User Manual
Table Of Contents
- Front_page_ErP2013
- TC_Clause
- 00_CONTENTS_ErP_2013
- 01_SYSTEM_DESCRIPTION_ErP2013(190313-draft_10C1a)
- 02_GENERAL_DATA_ErP2013(draft2D)
- 03_DIMENSIONAL_DATA_ErP2013(done)
- -DIMENSIONAL DATA
- MONOZONE / MULTIZONE Indoor Units
- MONOZONE / MULTIZONE Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA/18PSAN/25PSAN/35PSAN
- WALL TYPE: RAC-18WSA/25WSA/35WSA/18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA
- WALL TYPE: RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA/35PXA/50PXA
- WALL TYPE: RAC-25WXA/35WXA
- WALL TYPE: RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA/35PPA
- WALL TYPE: RAC-18WPA/25WPA
- WALL TYPE: RAC-35WPA
- WALL TYPE: RAK-50PPA
- WALL TYPE: RAC-50WPA
- WALL TYPE : RAK-60PPA
- WALL TYPE: RAC-60WPA
- WALL TYPE: RAK-70PPA
- WALL TYPE: RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA/35PEA/50PEA
- WALL TYPE: RAC-18WEA/25WEA
- WALL TYPE: RAC-35WEA
- WALL TYPE: RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA/50PXA
- FLOOR TYPE: RAC-25FXA/35FXA
- FLOOR TYPE: RAC-50FXA
- FLOOR TYPE: RAF-25RPA/35RPA/50RPA
- FLOOR TYPE: RAC-25FPA/35FPA
- FLOOR TYPE: RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA/70PPA
- DUCT TYPE: RAC-50DPA/60DPA/70DPA
- -DIMENSIONAL DATA
- 04_CAPACITIES_AND_SELECTION-ErP2013(DRAFT04)_3
- 05_WORKING_RANGE_ErP2013(23042012-done)
- 06_ELECTRICAL_DATA_ErP2013(Done)
- 07_A_ELECTRICAL_WIRING_DIAG-ErP2013(draft-03)
- ELECTRICAL WIRING DIAGRAM
- MONOZONE/MULTIZONE
- RAK-18QXA, RAK-25QXA, RAK-35QXA, RAK-50QXA
- RAK-18QPA, RAK-25QPA, RAK-35QPA, RAK-50QPA
- RAF-25QXA, RAF-35QXA, RAF-50QXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAI-25RPA, RAI-35RPA, RAI-50RPA
- RAD-18RPA, RAD-25RPA, RAD-35RPA, RAD-50RPA
- RAC-25NPA, RAC-35NPA, RAC-50NPA
- RAM-36NP2A
- RAM-53NP2A
- RAM-53NP3A
- RAM-68NP3A
- RAM-70NP4A
- RAM-90NP5A
- RAM-130NP6A (OUTDOOR 1)
- RAM-130NP6A (OUTDOOR 2)
- MONO - SPLIT
- RAK-18PSA, RAK-25PSA, RAK-35PSA
- RAK-18PSAN, RAK-25PSAN, RAK-35PSAN
- RAC-18WSA, RAC-25WSA, RAC-35WSA, RAC-18WSAN, RAC-25WSAN, RAC-35WSAN
- RAK-18PSPA, RAK-25PSPA, RAK-35PSPA
- RAC-18WSPA, RAC-25WSPA, RAC-35WSPA
- RAK-25PXA, RAK-35PXA, RAK-50PXA
- RAC-25WXA, RAC-35WXA
- RAC-50WXA
- RAK-18PPA, RAK-25PPA, RAK-35PPA
- RAC-18WPA, RAC-25WPA
- RAC-35WPA
- RAK-50PPA
- RAC-50WPA
- RAK-60PPA
- RAC-60WPA
- RAK-70PPA
- RAC-70WPA
- RAK-18PEA, RAK-25PEA, RAK-35PEA, RAK-50PEA
- RAC-18WEA, RAC-25WEA
- RAC-35WEA
- RAC-50WEA
- RAF-25PXA, RAF-35PXA, RAF-50PXA
- RAC-25FXA, RAC-35FXA
- RAC-50FXA
- RAF-25RPA, RAF-35RPA, RAF-50RPA
- RAC-25FPA, RAC-35FPA
- RAC-50FPA
- RAD-50PPA, RAD-60PPA, RAD-70PPA
- RAC-50DPA, RAC-60DPA, RAC-70DPA
- MONOZONE/MULTIZONE
- ELECTRICAL WIRING DIAGRAM
- 08_REFRIGERANT_CYCLE_ErP2013(done)
- REFRIGERANT CYCLE
- Monozone/Multizone Indoor Units
- Monozone/Multizone Outdoor Units
- MONO SPLIT
- WALL TYPE: RAK-18PSA/25PSA/35PSA / RAC-18WSA/25WSA/35WSA
- WALL TYPE: RAK-18PSAN/25PSAN/35PSAN / RAC-18WSAN/25WSAN/35WSAN
- WALL TYPE: RAK-18PSPA/25PSPA/35PSPA / RAC-18WSPA/25WSPA/35WSPA
- WALL TYPE: RAK-25PXA / RAC-25WXA
- WALL TYPE: RAK-35PXA / RAC-35WXA
- WALL TYPE: RAK-50PXA / RAC-50WXA
- WALL TYPE: RAK-18PPA/25PPA / RAC-18WPA/25WPA
- WALL TYPE: RAK-35PPA / RAC-35WPA
- WALL TYPE: RAK-50PPA / RAC-50WPA
- WALL TYPE: RAK-60PPA / RAC-60WPA
- WALL TYPE: RAK-70PPA / RAC-70WPA
- WALL TYPE: RAK-18PEA/25PEA / RAC-18WEA/25WEA
- WALL TYPE: RAK-35PEA / RAC-35WEA
- WALL TYPE: RAK-50PEA / RAC-50WEA
- FLOOR TYPE: RAF-25PXA/35PXA / RAC-25FXA/35FXA
- FLOOR TYPE: RAF-50PXA / RAC-50FXA
- FLOOR TYPE: RAF-25RPA / RAC-25FPA
- FLOOR TYPE: RAF-35RPA / RAC-35FPA
- FLOOR TYPE: RAF-50RPA / RAC-50FPA
- DUCT TYPE: RAD-50PPA/60PPA / RAC-50DPA/60DPA
- DUCT TYPE: RAD-70PPA / RAC-70DPA
- REFRIGERANT CYCLE
- 09_REMOTE_CONTROLLERS_OPERA-ErP2013(draft-03D)
- 10_UNITS_INSTALLATION-ErP2013(draft04A)
- UNITS INSTALLATION
- 10.1 INSTALLATION OF INDOOR UNIT
- INSTALLATION OF OUTDOOR UNIT
- FINAL STAGE OF INSTALLATION
- UNITS INSTALLATION
- 11_REFRIGERANT_PIPING_ErP2013(done)
- 12_DRAIN_PIPING_ErP2013(done)
- 13_ELECTRICAL_WIRING-ErP2013(draft01)
- ELECTRICAL WIRING
- General Check
- Electrical wiring for MONOZONE/MULTIZONE Unit
- Procedures of Wiring
- Electrical Wiring for Outdoor unit
- Electrical Wiring for Wall Type Indoor unit
- Electrical Wiring for Floor Type Indoor unit
- Electrical Wiring for 4 Way Ceiling Cassette Type Indoor unit (RAI-25RPA/RAI-35RPA/RAI-50RPA)
- Electrical Wiring for Duct Type Indoor unit (RAD-18RPA/RAD-25RPA/RAD-35RPA/RAD-50RPA/RAD-50PPA/RAD-60PPA/RAD-70PPA)
- Electrical wiring for SINGLE INVERTER Unit
- ELECTRICAL WIRING
- 14_TROUBLESHOOTING_ErP2013(done)
- TROUBLESHOOTING
- PRECAUTIONS FOR TROUBLE SHOOTING
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE RAM-36NP2A
- MULTIZONE/MONO SPLIT RAM-53NP2A / 53NP3A / 68NP3A / 70NP4A , MONO SPLIT RAF-50PXA/RAC-50FXA
- MULTIZONE RAM-90NP5A
- MULTIZONE RAM-130NP6A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA , RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA , RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35RPA / RAC-25/35FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-50RPA / RAC-50FPA
- MONO SPLIT RAF-25/35PXA / RAC-25/35FXA
- MONO SPLIT RAD-50/60/70PPA / RAC-50/60/70DPA
- DISCHARGE PROCEDURE AND POWER SHUT OFF METHOD FOR POWER CIRCUIT
- MONOZONE RAC-25NPA / 35NPA / 50NPA & MULTIZONE RAM-36NP2A / 53NP2A / 53NP3A / 68NP3A / 70NP4A / 130NP6A & MONO SPLIT RAF-50PXA / RAC-50FXA, RAD-50/60/70PPA / RAC-50/60/70DPA
- MULTIZONE RAM-90NP5A
- MONO SPLIT RAK-18/25/35PSA / RAC-18/25/35WSA, RAK-18/25/35PSAN / RAC-18/25/35WSAN , RAK-18/25/35PSPA / RAC-18/25/35WSPA
- MONO SPLIT RAK-18/25/35PPA / RAC-18/25/35WPA, RAK-18/25/35/50PEA / RAC-18/25/35/50WEA , RAF-25/35PXA / RAC-25/35FXA RAF-50RPA / RAC-50FPA
- MONO SPLIT RAK-50/60/70PPA / RAC-50/60/70WPA
- MONO SPLIT RAF-25/35RPA / RAC-25/35FPA
- PRELIMINARY CHECK ON INDOOR/OUTDOOR UNIT ELECTRICAL PARTS AND REFRIGERATING
- CHECKING THE INDOOR UNIT ELECTRICAL PARTS
- No power is detected (no operation)
- Indoor fan does not operate (others are normal) – RAK-25/35/50PXA, RAK-18/25/35/50/70PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35/50PXA, RAD-50/60/70PPA
- Air deflector does not move (others are normal)
- Check the control P.W.B. (power circuit) – RAK-25/35PXA, RAK-18/25/35PPA, RAK-18/25/35/50PEA, RAF-25/35/50RPA, RAF-25/35PXA
- Checking the remote controller
- Outdoor unit does not operate (but receives remote infrared signal)
- All systems stop from several seconds to several minutes after operation is started (all indicators are also off)
- CHECKING OUTDOOR UNIT ELECTRICAL PARTS
- CHECKING BETWEEN GAS LEAKAGE AND COMPRESSOR FAULTY
- TROUBLESHOOTING WHEN INDOOR TIMER LAMP BLINKS
- TROUBLESHOOTING WHEN OUTDOOR LED LAMP BLINKS
- MONOZONE RAC-25NPA / 35NPA / 50NPA
- MULTIZONE
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM- 53NP3A / 68NP3A / 70NP4A / 130NP6A
- COMMUNICATION ERROR DIAGNOSIS MULTIZONE RAM-90NP5A
- MONO SPLIT(RAC-18/25/35WPA, RAC-25/35WXA, RAC-25/35FXA)
- MONO SPLIT (RAC-50WXA, RAC-50FXA
- MONO SPLIT (RAC-50/60/70WPA, RAC-50/60/70DPA)
- CHECKING POWER MODULE
- THERMISTOR
- PRECAUTIONS FOR TROUBLE SHOOTING
- TROUBLESHOOTING
- 15_MISC_Notes_split_ErP2013(done)
- MISCELLANEOUS NOTE
- INSTALLATION AT COLD REGIONS OR SNOWFALL REGIONS.
- INSTALLATION POINTS ON OUTDOOR UNITS IN COLD OR SNOWFALL REGIONS.
- Installation place of Cold and Snowfall Regions
- Considerations to the Seasonal Winds and Snowfall
- Considerations to Snowfall / Snow Buildup
- Considerations to Sliding Snow from Roof or SNOWFALL
- As to Proper Drainage of Defrosting WATER
- Request to cut Net attached to Rear side of Outdoor Unit
- Installation of HOT PIPE
- H-LINK ADAPTOR
- MISCELLANEOUS NOTE
- Back_page(new)
CAPACITIES AND SELECTION DATA
4-221
INDOOR
OUTDOOR TEMPERATURE (°CDW)
EDB
-15
-10
-7
-5
0
7
10
15
°C
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
TC
SHC
PI
(1.2+1.2)+(1.2
+1.8+5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.2
+2.5+2.5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.2
+2.5+3.5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.2
+3.5+3.5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.8
+1.8+1.8)
16
3816
0
2094
6041
0
2151
6887
0
2242
7451
0
2304
9073
0
2578
10716
0
2612
11691
0
2683
13493
0
2816
18
3763
0
2123
5988
0
2179
6822
0
2289
7377
0
2363
8977
0
2643
10663
0
2745
11648
0
2802
13440
0
2949
20
3710
0
2151
5935
0
2207
6762
0
2326
7313
0
2406
8903
0
2689
10599
0
2830
11394
0
2929
13355
0
3085
22
3657
0
2179
5882
0
2236
6677
0
2375
7207
0
2468
8808
0
2754
10535
0
2943
11521
0
3037
13291
0
3212
24
3604
0
2207
5829
0
2264
6618
0
2422
7144
0
2527
8734
0
2819
10472
0
3056
11458
0
3153
13100
0
3342
(1.2+1.2)+(1.8
+1.8+2.5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.8
+1.8+3.5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
(1.2+1.2)+(1.8
+1.8+5)
16
3888
0
2131
6156
0
2189
7018
0
2282
7592
0
2344
9245
0
2624
10919
0
2658
11912
0
2730
13748
0
2866
18
3834
0
2160
6102
0
2218
6951
0
2330
7517
0
2405
9148
0
2690
10865
0
2794
11869
0
2851
13694
0
3001
20
3780
0
2189
6048
0
2246
6890
0
2367
7452
0
2448
9072
0
2736
10800
0
2880
11610
0
2981
13608
0
3139
22
3726
0
2218
5994
0
2275
6804
0
2417
7344
0
2511
8975
0
2802
10735
0
2995
11740
0
3090
13543
0
3269
24
3672
0
2246
5940
0
2304
6744
0
2465
7279
0
2572
8899
0
2868
10670
0
3110
11675
0
3208
13349
0
3401
EWB : Evaporator Wet Bulb temperature (°C)
TC : Total Capacity (W)
EDB : Evaporator Dry Bulb temperature (°C)
SHC : Sensible Heating Capacity (W)
(°CDB) : Outdoor Unit Inlet Air Dry Temperature (°C)
PI : Power Input