Install Instructions

ManualsBrandsHoneywell ManualsHVAC Controls1/4" NPT Pressure Switch, 1.5-7 psi Auto Reset (Additive)

➔

www.docuthek.com

USA CAN MEX

Cert. version 05.18

Operating instructions

USA

CAN

MEX

USA-1

03251547

Translation from the German

Gas pressure switches C6097A,

C6097B

Please read and keep in a safe place

Please read through these instructions

carefully before installing or operating. Following the

installation, pass the instructions on to the opera-

tor. This unit must be installed and commissioned

in accordance with the regulations and standards

in force. These instructions can also be found at

www.docuthek.com.

Explanation of symbols

• , 1 , 2 , 3 ... = Action

▷ = Instruction

Liability

We will not be held liable for damage resulting from

non-observance of the instructions and non-com-

pliant use.

Safety instructions

Information that is relevant for safety is indicated in

the instructions as follows:

DANGER

Indicates potentially fatal situations.

WARNING

Indicates possible danger to life and limb.

CAUTION

Indicates possible material damage.

All interventions may only be carried out by qualiﬁed

gas technicians. Electrical interventions may only be

carried out by qualiﬁed electricians.

Conversion, spare parts

All technical changes are prohibited. Only use OEM

spare parts.

Checking the usage

Gas pressure switches C6097 for monitoring increas-

ing and decreasing gas or air pressure.

C6097A: switches with falling pressure,

C6097B: switches with rising pressure.

Positive pressure Negative pressure

C6097A

Gas, air, ﬂue gas,

biogas

Air, ﬂue gas

C6097B

Gas, air, ﬂue gas,

biogas

Air, ﬂue gas

Pressure switches with manual reset lock off after

switching. They can be unlocked using the manual

reset.

This function is only guaranteed when used within the

speciﬁed limits– see page5 (Technical data). Any

other use is considered as non-compliant.

Part designations

1 Upper housing section with cover

2 Lower housing section

3 Hand wheel

4 ½" NPT conduit coupling

5 Manual reset

(only on C6097A3012, C6097A3038,

C6097A3095, C6097A3111, C6097B3002,

C6097B3028, C6097B3051 and some

customer specific variants)

Type label

C6097

Approval and type: see

type label.

For detailed information on the adjusting range, mean

switching differential, max. inlet pressure, lock-off,

medium and switching properties, see page 6

(Type table).

Safety

Summary of content (6 pages)

PAGE 1
USA CAN MEX ➔ www.docuthek.com Checking the usage Operating instructions Gas pressure switches C6097A, C6097B Gas pressure switches C6097 for monitoring increasing and decreasing gas or air pressure. C6097A: switches with falling pressure, C6097B: switches with rising pressure. Positive pressure Negative pressure Gas, air, flue gas, C6097A Air, flue gas biogas Gas, air, flue gas, C6097B Air, flue gas biogas Pressure switches with manual reset lock off after switching.
PAGE 2
Ports 4 D MEX CAUTION CAN USA Installation Please observe the following to ensure that the C6097 is not damaged during installation and operation: – Continuous operation with gases containing more than 0.1 %-by-vol. H2S or ozone concentrations exceeding 200 µg/m3 accelerate the ageing of elastomer materials and reduce the service life. – Use approved sealing material only. – Dropping the device can cause permanent damage. In this event, replace the entire device and associated modules before use.
PAGE 3
Wiring 0 To ensure that the C6097 is not damaged during operation, note the switching capacity, see page 5 (Technical data). ▷▷ In the case of low switching capacities, such as 24 V, 8 mA, for example, we recommend using an RC module (22 Ω, 1 μF) in air containing silicone or oil. 1 Disconnect the system from the electrical power supply. 2 3 4 USA CAUTION 0.4" = 0.4"WC (1 cm = 1 mbar) 6 Apply pressure. In doing so, monitor the ohmmeter and the pressure gauge.
PAGE 4
Pilot lamp set, blue 1 D MEX LED set, red/green CAN USA Accessories 1 3 2 3 2 4 L1 + 1 2 NC NO 3 COM 2 NO 1 NC 4 3 COM 2 NO 3 COM 1 NO 2 NC NO 3 COM 1 NC N N – N L1 NC 3 COM 2 1 NC NO 24 V DC, I = 16 mA; 24 V AC, I = 8 mA, Order No.: 32003048-003/U. 110 to 230 V AC, Order No.: 32003049-003/U. 1 2 NC NO 3 COM N N 110/120 V AC, I = 1.2 mA, Order No.: 32003045-003/U. Further information about accessories can be found in Technical Information bulletin C6097 – www.docuthek.
PAGE 5
Logistics Gas type: natural gas, town gas, LPG (gaseous), flue gas, biogas (max. 0.1 %-by-vol. H2S) and air. Max. inlet pressure pmax. = withstand pressure, see page 6 (Type table). Switching capacity: U I (cos φ = 1) I (cos φ = 0.6) C6097 24 – 240 V AC max. 5 A max. 0.5 A Storage temperature: -4 to +104°F (-20 to +40°C). Maximum medium and ambient temperatures: -40 to +140°F (-40 to +60°C).
PAGE 6
Contact If you have any technical questions, please contact your local branch office/agent. The addresses are available on the Internet or from Elster GmbH. Elster GmbH Strotheweg 1, D-49504 Lotte (Büren) Tel. +49 541 1214-0 We reserve the right to make technical modifications Fax +49 541 1214-370 in the interests of progress. hts.lotte@honeywell.com, www.kromschroeder.com USA-6 1) Adjusting 40 – 200 "WC (100 – 500 mbar) 40 – 200 "WC (100 – 500 mbar) 12 – 60 "WC (30 – 150 mbar) 1 – 20 "WC (2.