Operation Manual

'"
#(!).3(!20%.).'0ARTSOFACUTTER&IG
7!2.).'
'LOVESSHOULDBEUSEDWHENSHARPENINGCHAIN
7!2.).'
"ESURETOROUNDOFFTHEFRONTEDGETOREDUCETHECHANCEOF
KICKBACKORTIESTRAPBREAKAGE
4OPPLATE
7ORKINGCORNER
3IDEPLATE
'ULLET
(EEL
#HASSIS
2IVETHOLE
4OE
$EPTHGAUGE
#ORRECTANGLEONTOPPLATEDEGREEOFANGLEDEPENDSONCHAIN
TYPE
3LIGHTLYPROTRUDINGHOOKORPOINTCURVEONNONCHISELCHAIN
4OPOFDEPTHGAUGEATCORRECTHEIGHTBELOWTOPPLATE
&RONTOFDEPTHGAUGEROUNDEDOFF
,/7%2).'$%04('!5'%37)4(!&),%
)FYOUSHARPENYOURCUTTERSWITHAüLEHOLDERCHECKANDLOWER
THEDEPTH
#HECKDEPTHGAUGESEVERYTHIRDSHARPENING
0LACEDEPTHGAUGETOOLONCUTTER)FDEPTHGAUGEPROJECTSüLEIT
LEVELWITHTHETOPOFTHETOOL!LWAYSüLEFROMTHEINSIDEOFTHE
CHAINTOWARDANOUTSIDECUTTER&IG
2OUNDOFFFRONTCORNERTOMAINTAINORIGINALSHAPEOFDEPTHGAUGE
AFTERUSINGDEPTHGAUGETOOL!LWAYSFOLLOWTHERECOMMENDED
DEPTHGAUGESETTINGFOUNDINTHEMAINTENANCEOROPERATOR
MANUALFORYOURSAW&IG
'%.%2!,).3425#4)/.3&/2&),).'#544%23
&ILECUTTERONONESIDEOFTHECHAINFROMTHEINSIDEOUT
&ILEONFORWARDSTROKEONLY&IG
+EEPALLCUTTERSTHESAMELENGTH&IG
&ILEENOUGHTOREMOVEANYDAMAGETOCUTTINGEDGESSIDEPLATE
ANDTOPPLATEOFCUTTER&IG
3(!20%.).'!.',%3&/23(!20%.).'3!7#(!).
0ART.UMBER 6'08
0ITCH 
$ETH'AUGE3ETTIG 
3IDE0LATE&ILING!NGLE 
4OP0LATE!NGLE 
&ILE'UIDE!NGLE 




-AINTENANCESCHEDULE
"ELOWYOUWILLüNDSOMEGENERALMAINTENANCEINSTRUCTIONS&OR
FURTHERINFORMATIONPLEASECONTACT()4!#()!UTHORIZED3ERVICE
#ENTERS
$AILYMAINTENANCE
o#LEANTHEEXTERIOROFTHEUNIT
o#LEANTHECHAINOILüLTERPORT
o#LEANTHEGROOVEANDOILüLTERPORTINTHEGUIDEBAR
o#LEANTHESIDECASEOFSAWDUST
o#HECKTHATTHESAWCHAINISSHARP
o#HECKTHATTHEBARNUTSARESUFüCIENTLYTIGHTENED
o-AKESURETHATTHECHAINTRANSPORTGUARDISUNDAMAGEDANDTHAT
ITCANBESECURELYüTTED
o#HECKTHATNUTSANDSCREWSARESUFüCIENTLYTIGHTENED
 %SPECIALLYINSPECTTHEBOLTOFMUFČERANDENSURETHATTHEYARE
 PROPERLYTIGHTENEDBEFORESTARTINGENGINE3HOULDANYOFTHE
 BOLTSBELOOSERETIGHTENTHEMIMMEDIATELY&AILURETODOSO
 COULDRESULTINSERIOUSHAZARD
o#HECKTHETIPOFTHEBAR0LEASEEXCHANGEITFORTHENEWONE
 WHENITISWORNOUT
o#HECKTHEBANDOFCHAINBRAKE0LEASEEXCHANGEITFORTHENEW
 ONEWHENITISWORNOUT
7EEKLYMAINTENANCE
o#HECKTHESTARTERESPECIALLYCORD
o#LEANTHEEXTERIOROFTHESPARKPLUG
o2EMOVETHESPARKPLUGANDCHECKTHEELECTRODEGAP!DJUSTIT
 TOMMORCHANGETHESPARKPLUG
o#HECKTHATTHEAIRINTAKEATTHESTARTERISNOTCLOGGED
o#LEANTHEAIRüLTER
-ONTHLYMAINTENANCE
o2INSETHEFUELTANKWITHGASOLINEANDCLEANFUELüLTER
o#LEANCHAINOILüLTER
o#LEANTHEEXTERIOROFTHECARBURETORANDTHESPACEAROUNDIT
1UARTERLYMAINTENANCE
o#LEANTHECOOLINGüNSONTHECYLINDER
o#LEANTHEFANANDTHESPACEAROUNDIT
o#LEANTHEMUFČEROFCARBON
#!54)/.
#LEANINGOFCYLINDERüNSFANANDMUFČERSHALLBEDONEBYA
()4!#()!UTHORIZED3ERVICE#ENTERS