Owner’s Manual ROTARY LAWN MOWER 6.75 Horsepower Power-Propelled 22" Multi-Cut Model No. 917.375810 CAUTION: Read and follow all Safety Rules and Instructions before operating this equipment Husqvarna, Charlotte, NC 28269 U.S.A. Visit our website: www.husqvarna.
TABLE OF CONTENTS Warranty ...................................................2 Safety Rules ..........................................2-4 Product Specifications ..............................5 Assembly / Pre-Operation ........................6 Operation.............................................7-11 Maintenance Schedule ...........................11 Maintenance ......................................11-14 Service and Adjustments...................14-16 Storage ............................................
DO: • Mow across the face of slopes: never up and down. Exercise extreme caution when changing direction on slopes. • Remove obstacles such as rocks, tree limbs, etc. • Watch for holes, ruts, or bumps. Tall grass can hide obstacles. DO NOT: • Do not trim near drop-offs, ditches or embankments. The operator could lose footing or balance. • Do not trim excessively steep slopes. • Do not mow on wet grass. Reduced footing could cause slipping. • • • • III.
WARRANTY SECTION 1: LIMITED WARRANTY Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original purchaser to be free from defects in material and workmanship from the date of purchase for the “Warranty Period” of the product as set forth below: (4) Additional damage to parts or components due to continued use occurring after any of the above. REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER.
PRODUCT SPECIFICATIONS Serial Number: Date of Purchase: Gasoline Capacity / Type: 1.6 Quarts (Unleaded Regular) Oil Type (API SG–SL): SAE 30 (above 32°F); SAE 5W-30 (below 32°F) Oil Capacity: 20 Ounces Spark Plug (Gap: .030") Champion J19LM or RJ19LM Blade Bolt Torque: 35-40 ft. lbs. • The model and serial numbers will be found on a decal on the rear of the lawn mower housing. Record both serial number and date of purchase in space provided above.
ASSEMBLY / PRE-OPERATION Read these instructions and this manual in its entirety before you attempt to assemble or operate your new lawn mower. IMPORTANT: This lawn mower is shipped WITHOUT OIL OR GASOLINE in the engine. Your new lawn mower has been assembled at the factory with the exception of those parts left unassembled for shipping pur poses. To ensure safe and proper operation of your lawn mower, all parts and hardware you assemble must be tightened securely.
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product. Learn and understand their meaning.
The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or performing any adjustments or repairs. We recommend a standard safety glasses or wide vision safety mask worn over spectacles. HOW TO USE YOUR LAWN MOWER ENGINE SPEED The engine speed was set at the factory for optimum performance. Speed is not adjustable.
Discharge deflector Mulcher plug SIDE DISCHARGING • Mulcher plug must be installed into rear discharge opening of mower. • Open mulcher door and install discharge deflector under door as shown. • Mower is now ready for discharging operation. • To convert to mulching or bagging operation, discharge deflector must be removed and mulcher door closed. SIMPLE STEPS TO REMEMBER WHEN CONVERTING YOUR LAWN MOWER FOR MULCHING 1. Rear mulcher plug installed. 2. Mulcher door closed. FOR REAR BAGGING 1.
NOTE: Initial oil fill requires only 18 oz. due to residual oil in engine from the manufacturers 100% quality testing. When changing oil you may need 20 oz. 4. Insert and tighten dipstick. IMPORTANT: • Check oil level before each use. Add oil if needed. Fill to full line on dipstick. • Change the oil after every 25 hours of operation or each season. You may need to change the oil more often under dusty, dirty conditions. See “TO CHANGE ENGINE OIL” in the Maintenance section of this manual.
cut to reduce pushing effort and to keep from overloading the engine and leaving clumps of mulched grass. For extremely heavy grass, reduce your width of cut by overlapping previously cut path and mow slowly. • Certain types of grass and grass conditions may require that an area be mulched a second time to completely hide the clippings. When doing a second cut, mow across (perpendicular) to the first cut path.
GENERAL RECOMMENDATIONS LAWN MOWER The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain unit as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your unit. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual.
4. Use block of wood between blade and lawn mower housing and tighten the blade bolt, turning clockwise. • The recommended tightening torque is 35-40 ft. lbs. IMPORTANT: Blade bolt is heat treated. If bolt needs replacing, replace only with approved bolt shown in the Repair Parts section of this manual. Blade adapter Key Crankshaft keyway LUBRICATION Use only high quality detergent oil rated with API service classification SG–SL.
7. Continue adding small amounts of oil, rechecking the dipstick until oil level settles at FULL. DO NOT overfill, or engine will smoke heavily from the muffler on startup. 8. Always be sure to retighten oil dipstick before starting engine. 9. Reconnect spark plug wire to spark plug. AIR FILTER Your engine will not run properly and may be damaged by using a dirty air filter. Replace the air filter cartridge every 100 hours of operation or every season, whichever occurs first.
TO REMOVE DRIVE BELT 1. Remove drive cover and belt keeper. 2. Remove belt from gearcase pulley by pushing down on pulley and rolling belt off it. 3. Turn lawn mower on its side with air filter and carburetor down. 4. Remove blade and debris shield. 5. Remove belt from engine pulley on crankshaft. TO REPLACE DRIVE BELT 1. Place new drive belt in the belt retainers of the debris shield. 2. Route the other end of the new drive belt through hole in housing. 3. Reinstall debris shield and blade. 4.
ENGINE your lawn mower to a Husqvarna or other qualified service center for repair and/or adjustment. IMPORTANT: Never tamper with the engine governor, which is factory set for proper engine speed. Overspeeding the engine above the factory high speed setting can be dangerous. If you think the engine-governed high speed needs adjusting, contact a Husqvarna or other qualified service center, which has proper equipment and experience to make any necessary adjustments.
gum deposits during storage. Add stabilizer to gasoline in fuel tank or storage container. Always follow the mix ratio found on stabilizer container. Run engine at least 10 minutes after adding stabilizer to allow the stabilizer to reach the carburetor. Do not empty the gas tank and carburetor if using fuel stabilizer. ENGINE OIL Drain oil (with engine warm) and replace with clean engine oil. (See “ENGINE” in the Maintenance section of this manual). CYLINDER 1. Remove spark plug. 2.
TROUBLESHOOTING - See appropriate section in manual unless directed to a Husqvarna or other qualified service center. PROBLEM Loss of power Poor cut – uneven CAUSE CORRECTION 1. Rear of mower housing or blade dragging in grass. 2. Cutting too much grass. 3. Dirty air filter. 4. Buildup of grass, leaves, and trash under mower. 5. Too much oil in engine. 6. Walking speed too fast. 1. Worn, bent or loose blade. 2. Wheel heights uneven. 3. Buildup of grass, leaves and trash under mower.
HUSQVARNA ROTARY LAWN MOWER - - MODEL NUMBER 917.
HUSQVARNA ROTARY LAWN MOWER - - MODEL NUMBER 917.375810 KEY NO. PART NO.
HUSQVARNA ROTARY LAWN MOWER - - MODEL NUMBER 917.
HUSQVARNA ROTARY LAWN MOWER - - MODEL NUMBER 917.375810 KEY NO. 39 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 25 26 27 28 29 32 33 35 PART NO.
BRIGGS & STRATTON 4-CYCLE ENGINE 584 MODEL NUMBER 125K02-0654-E1 684 1 54 847 287 523 2 50 3 51 842 585 869 383 525 870 337 524 7 635 871 718 5 11 45 868 13 306 40 16 45 35 40 34 36 24 33 25 27 307 8 29 741 32 9 32A 26 10 28 27 4 12 46 43 15 20 40 22
BRIGGS & STRATTON 4-CYCLE ENGINE 966 425 MODEL NUMBER 125K02-0654-E1 977 CARBURETOR GASKET SET 222 443 621 968 163 137 529 163 668 633 617 188 976 365 445 121 CARBURETOR OVERHAUL KIT 134 125 134 97 633 163 133 104 617 137 104 163 633 127 276 975 137 227 333 334 562 851 127 745 276 130 95 617 505 117 276 118 276 356 615 404 923 922 621 209 616 202 358 ENGINE GASKET SET 3 20 12 842 524 668 7 163 585 51 617 41 48
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 125K02-0654-E1 969 300 921 564 304 78 604 37 81 613 363 305 187 1059 190 608 65 55 592 601 670 972 58 957 1211 459 689 60 1210 456 23 597 332 455 1058 OWNER’S MANUAL 1330 REPAIR MANUAL KEY NO. 1 2 3 4 5 7 8 9 10 11 12 13 15 16 20 22 23 24 25 PART NO.
BRIGGS & STRATTON 4-CYCLE ENGINE KEY NO. 81 95 97 104 117 118 121 125 127 130 133 134 137 163 187 188 190 202 209 222 227 276 287 300 304 305 306 307 332 333 334 337 356 358 363 365 383 404 425 443 445 455 456 459 505 523 524 525 529 562 564 584 585 PART NO.
SERVICE NOTES
Get it fixed, at your home or ours! Your Home For repair – in your home – of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner’s manuals that you need to do-it-yourself. For Sears professional installation of home appliances and items like garage door openers and water heaters. 1-800-4-MY-HOME® (1-800-469-4663) www.sears.com Anytime, day or night (U.S.A. and Canada) www.sears.