User Manual
Table Of Contents
- Front_page_ErP2013
- TC_Clause
- 00_CONTENTS_ErP_2013
- 01_SYSTEM_DESCRIPTION_ErP2013(190313-draft_10C1a)
- 02_GENERAL_DATA_ErP2013(draft2D)
- 03_DIMENSIONAL_DATA_ErP2013(done)
- -DIMENSIONAL DATA
- MONOZONE / MULTIZONE Indoor Units
- MONOZONE / MULTIZONE Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA/18PSAN/25PSAN/35PSAN
- WALL TYPE: RAC-18WSA/25WSA/35WSA/18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA
- WALL TYPE: RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA/35PXA/50PXA
- WALL TYPE: RAC-25WXA/35WXA
- WALL TYPE: RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA/35PPA
- WALL TYPE: RAC-18WPA/25WPA
- WALL TYPE: RAC-35WPA
- WALL TYPE: RAK-50PPA
- WALL TYPE: RAC-50WPA
- WALL TYPE : RAK-60PPA
- WALL TYPE: RAC-60WPA
- WALL TYPE: RAK-70PPA
- WALL TYPE: RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA/35PEA/50PEA
- WALL TYPE: RAC-18WEA/25WEA
- WALL TYPE: RAC-35WEA
- WALL TYPE: RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA/50PXA
- FLOOR TYPE: RAC-25FXA/35FXA
- FLOOR TYPE: RAC-50FXA
- FLOOR TYPE: RAF-25RPA/35RPA/50RPA
- FLOOR TYPE: RAC-25FPA/35FPA
- FLOOR TYPE: RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA/70PPA
- DUCT TYPE: RAC-50DPA/60DPA/70DPA
- -DIMENSIONAL DATA
- 04_CAPACITIES_AND_SELECTION-ErP2013(DRAFT04)_3
- 05_WORKING_RANGE_ErP2013(23042012-done)
- 06_ELECTRICAL_DATA_ErP2013(Done)
- 07_A_ELECTRICAL_WIRING_DIAG-ErP2013(draft-03)
- ELECTRICAL WIRING DIAGRAM
- MONOZONE/MULTIZONE
- RAK-18QXA, RAK-25QXA, RAK-35QXA, RAK-50QXA
- RAK-18QPA, RAK-25QPA, RAK-35QPA, RAK-50QPA
- RAF-25QXA, RAF-35QXA, RAF-50QXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAI-25RPA, RAI-35RPA, RAI-50RPA
- RAD-18RPA, RAD-25RPA, RAD-35RPA, RAD-50RPA
- RAC-25NPA, RAC-35NPA, RAC-50NPA
- RAM-36NP2A
- RAM-53NP2A
- RAM-53NP3A
- RAM-68NP3A
- RAM-70NP4A
- RAM-90NP5A
- RAM-130NP6A (OUTDOOR 1)
- RAM-130NP6A (OUTDOOR 2)
- MONO - SPLIT
- RAK-18PSA, RAK-25PSA, RAK-35PSA
- RAK-18PSAN, RAK-25PSAN, RAK-35PSAN
- RAC-18WSA, RAC-25WSA, RAC-35WSA, RAC-18WSAN, RAC-25WSAN, RAC-35WSAN
- RAK-18PSPA, RAK-25PSPA, RAK-35PSPA
- RAC-18WSPA, RAC-25WSPA, RAC-35WSPA
- RAK-25PXA, RAK-35PXA, RAK-50PXA
- RAC-25WXA, RAC-35WXA
- RAC-50WXA
- RAK-18PPA, RAK-25PPA, RAK-35PPA
- RAC-18WPA, RAC-25WPA
- RAC-35WPA
- RAK-50PPA
- RAC-50WPA
- RAK-60PPA
- RAC-60WPA
- RAK-70PPA
- RAC-70WPA
- RAK-18PEA, RAK-25PEA, RAK-35PEA, RAK-50PEA
- RAC-18WEA, RAC-25WEA
- RAC-35WEA
- RAC-50WEA
- RAF-25PXA, RAF-35PXA, RAF-50PXA
- RAC-25FXA, RAC-35FXA
- RAC-50FXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAC-25FPA, RAC-35FPA
- RAC-50FPA
- RAD-50PPA, RAD-60PPA, RAD-70PPA
- RAC-50DPA, RAC-60DPA, RAC-70DPA
- MONOZONE/MULTIZONE
- ELECTRICAL WIRING DIAGRAM
- 08_REFRIGERANT_CYCLE_ErP2013(done)
- REFRIGERANT CYCLE
- Monozone/Multizone Indoor Units
- Monozone/Multizone Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA / RAC-18WSA/25WSA/35WSA
- WALL TYPE: RAK-18PSAN/25PSAN/35PSAN / RAC-18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA / RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA / RAC-25WXA
- WALL TYPE: RAK-35PXA / RAC-35WXA
- WALL TYPE: RAK-50PXA / RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA / RAC-18WPA/25WPA
- WALL TYPE: RAK-35PPA / RAC-35WPA
- WALL TYPE: RAK-50PPA / RAC-50WPA
- WALL TYPE: RAK-60PPA / RAC-60WPA
- WALL TYPE: RAK-70PPA / RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA / RAC-18WEA/25WEA
- WALL TYPE: RAK-35PEA / RAC-35WEA
- WALL TYPE: RAK-50PEA / RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA / RAC-25FXA/35FXA
- FLOOR TYPE: RAF-50PXA / RAC-50FXA
- FLOOR TYPE: RAF-25RPA / RAC-25FPA
- FLOOR TYPE: RAF-35RPA / RAC-35FPA
- FLOOR TYPE: RAF-50RPA / RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA / RAC-50DPA/60DPA
- DUCT TYPE: RAD-70PPA / RAC-70DPA
- REFRIGERANT CYCLE
- 09_REMOTE_CONTROLLERS_OPERA-ErP2013(draft-03D)
- 10_UNITS_INSTALLATION-ErP2013(draft04A)
- UNITS INSTALLATION
- 10.1 INSTALLATION OF INDOOR UNIT
- INSTALLATION OF OUTDOOR UNIT
- FINAL STAGE OF INSTALLATION
- UNITS INSTALLATION
- 11_REFRIGERANT_PIPING_ErP2013(done)
- 12_DRAIN_PIPING_ErP2013(done)
- 13_ELECTRICAL_WIRING-ErP2013(draft01)
- ELECTRICAL WIRING
- General Check
- Electrical wiring for MONOZONE/MULTIZONE Unit
- Procedures of Wiring
- Electrical Wiring for Outdoor unit
- Electrical Wiring for Wall Type Indoor unit
- Electrical Wiring for Floor Type Indoor unit
- Electrical Wiring for 4 Way Ceiling Cassette Type Indoor unit (RAI-25RPA/RAI-35RPA/RAI-50RPA)
- Electrical Wiring for Duct Type Indoor unit (RAD-18RPA/RAD-25RPA/RAD-35RPA/RAD-50RPA/RAD-50PPA/RAD-60PPA/RAD-70PPA)
- Electrical wiring for SINGLE INVERTER Unit
- ELECTRICAL WIRING
- 14_TROUBLESHOOTING_ErP2013(done)
- TROUBLESHOOTING
- PRECAUTIONS FOR TROUBLE SHOOTING
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE RAM-36NP2A
- MULTIZONE/MONO SPLIT RAM-53NP2A / 53NP3A / 68NP3A / 70NP4A , MONO SPLIT RAF-50PXA/RAC-50FXA
- MULTIZONE RAM-90NP5A
- MULTIZONE RAM-130NP6A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA , RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA , RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35RPA / RAC-25/35FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-50RPA / RAC-50FPA
- MONO SPLIT RAF-25/35PXA / RAC-25/35FXA
- MONO SPLIT RAD-50/60/70PPA / RAC-50/60/70DPA
- DISCHARGE PROCEDURE AND POWER SHUT OFF METHOD FOR POWER CIRCUIT
- MONOZONE RAC-25NPA / 35NPA / 50NPA & MULTIZONE RAM-36NP2A / 53NP2A / 53NP3A / 68NP3A / 70NP4A / 130NP6A & MONO SPLIT RAF-50PXA / RAC-50FXA, RAD-50/60/70PPA / RAC-50/60/70DPA
- MULTIZONE RAM-90NP5A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA, RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA, RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35PXA / RAC-25/35FXA RAF-50RPA / RAC-50FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-25/35RPA / RAC-25/35FPA
- PRELIMINARY CHECK ON INDOOR/OUTDOOR UNIT ELECTRICAL PARTS AND REFRIGERATING
- CHECKING THE INDOOR UNIT ELECTRICAL PARTS
- No power is detected (no operation)
- Indoor fan does not operate (others are normal) – RAK-25/35/50PXA, RAK-18/25/35/50/70PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35/50PXA, RAD-50/60/70PPA
- Air deflector does not move (others are normal)
- Check the control P.W.B. (power circuit) – RAK-25/35PXA, RAK-18/25/35PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35PXA
- Checking the remote controller
- Outdoor unit does not operate (but receives remote infrared signal)
- All systems stop from several seconds to several minutes after operation is started (all indicators are also off)
- CHECKING OUTDOOR UNIT ELECTRICAL PARTS
- CHECKING BETWEEN GAS LEAKAGE AND COMPRESSOR FAULTY
- TROUBLESHOOTING WHEN INDOOR TIMER LAMP BLINKS
- TROUBLESHOOTING WHEN OUTDOOR LED LAMP BLINKS
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM- 53NP3A / 68NP3A / 70NP4A / 130NP6A
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM-90NP5A
- MONO SPLIT(RAC-18/25/35WPA, RAC-25/35WXA, RAC-25/35FXA)
- MONO SPLIT (RAC-50WXA, RAC-50FXA
- MONO SPLIT (RAC-50/60/70WPA, RAC-50/60/70DPA)
- CHECKING POWER MODULE
- THERMISTOR
- PRECAUTIONS FOR TROUBLE SHOOTING
- TROUBLESHOOTING
- 15_MISC_Notes_split_ErP2013(done)
- MISCELLANEOUS NOTE
- INSTALLATION AT COLD REGIONS OR SNOWFALL REGIONS.
- INSTALLATION POINTS ON OUTDOOR UNITS IN COLD OR SNOWFALL REGIONS.
- Installation place of Cold and Snowfall Regions
- Considerations to the Seasonal Winds and Snowfall
- Considerations to Snowfall / Snow Buildup
- Considerations to Sliding Snow from Roof or SNOWFALL
- As to Proper Drainage of Defrosting WATER
- Request to cut Net attached to Rear side of Outdoor Unit
- Installation of HOT PIPE
- H-LINK ADAPTOR
- MISCELLANEOUS NOTE
- Back_page(new)
CAPACITIES AND SELECTION DATA
4-31
INDOOR
OUTDOOR TEMPERATURE (°CDB)
EWB
EDB
-10
21
27
32
35
40
43
°C
°C
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
1.8+2.5
12.0
18
4676
3208
1046
3370
2722
790
3119
2513
932
3444
2790
1205
3318
2667
1258
3108
2514
1349
2982
2391
1402
14.0
20
4676
3208
1046
3621
2722
790
3370
2539
942
3696
2790
1218
3570
2698
1271
3318
2514
1362
3192
2422
1428
16.0
22
4676
3414
1062
3872
2722
801
3585
2539
953
3948
2790
1231
3822
2698
1297
3570
2514
1389
3444
2422
1441
18.0
25
5014
3661
1079
4123
2958
811
3800
2748
964
4200
3035
1245
4032
2913
1297
3780
2729
1402
3612
2606
1454
19.0
27
5183
3784
1095
4267
3115
822
3944
2879
975
4368
3189
1258
4200
3066
1310
3948
2882
1402
3780
2759
1454
22.0
30
5747
3743
1095
4733
3088
822
4374
2853
975
4830
3158
1271
4662
3035
1323
4200
2943
1454
3906
2882
1533
24.0
32
6141
3743
1111
5055
3088
832
4661
2853
986
5166
3158
1271
4956
3035
1336
4368
3005
1493
3990
2974
1585
1.8+3.5
12.0
18
5567
3819
1317
4012
3240
996
3713
2991
1173
4100
3322
1518
3950
3176
1584
3700
2993
1700
3550
2847
1766
14.0
20
5567
3819
1317
4311
3240
996
4012
3022
1187
4400
3322
1535
4250
3212
1601
3950
2993
1716
3800
2884
1799
16.0
22
5567
4064
1338
4610
3240
1009
4268
3022
1201
4700
3322
1551
4550
3212
1634
4250
2993
1749
4100
2884
1815
18.0
25
5970
4358
1359
4909
3521
1022
4524
3272
1215
5000
3614
1568
4800
3468
1634
4500
3249
1766
4300
3103
1832
19.0
27
6171
4505
1379
5079
3708
1035
4695
3427
1229
5200
3796
1584
5000
3650
1650
4700
3431
1766
4500
3285
1832
22.0
30
6841
4456
1379
5634
3677
1035
5207
3396
1229
5750
3760
1601
5550
3614
1667
5000
3504
1832
4650
3431
1931
24.0
32
7311
4456
1400
6018
3677
1048
5549
3396
1242
6150
3760
1601
5900
3614
1683
5200
3577
1881
4750
3541
1997
1.8+5.0
12.0
18
6012
4125
1433
4333
3500
1083
4010
3231
1276
4428
3587
1651
4266
3430
1723
3996
3232
1849
3834
3075
1921
14.0
20
6012
4125
1433
4656
3500
1083
4333
3264
1291
4752
3587
1669
4590
3469
1741
4266
3232
1867
4104
3114
1957
16.0
22
6012
4389
1456
4979
3500
1097
4610
3264
1306
5076
3587
1687
4914
3469
1777
4590
3232
1903
4428
3114
1975
18.0
25
6447
4706
1478
5301
3803
1112
4886
3533
1321
5400
3903
1705
5184
3745
1777
4860
3508
1921
4644
3351
1992
19.0
27
6664
4865
1500
5486
4004
1126
5071
3702
1336
5616
4100
1723
5400
3942
1795
5076
3705
1921
4860
3548
1992
22.0
30
7389
4812
1500
6085
3971
1126
5624
3668
1336
6210
4060
1741
5994
3903
1813
5400
3784
1992
5022
3705
2100
24.0
32
7896
4812
1523
6500
3971
1140
5993
3668
1352
6642
4060
1741
6372
3903
1831
5616
3863
2046
5130
3824
2172
2.5+2.5
12.0
18
5567
3819
1317
4012
3240
996
3713
2991
1173
4100
3322
1518
3950
3176
1584
3700
2993
1700
3550
2847
1766
14.0
20
5567
3819
1317
4311
3240
996
4012
3022
1187
4400
3322
1535
4250
3212
1601
3950
2993
1716
3800
2884
1799
16.0
22
5567
4064
1338
4610
3240
1009
4268
3022
1201
4700
3322
1551
4550
3212
1634
4250
2993
1749
4100
2884
1815
18.0
25
5970
4358
1359
4909
3521
1022
4524
3272
1215
5000
3614
1568
4800
3468
1634
4500
3249
1766
4300
3103
1832
19.0
27
6171
4505
1379
5079
3708
1035
4695
3427
1229
5200
3796
1584
5000
3650
1650
4700
3431
1766
4500
3285
1832
22.0
30
6841
4456
1379
5634
3677
1035
5207
3396
1229
5750
3760
1601
5550
3614
1667
5000
3504
1832
4650
3431
1931
24.0
32
7311
4456
1400
6018
3677
1048
5549
3396
1242
6150
3760
1601
5900
3614
1683
5200
3577
1881
4750
3541
1997
2.5+3.5
12.0
18
5790
3972
1381
4173
3370
1044
3862
3111
1230
4264
3454
1592
4108
3303
1661
3848
3113
1782
3692
2961
1851
14.0
20
5790
3972
1381
4483
3370
1044
4173
3143
1245
4576
3454
1609
4420
3340
1678
4108
3113
1799
3952
2999
1886
16.0
22
5790
4227
1403
4794
3370
1058
4439
3143
1259
4888
3454
1626
4732
3340
1713
4420
3113
1834
4264
2999
1903
18.0
25
6208
4532
1424
5105
3662
1071
4705
3403
1274
5200
3758
1644
4992
3606
1713
4680
3378
1851
4472
3227
1920
19.0
27
6418
4685
1446
5282
3856
1085
4883
3565
1288
5408
3948
1661
5200
3796
1730
4888
3568
1851
4680
3416
1920
22.0
30
7115
4634
1446
5860
3824
1085
5416
3532
1288
5980
3910
1678
5772
3758
1747
5200
3644
1920
4836
3568
2024
24.0
32
7603
4634
1468
6259
3824
1099
5771
3532
1303
6396
3910
1678
6136
3758
1765
5408
3720
1972
4940
3682
2093
3.5+3.5
12.0
18
6012
4125
1433
4333
3500
1083
4010
3231
1276
4428
3587
1651
4266
3430
1723
3996
3232
1849
3834
3075
1921
14.0
20
6012
4125
1433
4656
3500
1083
4333
3264
1291
4752
3587
1669
4590
3469
1741
4266
3232
1867
4104
3114
1957
16.0
22
6012
4389
1456
4979
3500
1097
4610
3264
1306
5076
3587
1687
4914
3469
1777
4590
3232
1903
4428
3114
1975
18.0
25
6447
4706
1478
5301
3803
1112
4886
3533
1321
5400
3903
1705
5184
3745
1777
4860
3508
1921
4644
3351
1992
19.0
27
6664
4865
1500
5486
4004
1126
5071
3702
1336
5616
4100
1723
5400
3942
1795
5076
3705
1921
4860
3548
1992
22.0
30
7389
4812
1500
6085
3971
1126
5624
3668
1336
6210
4060
1741
5994
3903
1813
5400
3784
1992
5022
3705
2100
24.0
32
7896
4812
1523
6500
3971
1140
5993
3668
1352
6642
4060
1741
6372
3903
1831
5616
3863
2046
5130
3824
2172