Use and Care Manual

ManualsBrandsHTP ManualsHeating, Ventilation, and Air ConditioningElite FT Gas Heating Water Boiler with 80,000 BTU

120 Braley Rd. P.O. Box 429 East Freetown, MA 02717-0429 www.htproducts.com

LP-390 REV. 4.19.13

Elite FT

USER’S INFORMATION

MANUAL

Elite FT Models

EFT-55 / 80 / 110 / 155 / 199 / 285 / 399

NOTICE: HTP reserves the right to make product changes or updates without notice and will not be held liable for typographical errors

in literature.

NOTE TO CONSUMER: PLEASE KEEP ALL INSTRUCTIONS FOR FUTURE REFERENCE.

IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING

PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. DO NOT STORE GASOLINE OR OTHER FLAMMABLE VAPORS

AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER BOILER.

WHAT TO DO IF YOU SMELL GAS

 Do not try to light any boiler.

 Do not touch any electrical switch.

 Do not use any phone in your building.

 Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

 If you cannot reach your gas supplier, call the fire department. Installation and service must be provided by a qualified installer,

service agency, or the gas supplier.

Summary of content (8 pages)

PAGE 1
Elite FT USER’S INFORMATION MANUAL Elite FT Models EFT-55 / 80 / 110 / 155 / 199 / 285 / 399 NOTICE: HTP reserves the right to make product changes or updates without notice and will not be held liable for typographical errors in literature. NOTE TO CONSUMER: PLEASE KEEP ALL INSTRUCTIONS FOR FUTURE REFERENCE. IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE.
PAGE 2
PAGE 3
The following defined terms are used throughout this manual to bring attention to the presence of hazards of various risk levels, or to important product information. DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
PAGE 4
TABLE OF CONTENTS PART 1 – PRODUCT AND SAFETY INFORMATION ............................................................................................................................... 4 A. BOILER OPERATION ........................................................................................................................................................................ 4 B. PRIMARY WATER .................................................................................................................
PAGE 5
PART 2 – COMBUSTION AIR – CONTAMINATION PREVENTION Do not operate the boiler if its combustion air intake is located in or near one of the areas or in the vicinity of products listed in Table 1. These areas will always contain hazardous contaminates that can form strong acids while passing through the burner and vent system.
PAGE 6
  Check and remove any blockage from the outdoor exhaust vent and intake pipe terminations. DO NOT perform this maintenance if exhaust vent and intake pipe terminations are in difficult to reach locations. Check the temperature/pressure gauge. Monthly  Check exhaust vent and intake piping.  Check exhaust vent and intake pipe bracing. Ensure bracing is undamaged and in good condition.  Check the pressure relief valve.  Check the condensate drain system.
PAGE 7
Failure to inspect the venting system and have it repaired by a qualified service technician can result in vent system failure, causing severe personal injury or death. Visually inspect the intake piping for any signs of blockage. Inspect the entire length of the intake pipe to ensure piping is intact and all joints are properly sealed. Inspect the intake pipe bracing. Ensure bracing is undamaged and in good condition. Notify a qualified service technician if any problems are found.
PAGE 8
MAINTENANCE NOTES LP-390 Rev. 4.19.