RGSSFP Rev.
IGFP-RGSSFP-0008 General Instructions THIS BOOKLET CONTAINS INFORMATION ON: RGSSFP Table of Contents The RGSSFP is a food prep case with refrigerated selfservice merchandising in the front, and hot and/or cold food prep area on top. Its large food prep counter makes for easy working and cleaning. General Instructions ................................................. 2 Cut & Plan Views ....................................................... 3 Installation .................................................
Rev.0008 HUSSMANN CHINO PRODUCT CONTROL Product temperature should always be maintained at a constant and proper temperature. This means that from the time the product is received, through storage, preparation and display, the temperature of the product must be controlled to maximize life of the product. The serial number and shipping date of all equipment has been recorded in Hussmann’s files for warranty and replacement part purposes.
IGFP-RGSSFP-0008 INSTALLING CONDENSATE DRAIN REFRIGERATION LINES LIQUID SUCTION Poorly or improperly installed condensate drains can seriously interfere with the operation of this refrigerator, and result in costly maintenance and product losses. Please follow the recommendations listed below when installing condensate drains to insure a proper installation: 1. Never use pipe for condensate drains smaller than the nominal diameter of the pipe or P-trap supplied with the case. 2.
Rev.0008 EXPANSION VALVE ADJUSTMENT Electrical Expansion valves must be adjusted to fully feed the evaporator. Before attempting any adjustments, make sure the evaporator is either clear or very lightly covered with frost, and that the fixture is within 10°F of its expected operating temperature. WIRING COLOR CODE Self Contained cases are wired using a terminal block.
IGFP-RGSSFP-0008 specified. Field wiring from the refrigeration control panel to the merchandisers is required for refrigeration thermostats. Most component amperes are listed in the “Case Specs” section, but always check the serial plate. mum visibility and product life at the factory.The use of higher output fluorescent lamps (H.O. and V.H.O.), will shorten the shelf life of the product. IMPORTANT STEPS 1. Do not set temperature too cold, as this causes product dehydration.
Rev.0008 Ammonia. Soap and hot water are not enough to kill this bacteria. A sanitizing solution must be included with each cleaning process to eliminate this bacteria. 1. Allow cases to come to room temperature 2. Scrub thoroughly, cleaning all surfaces, with soap and hot water. 3. Rinse with hot water, but do not flood. 4. Apply the sanitizing solution according to the manufacturer’s directions. 5. Rinse thoroughly. 6. Dry completely before resuming operation.
IGFP-RGSSFP-0008 Maintenance ELECTRICAL PRECAUTIONS BEFORE SERVICING – Always disconnect electrical power at the main disconnect when servicing or replacing any electrical component This includes (but not limited to) Fans, Heaters, Thermostats, and Lights. REPLACING FLUORESCENT LAMPS Fluorescent lamps are furnished with a shatterproof protective coating. The same type of lamp with protective coating must be used if replaced.
200 650 175 200 650 175 200 650 Refrigerated Dome 6' Deli Refrig. Rear storage Refrigerated Dome 8' Deli Refrig.
Hussmann Corporation, Int'l. 13770 Ramona Avenue, Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ~115 VAC / 50-60 Hz. ORANGE LIGHT SWITCH Revisions: No. Description: BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L FP28T5 / 830 FP28T5 / 830 FP28T5 / 830 F32T8 / SPX30 Date: ~115 VAC / 50-60 Hz. By: S T-STAT Project Title: RGSSFP CASE 4' CASE WIRING DIAGRAM Drawing Title: BROWN Drawing No.: Sheet 1 of 1 W3500001 ~115 VAC / 50-60 Hz.
Hussmann Corporation, Int'l. 13770 Ramona Avenue, Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ~115 VAC / 50-60 Hz. ORANGE LIGHT SWITCH Revisions: No. Description: BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L Date: ~115 VAC / 50-60 Hz. By: S T-STAT M M REAR STORAGE COIL BOHN VA-012-0 RGSSFP CASE BROWN Drawing No.: Sheet 1 of 1 W3500002 ~115 VAC / 50-60 Hz.
Hussmann Corporation, Int'l. 13770 Ramona Avenue, Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ~115 VAC / 50-60 Hz. ORANGE LIGHT SWITCH Revisions: No. Description: BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L Date: ~115 VAC / 50-60 Hz. By: S T-STAT M M REAR STORAGE COIL BOHN VA-012-0 RGSSFP CASE BROWN Drawing No.: Sheet 1 of 1 W3500003 ~115 VAC / 50-60 Hz.
Hussmann Corporation, Int'l. 13770 Ramona Avenue, Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 ~115 VAC / 50-60 Hz. ORANGE LIGHT SWITCH Revisions: No. Description: BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH3-120-L BALLAST FULHAM WH5-120-L CAP UNUSED Date: ~115 VAC / 50-60 Hz. By: S T-STAT M M REAR STORAGE COIL BOHN VA-012-0 RGSSFP CASE M BROWN Drawing No.
IGFP-RGSSFP-0008 14
Rev.0008 Appendices insulated according to the manufacturer’s recommendations. 1.3 A clogged waste outlet blocks refrigeration. The installer is responsible for the proper installation of the system which dispenses condensate waste through an air gap into the building indirect waste system. 1.
IGFP-RGSSFP-0008 only in Fahrenheit shall be accurate to 2°F. The thermometer should be checked for proper calibration. (It should read 32°F when the stem is immersed in an ice water bath). b) LOCATION – The probe or sensing element of the thermometer should be located in the airstream where the air first enters the display or storage area, and not more than 1 inch away from the surface and in the center of the discharge opening.
Rev.0008 Limited Warranty This warranty is made to the original user at the original installation site and is not transferable. Hussmann merchandisers are warranted to be free from defect in material and workmanship under normal use and service for a period of one (1) year from the date of original installation (not to exceed fifteen (15) months from the date of shipment for the factory). Hussmann Impact Modular Coils are warranted for a total of five (5) years based upon the above criteria.
IGFP-RGSSFP-0008 Service Record Last service date: By: /Chino The MODEL NAME and SERIAL NUMBER is required in order to provide you with the correct parts and information for your particular unit. Additional copies of this publication may be obtained by contacting: Hussmann® Chino 13770 Ramona Avenue • Chino, California 91710 (909) 628-8942 FAX (909) 590-4910 (800) 395-9229 They can be found on a small metal plate on the unit. Please note them below for future reference.