Outboard Motor User Manual
Table Of Contents
- COVER
- INTRODUCTION
- CONTENTS
- OUTBOARD MOTOR SAFETY
- CONTROLS AND FEATURES
- CONTROL AND FEATURE ID CODES
- COMPONENT AND CONTROL LOCATIONS
- LHT TYPE (TILLER HANDLE)
- LRT AND XRT TYPES (REMOTE CONTROL)
- REMOTE CONTROL BOX (SIDE-MOUNT CONTROL TYPE) (OPTIONAL EQUIPMENT)
- PORTABLE FUEL TANK (OPTIONAL EQUIPMENT)
- TRIM METER (OPTIONAL EQUIPMENT)
- TACHOMETER (OPTIONAL EQUIPMENT)
- RUDDER METER
- TROLLING CONTROL SWITCH PANEL
- DIGITAL SPEEDOMETER (OPTIONAL EQUIPMENT)
- DIGITAL TACHOMETER (OPTIONAL EQUIPMENT)
- CONTROLS
- BEFORE OPERATION
- OPERATION
- SAFE OPERATING PRECAUTIONS
- BREAK-IN PROCEDURE
- PORTABLE FUEL TANK (OPTIONAL EQUIPMENT)
- FUEL HOSE CONNECTIONS
- FUEL PRIMING
- INFREQUENT OR OCCASIONAL USE
- STARTING THE ENGINE
- EMERGENCY STARTING
- STOPPING THE ENGINE
- GEARSHIFT AND THROTTLE OPERATION
- STEERING
- CRUISING
- TRIM TAB
- SHALLOW WATER OPERATION
- MOORING, BEACHING, LAUNCHING
- SERVICING YOUR OUTBOARD MOTOR
- CLEANING AND FLUSHING
- STORAGE
- TRANSPORTING
- TAKING CARE OF UNEXPECTED PROBLEMS
- TECHNICAL INFORMATION
- CONSUMER INFORMATION
- INDEX
Gasoline is highly
flammable and explosive.
You can be burned or
seriously injured when
handling fuel.
Stop the engine and keep
heat, sparks, and flame
away.
Handle fuel only
outdoors.
Wipe up spills
immediately.
100
STORAGE
DRAIN TUBE
VAPOR
SEPARATOR
TUBE CLAMPER
DRAIN SCREW
Draining the Fuel System
Disconnect the fuel tank hose
assembly connector from the fuel
tank (p. ).
Loosen the vapor separator drain
screw.
Release the drain tube from its
clamp along the high pressure fuel
hose and set the end of the tube
toward the outside of the engine
undercase. Place an approved
gasoline container below the end
of the tube, and use a funnel to
avoid spilling gasoline.
Remove the engine cover (p. ).
You can avoid fuel deterioration
problems by draining the fuel tank
and vapor separator. Before draining
and checking the fuel system, check
the fuel filter for contamination and/
or water accumulation. The fuel filter
must be free of any contamination
before proceeding (p. ). Draining
the vapor separator will not drain the
fuel filter bowl.
2.
1.
3.
4.
79
90
90
11/03/09 17:50:51 31ZZ3610_101