MODEL HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS ML-136041 ML-136042 ML-136049 ML-136050 ML-136051 ML-136052 ML-136053 ML-136054 HC24EA3 HC24EA5 HC24EA3 HC24EA3 HC24EA3 HC24EA5 HC24EA5 HC24EA5 208/240 V. 208/240 V. 208/240 V. 480 V. 480 V. 208/240 V. 480 V. 480 V. 9.25KW 15.75KW 8.5KW 9.25KW 8.5KW 15KW 15.75KW 15KW PRO PRO BASIC PRO BASIC BASIC PRO BASIC 701 S. RIDGE AVENUE TROY, OHIO 45374-0001 1-888-4HOBART www.hobartcorp.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL THIS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. WARNING IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY ....................................................................................................... 2 INTRODUCTION .................................................................................................................................... 5 GENERAL .........................................................................................................................................
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS TABLE OF CONTENTS (CONTINUED) START UP (PROFESSIONAL MODEL) ........................................................................................ 11 OPERATION .............................................................................................................................12 Main Power Switch Light (Professional model) ................................................................. 12 Timer ...............................................
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS INTRODUCTION GENERAL UNPACKING Hobart convection steamers are produced with quality workmanship and material. Proper installation, usage and maintenance will result in many years of satisfactory performance. It is suggested that you thoroughly read this entire manual and carefully follow all of the instructions provided. This steamer was inspected before leaving the factory.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS LOCATION ANCHORING STEAMER Allow space for plumbing and electrical connections. Minimum clearance is 6" (15.2 cm) on the back for proper air circulation. Allow adequate access for operating and servicing the steamer (36" at the front of the steamer, 15" (38 cm) above the steamer and 18" (45.7 cm) on right side of steamer). 1. Place steamer in the desired location on the countertop and mark four corners.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS ELECTRICAL CONNECTION WARNING: ELECTRICAL AND GROUNDING CONNECTIONS MUST COMPLY WITH APPLICABLE PORTIONS OF THE NATIONAL ELECTRICAL CODE AND/OR OTHER LOCAL ELECTRICAL CODES. Total KW Volts Hz Ph The wiring diagram is located on the right side panel as you face the steamer. This steamer is hard wired.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS PLUMBING CONNECTIONS WARNING: PLUMBING CONNECTIONS MUST COMPLY WITH APPLICABLE SANITARY, SAFETY AND PLUMBING CODES. If the water supply fails to meet these standards, it will be necessary to install a water conditioner on the generator water feed. The use of strainers or filters will not remove minerals from the water.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS Figure 2 VENT HOOD Local codes may require the steamer to be located under an exhaust hood. Information on the construction and installation of ventilating hoods may be obtained from Vapor Removal from Cooking Equipment, NFPA standard No. 96 (latest edition).
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS OPERATION Cooking Light (Professional model only) CONTROLS Drain Handle (Basic model only) The cooking light indicates that the steamer is in the cooking cycle. Push the handle in to turn on the steamer. Pull the handle out to turn off and drain the steamer. Timer Note: Controls for the Basic and Professional models are shown in Figure 3. Set the cooking time (0 to 60 minutes). Steam cooking will begin when the door is closed.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS 8. Close compartment door and let cooking cycle finish. When timer returns to 0, the buzzer will sound, signaling the end of the cooking cycle. To silence the buzzer, turn the timer dial to OFF. 9. To shut down the steamer, pull the handle to turn off and drain. Leave compartment doors slightly open to allow the inside to dry out. SHUTDOWN Pull drain handle until it stops. The power light will turn off before the handle stops.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS 8. Close compartment door and let cooking cycle finish. When timer returns to 0, the buzzer will sound, signaling the end of the cooking cycle. To silence the buzzer, turn the timer dial to OFF. When the ready light is on, set the timer to 5 minutes. The cooking light will illuminate. When the buzzer sounds, turn the timer to the OFF position. The steamer is ready to cook. 9. To shut down the steamer, turn off the power switch.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS CLEANING COMPARTMENT WARNING: DISCONNECT THE ELECTRICAL POWER TO THE MACHINE AND FOLLOW LOCKOUT / TAGOUT PROCEDURES BEFORE CLEANING. Wash the inside of the compartment with a solution of warm water and non-chloride detergent. Rinse with warm water. COOKING COMPARTMENT DRAIN Keep compartment drain running freely. Inspect compartment drains daily for blockage. Remove any particles or debris from the perforated strainer daily (or more often if needed).
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS Avoid rubbing with steel pads, wire brushes or scrapers that can leave iron deposits on stainless steel. Instead, use plastic scouring pads or soft cloths. For stubborn stains, use products such as Cameo, Talc or Zud First Impression. Always rub parallel to the polish lines or with the grain. Hard water will leave deposits that promote rust on stainless steel. Treated water from softeners or certain filters can eliminate these mineral deposits.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS MAINTENANCE WARNING: THE STEAMER AND ITS PARTS ARE HOT. USE CARE WHEN OPERATING, CLEANING OR SERVICING THE STEAMER. THE COOKING COMPARTMENT CONTAINS LIVE STEAM. STAY CLEAR WHEN OPENING DOOR. 1-gallon container for mixing deliming solution • Petrol-Gel Lubricant or equivalent foodgrade grease for coating deliming port threads Note: Deliming solution may cause the surface of aluminum measuring tools to tarnish or etch.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS 8. Turn power switch ON. 9. When ready light comes on, turn cooking timer on for 3 minutes to delime the steam tubes and nozzles. 10. After 40 minutes, turn power switch OFF and allow steam generator to completely drain, 5 minutes. 11. Rinse steam generator with clean water: A. Turn power switch ON. When ready light comes on, turn cooking timer on for 3 minutes to rinse the steam tubes and nozzles. B.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS DRAINING THE GENERATOR Drain the generator at the end of each day to flush out minerals and minimize scale build-up. The generator drains automatically for approximately 15 minutes after the power switch is turned OFF on the Professional model, or the drain handle is pulled on the Basic model.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS COOKING HINTS The steamer efficiently cooks vegetables and other foods for immediate serving. Steam cooking should be carefully time controlled. Keep hot food holding-time to a minimum to produce the most appetizing results. Prepare small batches. Cook only enough to start serving, then cook additional amounts to meet demand. than 15 minutes of cooking time. When a cover is used, approximately one-third additional cooking time is necessary.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS PRODUCTS TO BE COOKED IN SOLID PANS PRODUCT TIME (MINUTES) WEIGHT PER PAN Eggs, Scrambled 9 - 12 8 Doz. Rice, Long Grain (Cover with 4 cups water/lb.) 23 - 25 2 Lb. Pasta (Place perforated pan inside solid pan, cover with cold water) Spaghetti – Regular/Vermicelli Macaroni - Shells/Elbows Noodles - 1/2" Wide Lasagna Noodles 10 - 15 13 - 18 10 - 15 13 - 18 Frozen Casseroles, Lasagna 33 - 35 Full Pan Meat Loaf, 3-5 Lb. Each 38 - 40 15 Lb.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS PRODUCTS TO BE COOKED IN PERFORATED PANS PRODUCT TIME (MINUTES) WEIGHT PER PAN SEAFOOD Clams Frozen Fresh, Cherrystone 9 - 12 4-6 3 Doz. 3 Doz. King Crab, Frozen Claws Legs 3-4 3-6 2 1/2 Lb. 4 1/2 Lb. Lobster Tail, Frozen 5-6 10 Lb. Lobster, Live, 10" - 12" 4-5 4 Per Pan Salmon Fillets, Frozen, 8 ounce each 4-5 7 1/2 Lb. Scallops, Fresh 3-4 3 Lb. Scrod Fillets, Fresh 3-5 4 Lb. 14 - 15 8 - 10 5-8 4 Doz. 4 Doz. 4 Doz.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS PRODUCT TIME (MINUTES) WEIGHT PER PAN VEGETABLES (Cont’d.) Broccoli Spears, Frozen Spears, Fresh Flowerettes, Frozen 6-8 4-6 4-6 4 Lb. 5 Lb. 5 Lb. Cabbage, Fresh, 1/6 Cut 6-8 5 Lb. Carrots Baby Whole, Frozen Crinkle Cut, Frozen Sliced, Fresh 6-8 7- 8 9 - 11 7 Lb. 4 Lb. 9 Lb. Cauliflower, Flowerettes Frozen Fresh 4-6 7-8 4 Lb. 5 Lb. Celery, 1" Diagonal Cut 5-7 5 Lb. Corn Yellow Whole Kernel, Frozen Cobbettes, Frozen 3-5 6-8 5 Lb.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES REMEDY No main power source Check the power source. Power switch in OFF position (Professional) Set power switch to the ON position. Handle out (OFF) position (Basic) Push handle in. Water not being supplied to steamer Refer to symptom WATER NOT BEING SUPPLIED TO STEAMER.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS SERVICE AND PARTS INFORMATION To obtain service and parts information concerning this steamer, contact the local Hobart Service office in your area, or call 1-888-4HOBART. Parts and service are also available at www.hobartcorp.com.
HC24EA SERIES ELECTRIC COUNTERTOP CONVECTION STEAMERS F-35432 (June 2006) — 24 — PRINTED IN U.S.A.
