OPERATOR'S MANUAL 12V CORDLESS GRASS SHEAR MODEL NO. GS120V THANK YOU FOR BUYING THIS HOMELITE CORDLESS GRASS SHEAR Your new cordless grass shear has been engineered and manufactured to Homelite's high standard for dependability, ease of operation, and operator safety. Properly cared for, it will give you years of rugged, trouble-free performance. CAUTION: Carefully read through this entire operator's manual before using your new cordless grass shear.
TABLE OF CONTENTS Rules for Safe Operation ................................................................................................................................ 2 - 5 Safety-Symbols .................................................................................................................................................... 6 Features ...............................................................................................................................................................
RULES FOR SAFE OPERATION READ ALL INSTRUCTIONS • BEFORE OPERATING • • • • • • • • • • • • • Read the instructions carefully. Be familiar with the controls and proper use of the unit. Do not operate this unit when tired, ill, or under the influence of alcohol, drugs, or medication. Inspect the unit before use. Replace damaged parts. Check for battery pack leaks. Make sure all fasteners are in place and secure. Replace cutting blades or any other parts that are cracked, chipped, or damaged.
RULES FOR SAFE OPERATION • • • • • • • • • • • Maintain grass shear with care. Keep cutting edge sharp and clean for best performance and to reduce the risk of injury. Follow instructions for lubricating and changing accessories. Keep unit dry, clean, and free from oil and grease. Check damaged parts. Before further use of the grass shear, any parts that are damaged should be carefully checked to determine that it will operate properly and perform it's intended function.
RULES FOR SAFE OPERATION • • • • • For best results, your battery unit should be charged in a location where the temperature is more than 50°F (10°C) but less than 100°F (38°C). Do not store outside or in vehicles. Under extreme usage or temperature conditions, battery pack leakage may occur. If liquid comes in contact with your skin, wash immediately with soap and water, then neutralize with lemon juice or vinegar.
SAFETY SYMBOLS The purpose of safety symbols is to attract your attention to possible dangers. The safety symbols, and their explanations, deserve your careful attention and understanding. The safety warnings do not by themselves eliminate any danger. The instructions or warnings they give are not substitutes for proper accident prevention measures. SYMBOL MEANING SAFETY ALERT SYMBOL Indicates danger, warning, or caution. Attention is required in order to avoid serious personal injury.
FEATURES MODEL GS120V - 12V CORDLESS GRASS SHEAR BATTERY PACK REAR HANDLE TRIGGER LOCK BUTTON TRIGGER BLADES Fig.
OPERATION • WARNING: If any parts are missing, do not operate unit until the missing parts are replaced. Failure to do so could result in possible serious personal injury. • The battery pack will become slightly warm to the touch while charging. This is normal and does not indicate a problem. DO NOT place charger in an area of extreme heat or cold. It will work best at normal room temperature.
OPERATION TO INSTALL BATTERY PACK • • CAUTION: Place the battery pack in the grass shear. Align raised rib on battery pack with groove in grass shear battery port. See Figure 3. Make sure the latches on each side of the battery pack snap in place and that battery pack is secured in the grass shear before beginning operation. When placing battery pack in your grass shear, be sure raised rib on battery pack aligns with groove in grass shear battery port and latches snap in place properly.
OPERATION HOLDING THE GRASS SHEAR • Do not force the unit through dense growth. If the blades slow down, reduce your pace. If blades do become jammed, stop the motor, allow the blades to stop and remove the battery pack before attempting to remove the obstruction. • WARNING: Dress properly to reduce the risk of injury when operating this unit. Do not wear loose clothing or jewelry. Always wear eye protection when in use. Wear heavy, long pants, boots and well fitting gloves.
MAINTENANCE AND REPAIR REPLACING BLADES BLADE MAINTENANCE - GRASS SHEAR WARNING: Blades are sharp. When handling blades, do not place your hand or fingers between blades or in any position where they could get pinched or cut. NEVER touch blades or service unit with battery pack installed. Dull blades cut poorly and put extra strain on the motor. Replace the blades if they become dull from heavy use.
MAINTENANCE AND REPAIR GRASS SHEAR LUBRICATION All of the bearings in this tool are lubricated with a sufficient amount of high-grade lubricant for the life of the unit under normal operating procedures. Therefore, no further lubrication is required. WARNING: Do not attempt to disassemble the battery pack. Fire or injury can result. BATTERIES Your battery pack is equipped with Nickel-Cadmium rechargeable batteries. Length of service from each charging will depend on the type of work you are doing.
MAINTENANCE AND REPAIR DISPOSAL OF THE EXHAUSTED BATTERY PACK C YC R E LE 1.8 00 N i Cd 37 RBRC .822.88 WARNING: To preserve natural resources, please recycle or dispose of properly. This product contains nickel-cadmium battery pack. Must be disposed of properly. Local, state, or federal laws may prohibit disposal of NickelCadmium batteries in ordinary trash. Consult your local waste authority for information regarding available recycling and/or disposal options.
MAINTENANCE AND REPAIR • • Store and charge your batteries in a cool area. Temperatures above or below normal room temperature will shorten battery pack life. Never store batteries in a discharged condition. Wait for battery pack to cool and charge immediately. • All batteries gradually lose their charge. The higher the temperature, the quicker they lose their charge. If you store your unit for long periods of time without using it, recharge the batteries every month or two.
HOMELITE PRODUCTS LIMITED WARRANTY Homelite Consumer Products, Inc. warrants to the original retail purchaser that this HOMELITE® Product is free from defect in material and workmanship and agrees to repair or replace, at Homelite Consumer Products, Inc.
OPERATOR'S MANUAL 12V CORDLESS GRASS SHEAR MODEL NO. GS120V SERVICE Now that you have purchased your unit, should a need ever exist for repair parts or service, simply contact your nearest Homelite Authorized Service Center. Be sure to provide all pertinent facts when you call or visit. Please call 1-800-chainsaw (1-800-242-4672) for your nearest Homelite Authorized Service Center. You can also check our web site at www.homelite.com for a complete list of Authorized Service Centers. MODEL NO.
