Instructions / Assembly

VR8245 AND VR8345 UNIVERSAL ELECTRONIC IGNITION GAS CONTROLS
69-2013—02 2
WARNING
FIRE OR EXPLOSION HAZARD
CAN CAUSE PROPERTY DAMAGE, SEVERE INJURY, OR DEATH
Follow these warnings exactly:
1. Disconnect power supply before wiring to
prevent electrical shock or equipment damage.
2. To avoid dangerous accumulation of fuel gas,
turn off gas supply at the appliance service
valve before starting installation and perform
Gas Leak Test after completion of installation.
3. When working with a system using intermittent
pilot ignition, do not bend pilot tubing at gas
control or pilot burner after compression fitting
has been tightened because gas leakage at the
connection can result.
4. Always install sediment trap in gas supply line
to prevent contamination of gas control.
5. Do not force the gas control knob. Use only
your hand to turn the gas control knob. Never
use any tools. If the gas control knob will not
operate by hand, call a qualified service
technician to replace the gas control. Force or
attempted repair can result in fire or explosion.
CAUTION
Never apply a jumper across or short the valve
coil terminals. This can burn out the heat
anticipator in the thermostat or damage the
electronic intermittent pilot (IP) module.
IMPORTANT:
These gas controls are shipped with protective
seals over inlet and outlet tappings. Do not
remove seals until ready to connect piping.
Follow the appliance manufacturer instructions if
available; otherwise, use the following instructions.
Table 3. Fuel Conversion Kits.
Valve
Size
(Inlet and Outlet)
Pressure
Regulator Type Current Draw (A)
Conversion Kits
Natural Gas - LP LP - Natural Gas
VR8245M 1/2 x 1/2 Standard .5 393691 394588
VR8345H,K 3/4 x 3/4 Slow-Opening .7 393691 394588
VR8345M 3/4 x 3/4 Standard .7 393691 394588
VR8345Q 3/4 x 3/4 2-Stage .9 396021 396025
Table 4. Cross Reference.
Universal
Service Part Honeywell White-Rodgers Robert-Shaw
VR8245M2530 VR8204M1075, VR8204M1091,
VR8204A1201, VR8204A1219,
VR8204A2001, VR8204A2076,
VR8204A2175, VR8204A2803,
VR8205A2008, VR8205M1106,
VR8205A2024, VR8205M2310,
VR8205M2443
36E01-204, 36E01-205,
36E01-206, 36E01-305,
36E22-214, 36E36-304,
36E93-304, 36G22-214,
36J22-214
720-079 (7200IPER),
720-080 (7200IPER-LP),
722-051 (2000DERHC),
722-079 (2000IPERHC)
VR8345H4555 VR8204H1006, VR8304H4503,
VR8305H4013, VR8305H4039,
VR8205H1003
36E24-214, 36E52-214,
36E93-304, 36E98-304
720-070 (72000IPER-S7C),
720-071 (72000IPER-S7C),
720-072 (72000IPER-S7C),
720-073 (72000IPER-LP-S7C)
VR8345M4302 VR8204A1201, VR8204A1219,
VR8204A2001, VR8204A2175,
VR8204A2803, VR8204M1075,
VR8205A2008, VR8205M1106,
VR8205M2310, VR8205M2443,
VR8304M3509, VR8304M4002,
VR8304M4507, VR8305M3506,
VR8305M4066, VR8305M4165,
VR8305M4231
36C68-423, 36C74-413,
36E01-204, 36E01-205,
36E01-206, 36E01-305,
36E22-214, 36E36-304,
36E93-304, 36G22-214,
36J22-214
720-051 (7200DER),
720-079 (7200IPER),
720-080 (7200IPER-LP),
722-051 (2000DERHC),
722-079 (2000IPERHC)
VR8345Q4563 VR8205Q2381, VR8205Q2555,
VR8205Q2662, VR8205Q2746,
VR8205Q2787, VR8305Q4453,
VR8304Q4511, VR8305Q4138,
VR8305Q4146, VR8305Q4500
36C76-406, 36C76-420,
36C76-463, 36D13-208,
36D13-405, 36E54-214,
36E96-314, 36G54-214
720-082 (7200IPER2-4)