FOOD WASTE DISPOSERS MODELS FD4-150 FD4-200 FD4-300 701 S. RIDGE AVENUE TROY, OHIO 45374-0001 937 332-3000 www.hobartcorp.
© HOBART CORPORATION, 2014 –2–
TABLE OF CONTENTS SAFETY............................................................................................................................................. 4 INSTALLATION.................................................................................................................................. 5 Fabricating................................................................................................................................... 5 Plumbing Connections..................................
Installation, Operation and Care of MODELS FD4-150, FD4-200, & FD4-300 FOOD WASTE DISPOSERS SAVE THESE INSTRUCTIONS SAFETY RECOGNIZE SAFETY INFORMATION When you see this symbol on your machine or in this manual, be alert to the potential for personal injury. READ ALL INSTRUCTIONS Read this owner's manual before using the machine. Failure to follow the instructions provided could result in personal injury or equipment damage. KEEP OUT OF REACH OF CHILDREN This disposer is intended for commercial use only.
INSTALLATION Immediately after unpacking the disposer, check for possible shipping damage. If the disposer is found to be damaged, save the packaging material and contact the carrier within 15 days of delivery. Prior to installation, test the electrical service to make sure that it agrees with the specifications on the disposer data plate. Temporary support, such as blocking, must be provided for the disposer during installation to avoid excessive stress at welded or soldered cone to table connection.
ELECTRICAL CONNECTION Electrical and grounding connections must comply with the applicable portions of the National Electrical Code and/or other local electrical codes. Disconnect the electrical power to the machine and follow lockout/tagout procedures. This unit must be connected to a dedicated, acceptable motor control switch with a marked OFF position to disconnect the appliance from all ungrounded supply conductors.
15" 6 1/2" 6 1/2" 34" 2" 2" DRAIN LINE *27 3/8" 0"-6" FOOT ADJUSTMENT 6 1/4" 8" * HEIGHT CAN VARY FROM 22-5/8" TO 28-7/8" –7–
OPERATION Before operating disposer make sure it is clear of foreign objects such as metal or wire clippings, screws, nails, etc., which may have dropped into it during installation. Check the flywheel for free rotation. Never use your hand to check rotation of flywheel or to remove foreign matter from the disposer. Use a stick or similar object to turn the flywheel. Foreign matter can be removed with tongs or pliers. Start the disposer before feeding food waste. Be sure water is flowing.