2014 Civic CNG Online Reference Owner's Manual This owner’s manual should be considered a permanent part of the vehicle and should remain with the vehicle when it is sold. This owner’s manual is for vehicles sold in the United States. The information and specifications included in this publication were in effect at the time of approval for printing. Honda Motor Co., Ltd.
Contents 2014 Civic CNG Safe Driving P. 4 Safety Labels P. 4 Safe Driving P. 4 Instrument Panel P. 6 Instrument Panel P. 6 Indicators P. 6 Gauges and Displays P. 9 Driving P. 10 Before Driving P. 10 When Driving P. 11 Refueling P. 16 Maintenance P. 19 Maintaining the Fuel System P. 19 Replacing Light Bulbs P. 23 TM Maintenance Minder P. 20 Driving P. 10 Maintenance P. 19 Handling the Unexpected P. 25 Information P. 42 Maintenance Under the Hood P. 22 Handling the Unexpected P.
2014 Civic CNG Online Reference Owner's Manual Introduction Home Your vehicle runs on compressed natural gas (CNG), a highly pressurized version of the same clean-burning natural gas used in many homes and businesses. Your vehicle operates and performs like a gasoline-powered vehicle. However, there are a few differences you should be aware of. In addition to reading your vehicle’s owner’s manual, please read this supplement carefully to understand the operation and unique features of your vehicle.
2014 Civic CNG Online Reference Owner's Manual Home Fuel Quality and Home Refueling In order to insure that your Civic Natural Gas vehicle receives CNG fuel with quality equal to or above the NFPA-52 and SAE J1616 fuel standards, Honda only recommends that your vehicle be refueled at a public commercial-grade CNG refueling station. Public stations offer an approximately five minute refueling time, and the assurance of natural gas quality meeting NFPA and SAE standards.
Safety Labels Home 2014 Civic CNG CNG Label Locations These labels are in the locations shown. They give instructions and warnings on the CNG fuel system. If a label comes off or becomes hard to read, contact a dealer for a replacement. SD Safe Driving Hood CNG Tank THIS VEHICLE IS FUELED BY COMPRESSED NATURAL GAS STORED AT HIGH PRESSURE. DO NOT ATTEMPT TO SERVICE FUEL SYSTEM WITHOUT PROPER SYSTEM DEPRESSURIZATION.
Safety Labels After a Collision 2014 Civic CNG Home SD Safe Driving CNG tank expiration and production dates: Are indicated on the labels. Have an authorized dealer or certified NGV technician inspect the fuel tank every three years, or 36,000 miles, whichever comes first, and replace it 15 years from its production date. Do not use an expired tank or reuse the old tank for other purposes. After a Collision Have the fuel tank inspected by an authorized dealer or certified NGV technician.
Indicators 2014 Civic CNG Home Indicator Name IP Instrument Panel Malfunction Indicator Lamp On/Blinking • Comes on when you turn the ignition switch to ON II , and goes off either when the engine starts or after several seconds if the engine did not start. If "readiness codes" have not been set, it blinks five times before it goes off. • Comes on if there is a problem with the emissions control system. • Comes on if there is a problem with the fuel system.
Indicators 2014 Civic CNG Home Indicator Name IP Instrument Panel Low Fuel Indicator On/Blinking Explanation • Comes on when you turn the ignition switch to ON II , and goes off when the engine starts. • Comes on when the fuel reserve is running low. • Blinks if there is a problem with the fuel gauge. • Comes on - Refuel your vehicle as soon as possible.
Indicators intelligent Multi-Information Display (i-MID) Warning and Information Messages 2014 Civic CNG Home intelligent Multi-Information Display (i-MID) Warning and Information Messages The following messages appear only on the i-MID. Press the system message indicator on. Message IP (display/information) button to see the message again with the Condition Instrument Panel • Appears when the fuel receptacle lid is open. FUEL LID OPEN 8 Explanation Fuel Gauge P.
Gauges and Displays Home 2014 Civic CNG Gauges Fuel Gauge Upper F Mark IP Displays the amount of fuel left in the fuel tank. Instrument Panel The lower F mark indicates a full tank at a fill pressure of 3,000 psi. Fuel Gauge Lower F Mark The upper F mark indicates a full tank at a fill pressure of 3,600 psi. FUEL LID OPEN Fuel Gauge The quantity of fuel remaining in the tank is calculated based on the pressure and temperature of the natural gas in the fuel tank.
Before Driving Home Storing Cargo in the Trunk Do not put large, heavy or pointed objects in the trunk. When storing items, properly secure them so that they do not move around while driving. The fuel tank is located in the trunk, and although a partition separates the tank from the cargo space, large items or loose items can damage the fuel tank and fuel system components. D Towing a Trailer Driving Your vehicle is not designed to tow a trailer. Attempting to do so can void your warranties.
When Driving Home 2014 Civic CNG Starting the Engine 1. Make sure the parking brake is applied. D Driving Brake Pedal 2. Check that the shift lever is in P , then depress the brake pedal. Although it is possible to start the vehicle in N , it is safer to start it in P . Starting the Engine Keep your foot firmly on the brake pedal when starting the engine. The engine is harder to start in cold weather and in thinner air found at altitudes above 8,000 feet (2,400 meters).
When Driving Starting the Engine 2014 Civic CNG Home 3. Turn the ignition switch to ON II without depressing the accelerator pedal. You may hear a click from the in-tank fuel shut-off valve. 4. Turn the ignition switch to START III without depressing the accelerator pedal. D Starting the Engine Driving Do not hold the key in START III for more than 15 seconds. •• If the engine does not start right away, wait for at least 10 seconds before trying again.
When Driving Home Automatic Transmission Automatic Transmission 2014 Civic CNG Creeping The engine runs at a higher idle speed and creeping increases. Keep the brake pedal firmly depressed when stopped. D Kickdown Driving Quickly depressing the accelerator pedal while driving uphill may cause the transmission to drop to a lower gear, unexpectedly increasing vehicle speed. Depress the accelerator pedal carefully, especially on slippery roads and curves.
When Driving Home Shifting 2014 Civic CNG Shifting Change the shift position in accordance with your driving needs. You cannot turn the ignition switch to LOCK 0 and remove the key unless the shift lever is in P .
When Driving Shifting 2014 Civic CNG Home Shift Lever Operation Shift Lever Operation D NOTICE Shift Lever Position Indicator When you change the shift lever from D to R and vice versa, come to a complete stop and keep the brake pedal depressed. Operating the shift lever before the vehicle has come to a complete standstill can damage the transmission. Driving Use the shift lever position indicator to check the lever position before pulling away.
Refueling Home Only fuels that can be used NFPA-52 and SAE J1616 standards Use of a fuel that does not meet these standards can cause a decrease in engine power and damage the emission controls. Fuel tank capacity: D Slow filling Driving 6.96 gasoline gallon equivalent (3,000 psi) 7.77 gasoline gallon equivalent (3,600 psi) Fast filling 5.84 gasoline gallon equivalent (3,000 psi) 6.
Refueling How to Refuel 2014 Civic CNG Home How to Refuel Refueling Procedure Example Push D Driving Using fast fill equipment at temperature below -4°F (-20°C) may damage the fuel system, potentially causing a leak. 2. Turn off the engine. 3. Push on the fuel receptacle lid release handle at the foot of the driver’s seat. Always observe all safety recommendations and operating instructions on the refueling equipment. The fuel receptacle lid opens. Fuel Receptacle NOTICE 1.
Refueling How to Refuel 2014 Civic CNG Home 6. Turn the lever until the arrows on the nozzle point to each other, then follow the instructions on the refueling station to begin refueling. While refueling, you may hear a chattering sound. This is normal. D Driving 7. Refueling will stop automatically when the tank is full. Follow the instructions on the refueling station to turn it off. 8. Disconnect the CNG fill nozzle from the fuel receptacle by slowly turning the lever on the nozzle 180 degrees.
Maintaining the Fuel System 2014 Civic CNG Home Your vehicle’s fuel system must be maintained and repaired by an authorized Civic Natural Gas dealer or a certified NGV technician. The fuel system has no userserviceable parts, and its components must not be modified. See instructions on fuel container for inspection and service life. Service Pressure: 3,600 psi (24,800 kPa) ÎÎ CNG M Label Locations P.
Maintenance MinderTM 2014 Civic CNG Home Your vehicle displays engine oil life and maintenance service items on the intelligent multi-information display (i-MID) to show you when you should have a dealer do engine oil replacement and indicated maintenance service. Refer to the important safety precautions and instructions in the Owner's Manual.
Maintenance MinderTM To Use Maintenace MinderTM 2014 Civic CNG Home Maintenance Service Items •• Independent of the Maintenance Minder information, replace the brake fluid every 3 years. •• Inspect idle speed every 160,000 miles (256,000 km). •• Adjust the valves during services A, B, 1, 2, or 3 if they are noisy.
Maintenance Under the Hood Home 2014 Civic CNG Transmission Fluid Automatic Transmission Fluid Automatic Transmission Fluid Specified fluid: Honda ATF DW-1 (automatic transmission fluid) Check the fluid level when the engine is at normal operating temperature. 1. Park on level ground, and start the engine. 2. Wait until the radiator fan starts and then turn off the engine. Perform step 3 after waiting for about 60 seconds (less than 90 seconds). M Maintenance HOT Range Upper Mark Lower Mark 3.
Replacing Light Bulbs Home 2014 Civic CNG High-Mount Brake Light Bulb When replacing, use the following bulb. High-Mount Brake Light: 21W Trunk Lining Screw 1. Open the trunk. 2. Remove the screw from the center of each trunk lining fastener, then remove the fasteners. M Maintenance Fastener 3. Pull the upper edge of the trunk lining down.
Replacing Light Bulbs High-Mount Brake Light Bulb 2014 Civic CNG Home 4. Turn the socket to the left and remove it. 5. Remove the old bulb and insert a new bulb.
Tools Home 2014 Civic CNG Models with compact spare tire Type of Tools Type of Tools The tools are stored in the trunk.
If a Tire Goes Flat Home 2014 Civic CNG Models with compact spare tire Changing a Flat Tire To change a flat tire, follow the instructions in the Owner’s Manual. To remove the spare tire, tools and the jack from the trunk and to store the flat tire, follow the instructions in this section. Removing the Spare Tire, Tools and the Jack Trunk Floor Lid 1. Open the trunk. 2. Remove the trunk floor lid. HU Handling the Unexpected Tool Kit Spare Tire 26 Tool Case 3.
If a Tire Goes Flat Changing a Flat Tire 2014 Civic CNG Home Wing Bolt Trunk Lining 5. Take the spare tire out of its well. Bend the lower part of the trunk lining upward to enlarge the opening. Spacer Cone Spare Tire 4. Unscrew the wing bolt and remove the spacer cone. Jack 6. Turn the jack’s end counterclockwise to loosen it, then remove the jack.
If a Tire Goes Flat Changing a Flat Tire 2014 Civic CNG Home Storing a Flat Tire Storing a Flat Tire Trunk Lining Rubber Cap 1. Open the trunk. 2. Raise the trunk floor and the lower part of the trunk lining. 3. Remove the rubber caps from the holes in the trunk floor and the trunk lining, then align both holes. Trunk Floor Support Plate 4. Place the flat tire straight up in the trunk, with the outside of the wheel facing forward. HU Handling the Unexpected 5.
If a Tire Goes Flat Home 2014 Civic CNG Models with tire repair kit Temporarily Repairing a Flat Tire This vehicle is not equipped with a spare tire. If the tire has a large cut or is otherwise severely damaged, you will need to have the vehicle towed. If the tire only has a small puncture, from a nail for instance, you can use the temporary tire repair kit so that you can drive to the nearest service station for a more permanent repair.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home 1. Remove the trunk floor lid. Getting Ready to Temporarily Repair the Flat Tire When making a temporary repair, carefully read the instruction manual provided with the kit. In cold temperatures, the sealant may not flow easily. In this situation, warm it up for five minutes before using. HU Handling the Unexpected 30 2. Take the kit out of the case.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home Injecting Sealant and Air Injecting Sealant and Air Valve Cap 1. Remove the valve cap from the tire valve stem. Valve Stem Sealant/Air Hose 2. Remove the sealant/air hose from the packaging. HU WARNING Tire sealant contains substances that are harmful and can be fatal if swallowed. If accidentally swallowed, do not induce vomiting. Drink plenty of water and get medical attention immediately.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home 4. Plug in the compressor to the accessory power socket. Be careful not to pinch the cord in a door or window. 5. Start the engine. Keep the engine running while injecting sealant and air. ÎÎ Carbon Monoxide Gas P. 64, Owner's Manual 6. Turn the selector switch to SEALANT/AIR.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home Sealant/Air Hose 10.Unplug the power plug from the accessory power socket. 11. Unscrew the sealant/air hose from the tire valve stem. Reinstall the valve cap. Injecting Sealant and Air See a Honda dealer for a replacement sealant bottle and proper disposal of an empty bottle. 12.Press the pressure relief button until the gauge returns 0 psi (0 kPa). Valve Stem Repair Notification Label 13.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home 4. Attach the air only hose onto the tire valve stem. Screw it until it is tight. 5. Turn the selector switch to AIR ONLY. Do not turn the air compressor on to check the pressure. ÎÎ Inflating An Under-inflated Tire P. 35 Air Only Hose HU 6. If the air pressure is: • Less than 19 psi (130 kPa): Do not add air or continue driving. The leak is too severe. Call for help and have your vehicle towed.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home Inflating An Under-inflated Tire Inflating An Under-inflated Tire NOTICE You can use the kit to inflate a non-punctured under-inflated tire. 1. Remove the trunk floor lid. ÎÎ Getting Ready to Temporarily Repair the Flat Tire P. 29 Do not operate the temporary tire repair kit compressor for more than 15 minutes. The accessory power socket and compressor can overheat and become permanently damaged. 2.
If a Tire Goes Flat Temporarily Repairing a Flat Tire 2014 Civic CNG Home 7. Plug in the kit to the accessory power socket. Be careful not to pinch the cord in a door or window. 8. Start the engine. Keep the engine running while injecting air. ÎÎ Carbon Monoxide Gas P. 64, Owner's Manual AIR ONLY Side HU Handling the Unexpected ON Pressure Relief Button 36 9. Turn the selector switch to AIR ONLY. 10.Press the inflator switch to turn on the kit. The compressor starts to inject air into the tire.
Fuel Leaks Home 2014 Civic CNG If a Fuel Leak is Detected If you smell natural gas or hear a hissing sound, except when refueling, the fuel system may have a leak. Turning Off the Manual Shut-Off Valve 1. Park your vehicle outside in a well-ventilated area. Set the parking brake. Keep away from heat, sparks, and flame. 2. Open all the windows and trunk for ventilation. 3. Turn the ignition switch to LOCK 0 . 4. Turn the manual shut-off valve one-quarter turn clockwise (located as shown).
Indicator, Coming On/Blinking Home HU Handling the Unexpected 38 If the Malfunction Indicator Lamp Comes On or Blinks 2014 Civic CNG If the Malfunction Indicator Lamp Comes On or Blinks NOTICE Reasons for the indicator lamp to come on or blink •• Comes on when there is a problem with the engine emissions control system, or the fuel system. If you drive with the malfunction indicator lamp on, the emissions control system and the engine could be damaged. •• Blinks when engine misfiring is detected.
Fuses 2014 Civic CNG Home To check and replace fuses, follow the instructions in the Owner’s Manual. Since your vehicle’s fuses are different from the standard gasoline model’s fuses, determine from the chart or the diagram on the fuse box label, which fuse or fuses control that device. Current (Amps) ratings in brackets indicate a fuse in that location for a device that may not be equipped on your vehicle.
Fuses Home Fuse Locations 2014 Civic CNG Fuse Locations If any electrical devices are not working, turn the ignition switch to LOCK 0 and check to see if any applicable fuse is blown. Engine Compartment Fuse Box Located near the brake fluid reservoir. Push the tabs to open the box. HU Fuse locations are shown on the fuse box cover. Locate the fuse in question by the fuse number and box cover number.
Fuses Fuse Locations 2014 Civic CNG Home Interior Fuse Box Located under the dashboard. Fuse Label HU Handling the Unexpected Fuse locations are shown on the label on the side panel. Locate the fuse in question by the fuse number and label number. Circuit protected and fuse rating Circuit Protected Amps (20 A) 1 HAC Option* 2 ACG 10 A 3 SRS 10 A 4 Fuel Pump 15 A 5 Meter 7.5 A 6 Power Window 7.
Specifications 2014 Civic CNG Home Vehicle Specifications Model No. of Passengers: Front Rear Total Weights: Gross Vehicle Weight Rating Gross Axle Weight Rating (Front) Gross Axle Weight Rating (Rear) Air Conditioning: Refrigerant Type Charge Quantity Lubricant Type I Information 42 Honda Civic 4-Door Natural Gas 2 3 5 3,870 lbs (1,755 kg) Engine Specifications Displacement Spark Plugs Fuel Fuel Tank Service Pressure Fuel Tank Capacity 2,007 lbs (910 kg) 1,863 lbs (845 kg) HFC-134a (R-134a) 13.
Specifications 2014 Civic CNG Home Brake Fluid Specified Engine Oil Honda Heavy Duty Brake Fluid DOT 3 Automatic Transmission Fluid Specified Honda ATF DW-1 (automatic transmission fluid) Capacity Change 2.5 US qt (2.4 ℓ) Recommended Tire • Genuine Honda Motor Oil 0W-20 • API Premium-grade 0W-20 detergent oil Change Capacity Change including filter 3.7 US qt (3.5 ℓ) 3.9 US qt (3.
Fuel System Home 2014 Civic CNG System Components Fuel Pressure Regulator Fuel Feed Line Fuel Tank Fuel Receptacle System Components Your vehicle’s fuel system includes a fuel tank, a fuel pressure regulator, a manual shut-off valve, high pressure fuel lines, and other components that comply with NFPA-52 standards. The system in your vehicle, including the tank and hoses, has been designed to hold gas at this pressure. It has also been tested for safety.
Authorized Manuals 2014 Civic CNG Home Service Express For electronic copies of service publications, you can purchase a subscription to Service Express. Visit www.techinfo.honda.com for pricing and options. Manuals in print Manuals can be purchased from Helm Incorporated. You can order a manual by phone at (800) 782-4356 (credit card orders only), or online at www.helminc.com.