Use and Care Manual

ManualsBrandsHonda ManualsGas Snow Blowers24 in. Two-Stage Hydrostatic Track Drive Gas powered Snow Blower with Electric Joystick Chute Control

Maintenance Schedule

(1) For professional commercial use, log hours of operation to determine proper maintenance intervals.

(2) These items should be serviced by your Honda servicing dealer, unless you have the proper tools and are mechanically proficient. Refer to the

Honda Shop Manual for service procedures. See “Honda Publications” on page 24 for ordering information.

(3) Check the belt for wear or damage. Replace the belt with a new one if it is worn or damaged.

(4) These parts may require more frequent inspection and replacement under heavy use.

Failure to follow this maintenance schedule could result in non-warrantable failures.

Each use

Every year

First month

or 20 hours

Every 100

hours

Every 300

hours

Every 4

years

PageBefore

operation

Before

storage

Engine oil Check level o page 5

Change o (4) o o (4) page 15

Auger transmission oil Check level o (2) —

Spark plug Check-adjust o (4)

page 15

Replace oo

Spark arrester Clean o (2) —

Auger skid shoes and scraper Check-adjust o o (4) page 16

Track Check-adjust o (4) o page 16

Wheel Check condition

and tire pressure

oo page 16

Auger and blower shear bolts Check o page 16

Bolts, nuts, fasteners Check o page 5

Fuel tank and carburetor Drain o page 18

Fuel sediment cup Clean o page 19

Lubrication points Apply grease/lube o page 18

Drive chains (track-type models) Lubricate o page 18

Chute guide control cable Check-adjust o (2) (4) o (2) (4) —

Auger clutch cable Check-adjust o (2) (4) o (2) (4) —

Throttle/choke cable Check-adjust o (2) (4) —

Drive clutch cable Check-adjust o (2) (4) o (2) (4) —

Height adjusting lever Check movement o (2) (4) —

Drive belt Check-adjust o (2) (3) (4) o(2)(3)(4) —

Auger belt Check-adjust o (2) (3) (4) o(2)(3)(4) —

Idle speed Check-adjust o (2) o (2) —

Valve clearance Check-adjust o (2) o (2) —

Combustion chamber Clean After every 1,000 hours (2) —

Fuel tank and filter Clean o (2) o (2) —

Fuel tube Check Every 2 years (2)

—

Replace o (2)

Battery (if equipped) Check voltage Charge if voltage is less than 12.9 V.

page 19

Charge o o

REGULAR SERVICE PERIOD (1)

Perform at every indicated month or operating

hour interval, whichever comes first.

Item