LP Portable to LP Piped Systems Kit Guide

ManualsBrandsHestan ManualsBarbecue36 Inch Built-In Grill with with 653 sq. in. Grilling Area, 2 Trellis Tubular Burners, 1 Sear Burner, Rotisserie, 89,000 BTU, Horizon Spring Assisted Hood, Warming Rack, Temperature Gauge and Hot Surface Ignition: Liquid Propane / Matador

LP PORTABLE TO

LP PIPED SYSTEMS KIT

AGCKLPP

IMPORTANT - READ ALL INSTRUCTIONS BEFORE YOU BEGIN

THE INSTRUCTIONS HEREIN SHOULD BE PERFORMED BY A QUALIFIED SERVICE TECHNICIAN.

THE APPLIANCE MUST BE COMPLETELY COOL AND THE PREVIOUS GAS SOURCE MUST BE SHUT

OFF OR REMOVED BEFORE ATTEMPTING INSTALLATION.

Some parts inside your grill or side burner have sharp edges. Care must be taken when handling the

various components to avoid personal injury. Wear gloves when handling.

TOOLS REQUIRED:

Work gloves

Safety glasses

Phillips screwdriver

Pipe wrench or large slip-joint pliers

Adjustable Wrenches (2)

Thread sealant

IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED

EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING

PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Flammable Gas - disconnect all propane or natural gas supplies to this

unit before servicing.

Electrical Parts & Components – disconnect all power supplies and

batteries before servicing.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

DANGER

1. Do not store or use gasoline or

other flammable liquids or vapors

in the vicinity of this or any other

appliance.

2. An LP cylinder not connected for

use shall not be stored in the vicinity

of this or any other appliance.

READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING YOUR

GRILL TO REDUCE THE RISK OF FIRE, BURN HAZARD, OR OTHER INJURY.

KEEP THIS MANUAL FOR FUTURE REFERENCE.

APPLICABLE APPLIANCES:

GRILLS - GABR / GSBR / GMBR / EAB / EABR / EMB / EMBR

SIDE BURNER - AGB / AEB

Summary of content (5 pages)

PAGE 1
LP PORTABLE TO LP PIPED SYSTEMS KIT EN AGCKLPP APPLICABLE APPLIANCES: GRILLS - GABR / GSBR / GMBR / EAB / EABR / EMB / EMBR SIDE BURNER - AGB / AEB IMPORTANT - READ ALL INSTRUCTIONS BEFORE YOU BEGIN THE INSTRUCTIONS HEREIN SHOULD BE PERFORMED BY A QUALIFIED SERVICE TECHNICIAN. THE APPLIANCE MUST BE COMPLETELY COOL AND THE PREVIOUS GAS SOURCE MUST BE SHUT OFF OR REMOVED BEFORE ATTEMPTING INSTALLATION. Some parts inside your grill or side burner have sharp edges.
PAGE 2
CHANGING REGULATOR (FOR UNITS WITH PORTABLE LP TANKS) An LP piped system is one with a large central LP tank that feeds an entire household. These systems are normally equipped with a high pressure regulator by the large LP tank, and low pressure regulators close to the home. EN This kit is to be used if your Hestan or Aspire grill or side burner was already supplied with a 2-stage LP regulator / hose assembly. The kit includes a special regulator for use with LP Piped systems. 1.
PAGE 3
TESTING & ADJUSTMENT LEAK TESTING GENERAL A complete gas tightness check must be performed of all gas-carrying components due to possible movement during installation, or excessive pressure unknowingly being applied to parts of the unit. EN BEFORE TESTING • Do not smoke while leak testing. • Never leak test with an open flame. • Make a soap solution of one part liquid detergent and one part water for leak testing purposes. • Apply the solution to the gas fittings by using a spray bottle or a brush.
PAGE 5
RETAIN THIS MANUAL FOR FUTURE REFERENCE Hestan Commercial Corporation 3375 E.