User Manual
Table Of Contents
- Front_page_ErP2013
- TC_Clause
- 00_CONTENTS_ErP_2013
- 01_SYSTEM_DESCRIPTION_ErP2013(190313-draft_10C1a)
- 02_GENERAL_DATA_ErP2013(draft2D)
- 03_DIMENSIONAL_DATA_ErP2013(done)
- -DIMENSIONAL DATA
- MONOZONE / MULTIZONE Indoor Units
- MONOZONE / MULTIZONE Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA/18PSAN/25PSAN/35PSAN
- WALL TYPE: RAC-18WSA/25WSA/35WSA/18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA
- WALL TYPE: RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA/35PXA/50PXA
- WALL TYPE: RAC-25WXA/35WXA
- WALL TYPE: RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA/35PPA
- WALL TYPE: RAC-18WPA/25WPA
- WALL TYPE: RAC-35WPA
- WALL TYPE: RAK-50PPA
- WALL TYPE: RAC-50WPA
- WALL TYPE : RAK-60PPA
- WALL TYPE: RAC-60WPA
- WALL TYPE: RAK-70PPA
- WALL TYPE: RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA/35PEA/50PEA
- WALL TYPE: RAC-18WEA/25WEA
- WALL TYPE: RAC-35WEA
- WALL TYPE: RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA/50PXA
- FLOOR TYPE: RAC-25FXA/35FXA
- FLOOR TYPE: RAC-50FXA
- FLOOR TYPE: RAF-25RPA/35RPA/50RPA
- FLOOR TYPE: RAC-25FPA/35FPA
- FLOOR TYPE: RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA/70PPA
- DUCT TYPE: RAC-50DPA/60DPA/70DPA
- -DIMENSIONAL DATA
- 04_CAPACITIES_AND_SELECTION-ErP2013(DRAFT04)_3
- 05_WORKING_RANGE_ErP2013(23042012-done)
- 06_ELECTRICAL_DATA_ErP2013(Done)
- 07_A_ELECTRICAL_WIRING_DIAG-ErP2013(draft-03)
- ELECTRICAL WIRING DIAGRAM
- MONOZONE/MULTIZONE
- RAK-18QXA, RAK-25QXA, RAK-35QXA, RAK-50QXA
- RAK-18QPA, RAK-25QPA, RAK-35QPA, RAK-50QPA
- RAF-25QXA, RAF-35QXA, RAF-50QXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAI-25RPA, RAI-35RPA, RAI-50RPA
- RAD-18RPA, RAD-25RPA, RAD-35RPA, RAD-50RPA
- RAC-25NPA, RAC-35NPA, RAC-50NPA
- RAM-36NP2A
- RAM-53NP2A
- RAM-53NP3A
- RAM-68NP3A
- RAM-70NP4A
- RAM-90NP5A
- RAM-130NP6A (OUTDOOR 1)
- RAM-130NP6A (OUTDOOR 2)
- MONO - SPLIT
- RAK-18PSA, RAK-25PSA, RAK-35PSA
- RAK-18PSAN, RAK-25PSAN, RAK-35PSAN
- RAC-18WSA, RAC-25WSA, RAC-35WSA, RAC-18WSAN, RAC-25WSAN, RAC-35WSAN
- RAK-18PSPA, RAK-25PSPA, RAK-35PSPA
- RAC-18WSPA, RAC-25WSPA, RAC-35WSPA
- RAK-25PXA, RAK-35PXA, RAK-50PXA
- RAC-25WXA, RAC-35WXA
- RAC-50WXA
- RAK-18PPA, RAK-25PPA, RAK-35PPA
- RAC-18WPA, RAC-25WPA
- RAC-35WPA
- RAK-50PPA
- RAC-50WPA
- RAK-60PPA
- RAC-60WPA
- RAK-70PPA
- RAC-70WPA
- RAK-18PEA, RAK-25PEA, RAK-35PEA, RAK-50PEA
- RAC-18WEA, RAC-25WEA
- RAC-35WEA
- RAC-50WEA
- RAF-25PXA, RAF-35PXA, RAF-50PXA
- RAC-25FXA, RAC-35FXA
- RAC-50FXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAC-25FPA, RAC-35FPA
- RAC-50FPA
- RAD-50PPA, RAD-60PPA, RAD-70PPA
- RAC-50DPA, RAC-60DPA, RAC-70DPA
- MONOZONE/MULTIZONE
- ELECTRICAL WIRING DIAGRAM
- 08_REFRIGERANT_CYCLE_ErP2013(done)
- REFRIGERANT CYCLE
- Monozone/Multizone Indoor Units
- Monozone/Multizone Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA / RAC-18WSA/25WSA/35WSA
- WALL TYPE: RAK-18PSAN/25PSAN/35PSAN / RAC-18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA / RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA / RAC-25WXA
- WALL TYPE: RAK-35PXA / RAC-35WXA
- WALL TYPE: RAK-50PXA / RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA / RAC-18WPA/25WPA
- WALL TYPE: RAK-35PPA / RAC-35WPA
- WALL TYPE: RAK-50PPA / RAC-50WPA
- WALL TYPE: RAK-60PPA / RAC-60WPA
- WALL TYPE: RAK-70PPA / RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA / RAC-18WEA/25WEA
- WALL TYPE: RAK-35PEA / RAC-35WEA
- WALL TYPE: RAK-50PEA / RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA / RAC-25FXA/35FXA
- FLOOR TYPE: RAF-50PXA / RAC-50FXA
- FLOOR TYPE: RAF-25RPA / RAC-25FPA
- FLOOR TYPE: RAF-35RPA / RAC-35FPA
- FLOOR TYPE: RAF-50RPA / RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA / RAC-50DPA/60DPA
- DUCT TYPE: RAD-70PPA / RAC-70DPA
- REFRIGERANT CYCLE
- 09_REMOTE_CONTROLLERS_OPERA-ErP2013(draft-03D)
- 10_UNITS_INSTALLATION-ErP2013(draft04A)
- UNITS INSTALLATION
- 10.1 INSTALLATION OF INDOOR UNIT
- INSTALLATION OF OUTDOOR UNIT
- FINAL STAGE OF INSTALLATION
- UNITS INSTALLATION
- 11_REFRIGERANT_PIPING_ErP2013(done)
- 12_DRAIN_PIPING_ErP2013(done)
- 13_ELECTRICAL_WIRING-ErP2013(draft01)
- ELECTRICAL WIRING
- General Check
- Electrical wiring for MONOZONE/MULTIZONE Unit
- Procedures of Wiring
- Electrical Wiring for Outdoor unit
- Electrical Wiring for Wall Type Indoor unit
- Electrical Wiring for Floor Type Indoor unit
- Electrical Wiring for 4 Way Ceiling Cassette Type Indoor unit (RAI-25RPA/RAI-35RPA/RAI-50RPA)
- Electrical Wiring for Duct Type Indoor unit (RAD-18RPA/RAD-25RPA/RAD-35RPA/RAD-50RPA/RAD-50PPA/RAD-60PPA/RAD-70PPA)
- Electrical wiring for SINGLE INVERTER Unit
- ELECTRICAL WIRING
- 14_TROUBLESHOOTING_ErP2013(done)
- TROUBLESHOOTING
- PRECAUTIONS FOR TROUBLE SHOOTING
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE RAM-36NP2A
- MULTIZONE/MONO SPLIT RAM-53NP2A / 53NP3A / 68NP3A / 70NP4A , MONO SPLIT RAF-50PXA/RAC-50FXA
- MULTIZONE RAM-90NP5A
- MULTIZONE RAM-130NP6A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA , RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA , RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35RPA / RAC-25/35FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-50RPA / RAC-50FPA
- MONO SPLIT RAF-25/35PXA / RAC-25/35FXA
- MONO SPLIT RAD-50/60/70PPA / RAC-50/60/70DPA
- DISCHARGE PROCEDURE AND POWER SHUT OFF METHOD FOR POWER CIRCUIT
- MONOZONE RAC-25NPA / 35NPA / 50NPA & MULTIZONE RAM-36NP2A / 53NP2A / 53NP3A / 68NP3A / 70NP4A / 130NP6A & MONO SPLIT RAF-50PXA / RAC-50FXA, RAD-50/60/70PPA / RAC-50/60/70DPA
- MULTIZONE RAM-90NP5A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA, RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA, RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35PXA / RAC-25/35FXA RAF-50RPA / RAC-50FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-25/35RPA / RAC-25/35FPA
- PRELIMINARY CHECK ON INDOOR/OUTDOOR UNIT ELECTRICAL PARTS AND REFRIGERATING
- CHECKING THE INDOOR UNIT ELECTRICAL PARTS
- No power is detected (no operation)
- Indoor fan does not operate (others are normal) – RAK-25/35/50PXA, RAK-18/25/35/50/70PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35/50PXA, RAD-50/60/70PPA
- Air deflector does not move (others are normal)
- Check the control P.W.B. (power circuit) – RAK-25/35PXA, RAK-18/25/35PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35PXA
- Checking the remote controller
- Outdoor unit does not operate (but receives remote infrared signal)
- All systems stop from several seconds to several minutes after operation is started (all indicators are also off)
- CHECKING OUTDOOR UNIT ELECTRICAL PARTS
- CHECKING BETWEEN GAS LEAKAGE AND COMPRESSOR FAULTY
- TROUBLESHOOTING WHEN INDOOR TIMER LAMP BLINKS
- TROUBLESHOOTING WHEN OUTDOOR LED LAMP BLINKS
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM- 53NP3A / 68NP3A / 70NP4A / 130NP6A
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM-90NP5A
- MONO SPLIT(RAC-18/25/35WPA, RAC-25/35WXA, RAC-25/35FXA)
- MONO SPLIT (RAC-50WXA, RAC-50FXA
- MONO SPLIT (RAC-50/60/70WPA, RAC-50/60/70DPA)
- CHECKING POWER MODULE
- THERMISTOR
- PRECAUTIONS FOR TROUBLE SHOOTING
- TROUBLESHOOTING
- 15_MISC_Notes_split_ErP2013(done)
- MISCELLANEOUS NOTE
- INSTALLATION AT COLD REGIONS OR SNOWFALL REGIONS.
- INSTALLATION POINTS ON OUTDOOR UNITS IN COLD OR SNOWFALL REGIONS.
- Installation place of Cold and Snowfall Regions
- Considerations to the Seasonal Winds and Snowfall
- Considerations to Snowfall / Snow Buildup
- Considerations to Sliding Snow from Roof or SNOWFALL
- As to Proper Drainage of Defrosting WATER
- Request to cut Net attached to Rear side of Outdoor Unit
- Installation of HOT PIPE
- H-LINK ADAPTOR
- MISCELLANEOUS NOTE
- Back_page(new)
CAPACITIES AND SELECTION DATA
4-19
INDOOR
OUTDOOR TEMPERATURE (°CDB)
EWB
EDB
-10
21
27
32
35
40
43
°C
°C
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
1.8+3.5
12.0
18
2677
1988
565
4346
3799
962
4023
3507
1134
4100
3595
1354
3950
3437
1413
3700
3239
1516
3550
3081
1575
14.0
20
2677
1988
565
4670
3799
962
4346
3543
1147
4400
3595
1369
4250
3476
1428
3950
3239
1531
3800
3121
1604
16.0
22
2677
2115
574
4994
3799
975
4624
3543
1161
4700
3595
1384
4550
3476
1457
4250
3239
1560
4100
3121
1619
18.0
25
2871
2268
583
5317
4128
987
4901
3835
1174
5000
3911
1398
4800
3753
1457
4500
3516
1575
4300
3358
1634
19.0
27
2968
2345
592
5502
4347
1000
5086
4018
1187
5200
4108
1413
5000
3950
1472
4700
3713
1575
4500
3555
1634
22.0
30
3290
2319
592
6103
4310
1000
5641
3981
1187
5750
4069
1428
5550
3911
1487
5000
3792
1634
4650
3713
1722
24.0
32
3516
2319
601
6519
4310
1013
6011
3981
1201
6150
4069
1428
5900
3911
1501
5200
3871
1678
4750
3832
1781
1.8+5.8
12.0
18
2785
1910
576
4520
3651
980
4183
3370
1155
4264
3454
1380
4108
3303
1440
3848
3113
1545
3692
2961
1605
14.0
20
2785
1910
576
4857
3651
980
4520
3405
1169
4576
3454
1395
4420
3340
1455
4108
3113
1560
3952
2999
1635
16.0
22
2785
2033
585
5193
3651
993
4809
3405
1183
4888
3454
1410
4732
3340
1485
4420
3113
1590
4264
2999
1650
18.0
25
2986
2180
594
5530
3967
1006
5097
3686
1196
5200
3758
1425
4992
3606
1485
4680
3378
1605
4472
3227
1665
19.0
27
3086
2253
603
5722
4177
1019
5289
3861
1210
5408
3948
1440
5200
3796
1500
4888
3568
1605
4680
3416
1665
22.0
30
3422
2229
603
6347
4142
1019
5866
3826
1210
5980
3910
1455
5772
3758
1515
5200
3644
1665
4836
3568
1755
24.0
32
3657
2229
612
6780
4142
1032
6251
3826
1223
6396
3910
1455
6136
3758
1530
5408
3720
1710
4940
3682
1815
2.5+2.5
12.0
18
2677
1837
565
4346
3510
962
4023
3240
1134
4100
3322
1354
3950
3176
1413
3700
2993
1516
3550
2847
1575
14.0
20
2677
1837
565
4670
3510
962
4346
3274
1147
4400
3322
1369
4250
3212
1428
3950
2993
1531
3800
2884
1604
16.0
22
2677
1955
574
4994
3510
975
4624
3274
1161
4700
3322
1384
4550
3212
1457
4250
2993
1560
4100
2884
1619
18.0
25
2871
2096
583
5317
3814
987
4901
3544
1174
5000
3614
1398
4800
3468
1457
4500
3249
1575
4300
3103
1634
19.0
27
2968
2166
592
5502
4017
1000
5086
3713
1187
5200
3796
1413
5000
3650
1472
4700
3431
1575
4500
3285
1634
22.0
30
3290
2143
592
6103
3983
1000
5641
3679
1187
5750
3760
1428
5550
3614
1487
5000
3504
1634
4650
3431
1722
24.0
32
3516
2143
601
6519
3983
1013
6011
3679
1201
6150
3760
1428
5900
3614
1501
5200
3577
1678
4750
3541
1781
2.5+3.5
12.0
18
2785
1988
576
4520
3799
980
4183
3507
1155
4264
3595
1380
4108
3437
1440
3848
3239
1545
3692
3081
1605
14.0
20
2785
1988
576
4857
3799
980
4520
3543
1169
4576
3595
1395
4420
3476
1455
4108
3239
1560
3952
3121
1635
16.0
22
2785
2115
585
5193
3799
993
4809
3543
1183
4888
3595
1410
4732
3476
1485
4420
3239
1590
4264
3121
1650
18.0
25
2986
2268
594
5530
4128
1006
5097
3835
1196
5200
3911
1425
4992
3753
1485
4680
3516
1605
4472
3358
1665
19.0
27
3086
2345
603
5722
4347
1019
5289
4018
1210
5408
4108
1440
5200
3950
1500
4888
3713
1605
4680
3555
1665
22.0
30
3422
2319
603
6347
4310
1019
5866
3981
1210
5980
4069
1455
5772
3911
1515
5200
3792
1665
4836
3713
1755
24.0
32
3657
2319
612
6780
4310
1032
6251
3981
1223
6396
4069
1455
6136
3911
1530
5408
3871
1710
4940
3832
1815
3.5+3.5
12.0
18
2785
1988
576
4520
3799
980
4183
3507
1155
4264
3595
1380
4108
3437
1440
3848
3239
1545
3692
3081
1605
14.0
20
2785
1988
576
4857
3799
980
4520
3543
1169
4576
3595
1395
4420
3476
1455
4108
3239
1560
3952
3121
1635
16.0
22
2785
2115
585
5193
3799
993
4809
3543
1183
4888
3595
1410
4732
3476
1485
4420
3239
1590
4264
3121
1650
18.0
25
2986
2268
594
5530
4128
1006
5097
3835
1196
5200
3911
1425
4992
3753
1485
4680
3516
1605
4472
3358
1665
19.0
27
3086
2345
603
5722
4347
1019
5289
4018
1210
5408
4108
1440
5200
3950
1500
4888
3713
1605
4680
3555
1665
22.0
30
3422
2319
603
6347
4310
1019
5866
3981
1210
5980
4069
1455
5772
3911
1515
5200
3792
1665
4836
3713
1755
24.0
32
3657
2319
612
6780
4310
1032
6251
3981
1223
6396
4069
1455
6136
3911
1530
5408
3871
1710
4940
3832
1815
2.5+5.0
12.0
18
2785
1988
576
4520
3799
980
4183
3507
1155
4264
3595
1380
4108
3437
1440
3848
3239
1545
3692
3081
1605
14.0
20
2785
1988
576
4857
3799
980
4520
3543
1169
4576
3595
1395
4420
3476
1455
4108
3239
1560
3952
3121
1635
16.0
22
2785
2115
585
5193
3799
993
4809
3543
1183
4888
3595
1410
4732
3476
1485
4420
3239
1590
4264
3121
1650
18.0
25
2986
2268
594
5530
4128
1006
5097
3835
1196
5200
3911
1425
4992
3753
1485
4680
3516
1605
4472
3358
1665
19.0
27
3086
2345
603
5722
4347
1019
5289
4018
1210
5408
4108
1440
5200
3950
1500
4888
3713
1605
4680
3555
1665
22.0
30
3422
2319
603
6347
4310
1019
5866
3981
1210
5980
4069
1455
5772
3911
1515
5200
3792
1665
4836
3713
1755
24.0
32
3657
2319
612
6780
4310
1032
6251
3981
1223
6396
4069
1455
6136
3911
1530
5408
3871
1710
4940
3832
1815