Instruction Manual Counter Showcase Models HNC-120BA-L/R-S HNC-150BA-L/R-S HNC-180BA-L/R-S HNC-210BA-L/R-S hoshizakiamerica.
WARNING Only qualified service technicians should install and service the appliance. To obtain the name and phone number of your local Hoshizaki Certified Service Representative, visit www.hoshizaki.com. No installation or service should be undertaken until the technician has thoroughly read this Instruction Manual. Likewise, the owner/manager should not proceed to operate the appliance until the installer has instructed them on its proper operation.
IMPORTANT This manual should be read carefully before the appliance is installed and operated. Read the warnings and guidelines contained in this manual carefully as they provide essential information for the continued safe use and maintenance of the appliance. Retain this manual for any further reference that may be necessary. CONTENTS PAGE Important Safety Information ----------------------------------------------------------------------------- 3 I.
Important Safety Information Throughout this manual, notices appear to bring your attention to situations which could result in death, serious injury, damage to the appliance, or damage to property. WARNING Indicates a hazardous situation which could result in death or serious injury. AVERTISSEMENT Signale une situation dangereuse qui peut entraîner des blessures graves voire mortelles. NOTICE Indicates a situation which could result in damage to the appliance or property.
I. General Information A. Construction Plug* Condenser Nameplate Joint Power Switch (Ground Fault Circuit Interrupter) Air Filter Slider Louver Sliding Glass Door Food Mount *Note: Always attach the plug(s) to the drain holes located in the showcase. Fig.
II. Installation and Operating Instructions A. Checks Before Installation * Visually inspect the exterior of the shipping container, and any severe damage noted should be reported to the carrier. NOTICE Remove shipping carton, evaporator spacer, tape and packing material. If packing material is left in the showcase, it will not work properly. IMPORTANT Remove shipping tape holding the door. * Remove the package containing accessories.
If the foundation is not firm enough, it may warp and cause some space between its center and the showcase bottom. In this case, provide a support to keep the foundation level. No good Good Support * Avoid a site where dripping is not allowed. Fig. 3 * Do not expose the showcase to direct sunlight or higher temperatures to prevent damage to the plastic housing. Adding additional heat will also affect showcase operating temperatures.
1) Unpack the showcase, and remove the shipping carton, evaporator spacer, tape and packing material BEFORE operating the unit. Be careful not to damage the exterior panels when handling the showcase. 2) Position the showcase in a selected site. Clean the interior with soap and water and rinse thoroughly. 3) Level the showcase in both the left-to-right and the front-to-rear directions. 4) The perimeter where the machine touches the counter should be sealed with silicone. D.
F.
IMPORTANT • The showcase is intended to display sushi materials and keep them cool during business hours. The showcase contains a large amount of glass and provides less refrigeration and cold storage capacity than ordinary refrigerators. Before displaying sushi materials, allow the showcase to operate for about 1 hour to cool down. Fully refrigerate sushi materials in a refrigerator prior to displaying them in the showcase.
III. Maintenance and Cleaning Instructions WARNING Before carrying out any cleaning or maintenance operations, unplug the showcase. AVERTISSEMENT Avant toute opération de maintenance ou de nettoyage, débranchez la vitrine. NOTICE • Do not disassemble the showcase further than illustrated in Fig. 1. • Do not touch or wet the machine compartment parts. This could result in failure or breakdown. A. Interior/Exterior * Clean the interior and food mounts every day for sanitary use.
C. Air Filter A plastic mesh air filter removes dirt or dust from the air, and keeps the condenser from getting clogged. If the filter gets clogged, the showcase’s performance will be reduced. Check the filter at least twice a month. When clogged, use warm water and a neutral cleaner to wash the filter. Louver 1) Hold the tabs located at the bottom of the louver, and lift them up to release the louver from the body. 2) Pull the louver toward you. 3) Pull the louver downward.
618 Hwy. 74 South, Peachtree City, GA 30269 USA (P) 770.487.2331 (F) 770.487.3360 hoshizakiamerica.
