Operation Manual

'"
G
B
/PERATINGPROCEDURES
&UEL&IG
7!2.).'
4HISUNITISEQUIPPEDWITHATWOSTROKEENGINE!LWAYSRUNo
THEENGINEONFUELWHICHISMIXEDWITHOIL
0ROVIDEGOODVENTILATIONWHENFUELINGORHANDLINGFUEL
&UELCONTAINSHIGHLYČAMMABLEANDITISPOSSIBLETOGETTHEo
SERIOUSPERSONALINJURYWHENINHALINGORSPILLINGONYOURBODY
!LWAYSPAYATTENTIONWHENHANDLINGFUEL!LWAYSHAVEGOOD
VENTILATIONWHENHANDLINGFUELINSIDEBUILDING
&UEL
!LWAYSUSEBRANDEDOCTANEUNLEADEDGASOLINEo
5SEGENUINETWOCYCLEOILORUSEAMIXBETWEENTOo
PLEASECONSULTTHEOILBOTTLEFORTHERATIOOR()4!#()!UTHORIZED
3ERVICE#ENTERS
)FGENUINEOILISNOTAVAILABLEUSEANANTIOXIDANTADDEDQUALITYo
OILEXPRESSLYLABELEDFORAIRCOOLEDCYCLEENGINEUSE*!3/&#
'2!$%/),OR)3/%'#'2!$%$ONOTUSE")!OR4#7STROKE
WATERCOOLINGTYPEMIXEDOIL
.EVERUSEMULTIGRADEOIL7ORWASTEOILo
!LWAYSMIXFUELANDOILINASEPARATECLEANCONTAINERo
!LWAYSSTARTBYüLLINGHALFTHEAMOUNTOFFUELWHICHISTOBEUSED
4HENADDTHEWHOLEAMOUNTOFOIL-IXSHAKETHEFUELMIXTURE
!DDTHEREMAININGAMOUNTOFFUEL
-IXSHAKETHEFUELMIXTHOROUGHLYBEFOREüLLINGTHEFUELTANK
&UELING
7!2.).'
!LWAYSSHUTOFFTHEENGINEBEFOREREFUELINGo
3LOWLYOPENTHEFUELTANKWHENüLLINGUPWITHFUELSOTHATo
POSSIBLEOVERPRESSUREDISAPPEARS
4IGHTENTHEFUELCAPCAREFULLYAFTERFUELINGo
!LWAYSMOVETHEUNITATLEASTMFTFROMTHEFUELINGAREAo
BEFORESTARTING
!LWAYS7ASHANYSPILLEDFUELFROMCLOTHINGIMMEDIATELYWITHo
SOAP
"ESURETOCHECKANYFUELLEAKINGAFTERREFUELINGo
"EFOREFUELINGCLEANTHETANKCAPAREACAREFULLYTOENSURETHAT
NODIRTFALLSINTOTHETANK-AKESURETHATTHEFUELISWELLMIXEDBY
SHAKINGTHECONTAINERBEFOREFUELING
#HAINOIL&IG
&ILLUPWITHCHAINOIL!LWAYSUSEGOODQUALITYCHAINOIL7HEN
THEENGINEISRUNNINGTHECHAINOILISAUTOMATICALLYDISCHARGED
./4%
!DDCHAINOILWHENITSLEVELLOWERSTOONECENTIMETERFROMBOTTOM
&IG
!$*534-%.4/&#(!)./),3500,9
4HECHAINOILQUANTITYDISCHARGEDTHROUGHTHELUBRICATIONSYSTEMIS
FACTORYADJUSTEDTOTHESTANDARD!DJUSTTHEQUANTITYINACCORDANCE
WITHTHEOPERATINGCONDITION4HENUMBEREDLABELDESCRIBES
ORDEROFCHAINOILADJUSTMENT&IG
,OOSENTHEüXINGSCREWONETURN&IGo
4URNTHEADJUSTINGSCREWCLOCKWISETODECREASETHEQUANTITYo
ANDTURNITCOUNTERCLOCKWISETOINCREASETHEQUANTITY
&IG
$ONOTTRYTOTURNTHESCREWCLOCKWISEBEYOND)TURNFROMo
ITSMOSTCOUNTERCLOCKWISEPOSITIONORTHEMAXIMUMQUANTITY
DISCHARGEDPOSITION
!FTERADJUSTMENTHASBEENMADETIGHTENüXINGSCREWo
&IG
./4%
7HENYOUHAVELOSTTHEPROPERPOSITIONOFTHESCREWSTARTWITH
THEMOSTCOUNTERCLOCKWISEPOSITION
3TARTING&IG
#!54)/.
"EFORESTARTINGMAKESURETHECUTTINGATTACHMENTDOESNOTTOUCH
ANYTHING
3ETIGNITIONSWITCHTO/.POSITION
0USHPRIMINGBULBSEVERALTIMESSOTHATFUELČOWSTHROUGH
THEBULBORRETURNPIPE)FSOEQUIPPED&IG
7ITHTHETHROTTLETRIGGERLOCKOUTPRESSEDIFSOEQUIPPEDPULL
THROTTLETRIGGERANDPUSHTHROTTLELOCKTHENSLOWLYRELEASETHE
THROTTLETRIGGERTHENTHROTTLETRIGGERLOCKOUT4HISISWILLLOCKTHE
THROTTLEINSTARTINGPOSITION
3ETCHOKELEVERTO#,/3%$POSITION&IG
0ULLRECOILSTARTERBRISKLYTAKINGCARETOKEEPTHEHANDLEINYOUR
GRASPANDNOTALLOWINGITTOSNAPBACK
7HENYOUHEARTHEENGINEWANTTOSTARTRETURNCHOKELEVERTO
25.POSITIONOPEN4HENPULLRECOILSTARTERBRISKLYAGAIN
./4%
)FENGINEDOESNOTSTARTREPEATPROCEDURESFROMTO
!FTERSTARTINGENGINEPULLTHROTTLETRIGGERTORELEASETHROTTLELOCK
4HENALLOWTHEENGINEABOUTMINUTESTOWARMUPBEFORE
SUBJECTINGITTOANYLOAD