Rev.
Q1-DC-0508 General Instructions Table of Contents General Instructions.....................................................2 Cut and Plan Views.......................................................3 Installation......................................................................3 This Booklet Contains Information on: Q1-DC refrigerated, service deli merchandiser. Shipping Damage All equipment should be thoroughly examined for shipping damage before and during unloading.
Rev. 0508 Cut and Plan Views 55 4' STRAIGHT 6 1/8" DRAIN 16 4 3/8" 9 3/4" 45" 2" 6 1/4" 16 " REF. DROP 44 7/ REF. DROP 14" 17 1/ 8" 13 3/8" /8" 48" 21 8" 29 3/8" 1/ " 28" 45° O/S " DRAIN 39 1 11" 1/2 45° I/S 1/ 8 27 Drain 5" from Center LIne 45" REF.
Q1-DC-0508 Installation (Cont'd) 5. Apply liberal bead of case joint sealant (butyl) to first case. Sealant area is shown using a dotted line in illustration in Step 8. Apply heavy amount to cover entire shaded area. DO NOT USE PERMAGUM! 7. To compress butyl at joint, use two Jurgenson wood clamps. Make sure case is level from front to back and side to side on inside bulkheads at joint. 8. Attach sections together via the bolts pictured in the illustration below. 9.
Rev. 0508 Plumbing Waste Outlet and P-TRAP The waste outlet is located off the center of the case on one side allowing drip piping to be run lengthwise under the fixture. A 1-1/2” P-TRAP and threaded adapter are supplied with each fixture. The P-TRAP must be installed to prevent air leakage and insect entrance into the fixture. 3. Always provide as much down hill slope (“fall”) as possible; 1/8” per foot is the preferred minimum.
Q1-DC-0508 Refrigeration (Cont'd) Electronic Expansion Valve (Optional) A wide variety of electronic expansion valves and case controllers can be utilized. Please refer to EEV and controller Hussmann’s information sheet. Sensors for electronic expansion valves will be installed on the coil inlet, coil outlet, and in the discharge air. (Some supermarkets require a 4th sensor in the return air). Case controllers will be located in the electrical raceway or under the case.
Rev. 0508 Electrical (Cont'd) Wiring and Serial Plate Amperage Field Wiring must be sized for component amperes stamped on the serial plate. Actual ampere draw may be less than specified. Field wiring from the refrigeration control panel to the merchandisers is required for refrigeration thermostats. Case amperes are listed on the wiring diagram, but always check the serial plate.
Q1-DC-0508 User Information (Cont'd) Case Cleaning Long life and satisfactory performance of any equipment are dependent upon the care given to it. To insure long life, proper sanitation and minimum maintenance costs, the refrigerator should be thoroughly cleaned frequently. SHUT OFF FAN DURING CLEANING PROCESS. It can be unplugged within the case, or shut off entire case at the source. The interior bottom may be cleaned with any domestic soap or detergent based cleaners.
Rev. 0508 User Information (Cont'd) Non-Glare Glass The high optical clarity of this glass is possible due to special coatings on the glass surface itself. To preserve this coating and the optical clarity, keep the glass clean. Water is the only solution recommended for use in cleaning non-glare glass. The damage to the glass from improper, caustic solutions is irreparable.
Q1-DC-0508 Maintenance Evaporator Fans The evaporator fans are located at the center front of these merchandisers directly beneath the display pans. Should fans or blades need servicing, always replace fan blades with the raised embossed side of the blade TOWARD THE MOTOR. FOR PROMPT SERVICEHave case Model and Serial Numberready! This information is located on thenameplate of the unit. Coils The copper coils used in Hussmann merchandisers may be repaired in the field.
Rev.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 L F28T5-48" 125-03-1132 LEDGE LIGHT (OPTIONAL) T-STAT DELI THERMOSTAT 225-01-0707 SOLENOID 225-01-3206 SUCTION SOLENOID SENSOR CPC 225-01-3260 OPTIONAL SENSOR DRAWN BY: D.QUAN PROJECT TITLE: Q1 DATE: 12/01/05 BY: DATE: CHECKED BY: --DRAWING TITLE: 09/21/06 D.Q.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 REVISIONS: #: DESCRIPTION: 1 2 3 NOTE: CASE MUST BE GROUNDED 13 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 F21T5-36" 125-03-1129 L F21T5-36" 125-03-1129 BALLAST 125-01-3267 FULHAM LH4-120-L F21T5-36" 125-03-1129 BALLAST 125-01-3267 FULHAM LH4-120-L DATE: ~115 VAC - 1Ø - 50/60 Hz.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 REVISIONS: #: DESCRIPTION: 1 2 3 NOTE: CASE MUST BE GROUNDED 14 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 F28T5-48" 125-03-1132 L F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L DATE: BY: ~115 VAC - 1Ø - 50/60 Hz.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 F28T5-48" 125-03-1132 L F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L ~115 VAC - 1Ø - 50/60 Hz.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 CIRCUIT #1 EVAP FAN MOTOR (1)0392457 M AIR SWEEP FAN (1)125-01-2012 M DRAWN BY: D.QUAN PROJECT TITLE: Q1 DATE: 02/02/06 BY: DATE: CHECKED BY: --DRAWING TITLE: 09/21/06 D.Q. PRODUCTION ORDER #: FILE LOCATION: F:\WIRESCHEMATICS\NEW-WIRING Q1-DC-4R THERMOSTAT 225-01-0707 SOLENOID 225-01-3202 SUCTION SOLENOID T-STAT ~115 VAC - 1Ø - 50/60 Hz.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G F35T5-60" 125-03-1135 ~115 VAC - 1Ø - 50/60 Hz. L REVISIONS: #: DESCRIPTION: 1 2 3 CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 CAP OFF WIRE LEDGE LIGHT OPTIONAL F35T5-60" 125-03-1135 CANOPY LIGHT F35T5-60" 125-03-1135 LIGHT SWITCH TIPPETTE 125-01-0311 NOTE: CASE MUST BE GROUNDED LOADING 115 V L1 3.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G F21T5-36" 125-03-1129 DATE: 02/02/06 ~115 VAC - 1Ø - 50/60 Hz. L LIGHT SWITCH TIPPETTE 125-01-0311 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 CIRCUIT #1 REVISIONS: #: DESCRIPTION: 1 UPDATE-02/02/06 2 3 NOTE: CASE MUST BE GROUNDED F21T5-36" 125-03-1129 CANOPY LIGHT F21T5-36" 125-03-1129 BALLAST 125-01-3266 FULHAM LH3-120-L LOADING 115 V L1 3.3 #.# L2 #.# #.# #.# L3 #.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 ~115 VAC - 1Ø - 50/60 Hz. L LIGHT SWITCH TIPPETTE 125-01-0311 F28T5-48" 125-03-1132 REVISIONS: #: DESCRIPTION: 1 UPDATE-02/02/06 2 REVISED BALLAST TO LH-4 (ECN=10662) 3 NOTE: CASE MUST BE GROUNDED F28T5-48" 125-03-1132 CANOPY LIGHT F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L LOADING 115 V L1 3.6 #.# L2 #.# #.# L3 #.# #.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 L1 L2 L3 N G CIRCUIT #1 15 AMP FUSE 125-01-3282 FUSE HOLDER 125-01-3283 ~115 VAC - 1Ø - 50/60 Hz. L LIGHT SWITCH TIPPETTE 125-01-0311 REVISIONS: #: DESCRIPTION: 1 ADDED Q1-DC-9R 2 ADDED ADDITION AIR SWEEP MOTORS 3 REVISED BALLAST (ECN=10658) NOTE: CASE MUST BE GROUNDED LOADING 115 V L1 6.
HUSSMANN CORPORATION 13770 RAMONA AVENUE CHINO, CA.91710 (909) 590-4910 LIC.#: 644406 F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L ~115 VAC - 1Ø - 50/60 Hz.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? L1 N L 5/10/07 A Updated dwg; removed ballast fuse DATE: MCA= .66A MOP= 15A ~120 VAC - 60 Hz.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? L1 N L 5/10/07 A Updated dwg; removed ballast fuse DATE: ~120 VAC - 60 Hz. MCA= .
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? (TWO MAXIMUM) G BK L1 N L 5/10/07 Updated dwg; removed ballast fuse A M ~120 VAC - 60 Hz. MCA= 8.4A MOP= 15A ~120 VAC - 60 Hz. MCA= .83A MOP= 15A R Q1-DC-5S/Q1-DS-5S * C ** AIR TEMP. DRAWING #: BUNDLE BLUE LABELED CONDENSING UNIT CIRCUIT PAGE 3 OF 11 W1750034-03 TECUMSEH HGA9430YXAXB 115VAC, 60HZ 225-03-0100 765 4321 PROD. TEMP. CONDENSING UNIT RLA= 6.7A MCC= 10.5A LRA= 45.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? (TWO MAXIMUM) G BK L1 N L F21T5-36" 125-03-1129 5/10/07 A Updated dwg; removed ballast fuse DATE: ~120 VAC - 60 Hz. MCA= 1.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? L1 N F28T5-48" 125-03-1132 L F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L 5/10/07 Updated dwg; removed ballast fuse A L1 N M M L1 N Q1-DC-7S/Q1-DS-7S SAFETY SWITCH FLOAT SWITCH R * C ** AIR TEMP. DRAWING #: BUNDLE BLUE LABELED CONDENSING UNIT CIRCUIT PAGE 5 OF 11 W1750034-05 TECUMSEH HGA9443YXAXB 115VAC, 60HZ 225-03-0104 765 4321 PROD. TEMP.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? (TWO MAXIMUM) G BK L1 N L F28T5-48" 125-03-1132 5/10/07 A Updated dwg; removed ballast fuse DATE: ~120 VAC - 60 Hz. MCA= 1.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 (TWO MAXIMUM) ? G BK L1 N L F35T5-60" 125-03-1135 5/10/07 A Updated dwg; removed ballast fuse CANOPY LIGHT BLACK # 14 BUNDLE BROWN LABELED FAN CIRCUIT M M M M R Q1-DC-9S/Q1-DS-9S C ** DRAWING #: PAGE 7 OF 11 W1750034-07 TECUMSEH HGA9443YXAXB 115VAC, 60HZ 225-03-0104 765 4321 OMNI STAT PN 952896-120VAC AIR TEMP. CONDENSING UNIT RLA= 9.6A MCC= 15.0A * PROD. TEMP.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ? (TWO MAXIMUM) G BK N L 5/10/07 A Updated dwg; removed ballast fuse LEDGE LIGHT (OPTIONAL) M M M SAFETY SWITCH Q1-DC-10S/Q1-DS-10S C TECUMSEH HGA9462ZXDXM 208VAC, 60HZ 225-03-0101 ** DRAWING #: BUNDLE BLUE LABELED CONDENSING UNIT CIRCUIT Q1-DC-XS Q1-DC-XS/Q1-DS-XS MCA= 7.8A MOP= 15A * AIR TEMP. 765 4321 PROD. TEMP.
N F28T5-48" 125-03-1132 L Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.
Hussmann Corporation, Int'l. 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 (TWO MAXIMUM) ? G BK N F28T5-48" 125-03-1132 L F28T5-48" 125-03-1132 BALLAST 125-01-3267 FULHAM LH4-120-L F28T5-48" 125-03-1132 F28T5-48" 125-03-1132 5/10/07 Updated dwg; removed ballast fuse A BALLAST 125-01-3267 FULHAM LH4-120-L DATE: ~120 VAC - 60 Hz. MCA= 2.
Q1-DC-0508 Appendices 1.3 A clogged waste outlet blocks refrigeration. The installer is responsible for the proper installation of the system which dispenses condensate waste through an air gap into the building indirect waste system. 1.
Rev. 0508 Appendices (Cont'd) 7. Are there unusual draft conditions (from heating/air-conditioning ducts, open doors, etc.)? 8. Is there exposure to direct sunlight? 9. Are display signs blocking or diverting airflow? 10. Are the coils of the refrigerator iced up? 11. Is the store ambient over 75°F, 55% RH as set forth in ASHRAE Standard 72 and ASHRAE Standard 117? 12. Are the shelf positions, number, and size other than recommended by Hussmann? 13.
Q1-DC-0508 Appendices (Cont'd) 1.1 Cleaning of non frozen food equipment d) Care must be taken when cross should include a weekly cleaning of the food merchandising products to ensure that compartment as a minimum to prevent bacteria potentially hazardous vegetable products are growth from accumulating. Actual use and not placed in non refrigerated areas. products may dictate more frequent cleaning.
Q1-DC-0508 Service Record Last service date: By: _______________ ___________________________________________________________________________________________________ _______________ ___________________________________________________________________________________________________ _______________ ___________________________________________________________________________________________________ _______________ ________________________________________________________________________________
