nor the male mice showed similar results.
PAGE 9
Components Chronic Algae NOEC Persistence and degradability Species Test Results Scenedesmus quadricauda 3700 mg/l, 8 days No data is available on the degradability of this product. Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) Acetone (CAS 67-64-1) -0.24 Cyclohexanone (CAS 108-94-1) 0.81 Methyl ethyl ketone (CAS 78-93-3) 0.29 Tetrahydrofuran (CAS 109-99-9) 0.46 The product is immiscible in water.
PAGE 10
Environmental hazards Marine pollutant EmS Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code No. F-E, S-D Read safety instructions, SDS and emergency procedures before handling. Not established. 15. Regulatory information US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated.
PAGE 11
FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace Acetone (CAS 67-64-1) Low priority Cyclohexanone (CAS 108-94-1) Low priority Methyl ethyl ketone (CAS 78-93-3) Low priority US state regulations US. Massachusetts RTK - Substance List Acetone (CAS 67-64-1) Cyclohexanone (CAS 108-94-1) Fumed Silica (CAS 112945-52-5) Methyl ethyl ketone (CAS 78-93-3) Tetrahydrofuran (CAS 109-99-9) US.
PAGE 12
HMIS® ratings Health: 3 Flammability: 3 Physical hazard: 0 NFPA ratings 3 2 Disclaimer 0 HCC Holdings Inc. an Oatey Affiliate cannot anticipate all conditions under which this information and its product, or the products of other manufacturers in combination with its product, may be used. It is the user’s responsibility to ensure safe conditions for handling, storage and disposal of the product, and to assume liability for loss, injury, damage or expense due to improper use.