User Guide

ManualsBrandsHustler ManualsOther766238

•••••••

Hustler Turf Equipment

•••••

P.O. Box 7000

•••

Hesston, Kansas

•

67062-2097

Hustler 4500/4600

Parts Manual

766238 Rev. 8/06

Summary of content (180 pages)

PAGE 1
Hustler 4500/4600 Parts Manual ••••••• Hustler Turf Equipment ••••• P.O. Box 7000 ••• Hesston, Kansas 766238 Rev.
PAGE 2
WARNING: The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. IMPORTANT: This engine is not equipped with a spark arrester muffler. It is a violation of California Public Resource Code Section 4442 to use or operate this engine on any forest-covered, brush-covered, or grass-covered unimproved land. Other states or federal areas may have similar laws. This spark ignition system complies with Canadian ICES-002.
PAGE 3
Table of Contents Chapter 1 General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Chapter 2 Contents Footrest Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Frame Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Frame Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Sub-Frame Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 4
Cooling System - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Cooling System - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Chapter 11 Contents Oil Cooler Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Oil Cooler Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Chapter 12 Contents Hydraulic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 5
Chapter 1 General Information This manual covers Tractor Models:4500 (924738) & 4600 (925008) Frequently Ordered Parts PART NO. 027912 076919 032029 065730 033779 DESCRIPTION LUBRIZOL 7 OZ.
PAGE 6
Hardware Description Codes & Abbreviations The following codes are used throughout this parts manual. Refer to this list when ordering parts. ABBREVIATION DESCRIPTION CB CE CP CS CW FW HX LW MB MS NT SC SB SS Carriage Bolt Clevis Pin Cotter Pin Cap Screw Cup Washer Flat Washer Hex Head Lock Washer Machine Bushing Machine Screw Nut Self Tapping Cap Screw Shoulder Bolt Set Screw Standard Torques The following chart lists the standard torque values for the threaded fasteners found in this manual.
PAGE 7
Chapter 2 Contents Footrest Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2 Frame Assembly - 4500. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 Frame Assembly - 4600. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-6 Sub-Frame Assemblies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8 Sub-Frame Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 8
Footrest Assembly 22 21 1 23 6 7 8 5 1 3 4 2 1 10 3 20 11 16 19 17 11 12 13 13 2 20 15 17 7 18 9 12 Main Frame Assembly 2-2 14 766238 8/06
PAGE 9
Footrest Assembly INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 306811 306811 1 SEAT MOUNT 2 307066 307066 1 LATCH PIN 3 075408 075408 1 FW .402 X .689 X .032 ZN 4 002261 002261 1 SPRING 5 082420 082420 1 ROLL PIN .125D X .875 LG ZN 6 055947 055947 4 CS .25-20 X .50 HX G5 ZN 7 017038 017038 12 LW .250 MEDIUM SPRING ZN 8 017079 017079 4 FW .250 X .560 X .
PAGE 10
Frame Assembly - 4500 2 1 3 4 FOOTREST 7 1 9 8 3 5 6 16 17 12 15 14 13 8 24 11 9 23 10 8 20 19 18 See Detail A 20 19 24 2 21 22 2 23 2 23 Detail A 2-4 766238 8/06
PAGE 11
Frame Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 383141 383141 1 MAIN FRAME 2 077859 077859 2 CS .50-13 X 3.250 HX G5 ZN 3 017137 017137 4 FW .560 X 1.370 X .109 SAE ZN 4 248237 248237 1 REAR CROSS MEMBER 5 017046 017046 2 LW .50 MEDIUM SPRING ZN 6 067918 067918 2 NT .50-13 HX G8 ZN 7 034280 034280 2 CS .312-18 X .750 HX G5 ZN 8 017004 017004 6 LW .312 MEDIUM SPRING ZN DESCRIPTION 9 076547 076547 6 FW .344 X .688 X .
PAGE 12
Frame Assembly - 4600 2 1 3 1 4 FOOTREST 9 8 7 3 5 6 12 15 14 13 21 8 21 11 9 22 10 2 8 20 18 17 16 18 17 2-6 19 23 766238 8/06
PAGE 13
Frame Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 383141 383141 1 MAIN FRAME 2 077859 077859 2 CS .50-13 X 3.250 HX G5 ZN 3 017137 017137 4 FW .560 X 1.370 X .109 SAE ZN 4 248237 248237 1 REAR CROSS MEMBER 5 017046 017046 2 LW .50 MEDIUM SPRING ZN 6 067918 067918 2 NT .50-13 HX G8 ZN 7 034280 034280 2 CS .312-18 X .750 HX G5 ZN 8 017004 017004 6 LW .312 MEDIUM SPRING ZN DESCRIPTION 9 076547 076547 6 FW .344 X .688 X .
PAGE 14
Sub-Frame Assembly - 4500 Radiator Assembly 7 2 1 5 10 9 4 1 1 14 8 3 11 8 15 9 13 22 13 14 12 24 30 9 25 26 10 23 28 13 16 27 14 29 1 17 6 9 5 18 21 1 1 19 20 4 3 4 5 1 1 1 4 3 2-8 766238 8/06
PAGE 15
Sub-Frame Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 447425 447425 1 2 460600 460600 1 TOP PUMP MOUNT 3 067918 067918 6 NT .50-13 HX G8 ZN 4 017046 017046 8 LW .50 MEDIUM SPRING ZN 5 017137 017137 6 FW .560 X 1.370 X .109 SAE ZN 6 016527 016527 2 CS .50-13 X 1.00 HX G5 ZN 7 061812 061812 2 CS .50-13 X 3.50 HX G5 ZN 8 076992 076992 4 FW .530 X 1.750 X .
PAGE 16
Sub-Frame Assembly - 4600 Radiator Assembly 7 2 1 10 9 5 19 3 1 26 4 1 12 27 8 25 24 29 8 9 9 11 10 6 31 4 2 23 20 18 2 22 28 26 20 27 30 21 1 13 3 17 9 14 16 1 1 4 5 22 1 23 1 1 15 5 4 3 2-10 766238 8/06
PAGE 17
Sub-Frame Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 496117 496117 1 2 460600 460600 1 SUB-FRAME TOP PUMP MOUNT 3 067918 067918 6 NT .50-13 HX G8 ZN 4 017046 017046 8 LW .50 MEDIUM SPRING ZN 5 017137 017137 6 FW .560 X 1.370 X .109 SAE ZN 6 016527 016527 2 CS .50-13 X 1.00 HX G5 ZN 7 061812 061812 2 CS .50-13 X 3.50 HX G5 ZN 8 076992 076992 4 FW .530 X 1.750 X .
PAGE 18
2-12 766238 8/06
PAGE 19
Chapter 3 Contents Tool Bar Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Tool Bar Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 20
Tool Bar Assembly - 4500 1 2 2 Ground Wires 6 8 20 3 1 21 12 19 14 7 4 11 22 13 18 17 39 23 10 11 1 15 5 9 17 1 15 16 2 22 24 25 8 26 32 29 23 27 30 33 36 37 24 38 31 25 35 28 34 3-2 766238 8/06
PAGE 21
Tool Bar Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 055939 055939 2 2 025403 025403 2 FW .281 X .625 X .062 ZN 3 029868 029868 1 LW .250 INT-EXT ZN 4 017038 017038 2 LW .250 MEDIUM SPRING ZN 5 024927 024927 2 NT .25-20 HX G5 ZN 6 043570 043570 1 SINGLE HOSE CLIP 7 000174 000174 2 CE .375 X 1.250 .156 X 1.090 ZN 8 017251 017251 6 CP .156D X 1.00 LG HML ZN 9 711127 711127 2 NYLON ROLLER GUIDE 10 705178 705178 2 CS .375-16 X 1.
PAGE 22
Tool Bar Assembly - 4600 1 2 Ground Wires 7 19 3 20 11 1 18 6 10 12 21 13 17 16 38 22 9 8 1 10 1 14 14 Glow Plug Timer (Part of Engine) 4 16 5 15 1 14 21 23 7 24 25 31 28 22 23 26 29 32 35 36 37 30 24 34 27 33 3-4 766238 8/06
PAGE 23
Tool Bar Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 056077 056077 1 2 043570 043570 1 SINGLE HOSE CLIP 3 029868 029868 1 LW .250 INT-EXT ZN 4 025403 025403 1 FW .281 X .625 X .062 ZN 5 024927 024927 1 NT .25-20 HX G5 ZN DESCRIPTION CS .25-20 X 1.00 G5 ZN 6 000174 000174 2 CE .375 X 1.250 .156 X 1.090 ZN 7 017251 017251 6 CP .156D X 1.00 LG HML ZN 8 711127 711127 2 NYLON ROLLER GUIDE 9 705178 705178 2 CS .375-16 X 1.
PAGE 24
3-6 766238 8/06
PAGE 25
Chapter 4 Contents Fuel System - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2 Fuel System - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 Fender Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 26
Fuel System - 4500 2 5 4 3 6 15 1 14 3 10 8 9 10 13 11 1 12 10 5 5 4 3 6 Fuel Pump 3 4 5 5 4 7 4-2 766238 8/06
PAGE 27
Fuel System - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 385773 385773 1 2 084756 084756 1 FUEL CAP AND GAUGE 3 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 4 017004 017004 4 LW .312 MEDIUM SPRING ZN 5 070664 070664 5 FW .344 X .750 X .060 ZN 6 084921 084921 2 PIPE PLUG .125 7 034272 034272 1 NT .312-18 HX G5 ZN 8 068486 068486 1 SHUT-OFF VALVE 9 039131 039131 1 HOSE ADAPTER 10 041491 041491 4 HOSE CLAMP 11 034264 034264 2 FUEL HOSE .312 I.D.
PAGE 28
Fuel System - 4600 5 4 3 2 23 7 14 8 15 1 9 12 3 16 14 10 1 14 9 11 13 21 20 3 5 14 2 19 18 4 1 22 17 5 3 4 5 4 5 6 4-4 766238 8/06
PAGE 29
Fuel System - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 385773 385773 1 2 084756 084756 1 FUEL CAP AND GAUGE 3 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 4 017004 017004 4 LW .312 MEDIUM SPRING ZN 5 070664 070664 5 FW .344 X .750 X .060 ZN 6 034272 034272 1 NT .
PAGE 30
Fender Assembly 3 2 4 AIR SCOOP ANGLE SUPPORT 7 6 17 9 16 2 4 4 8 1 10 12 3 11 5 13 14 25 24 18 23 15 13 13 14 20 19 15 14 22 23 23 21 24 25 4-6 766238 8/06
PAGE 31
Fender Assembly INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 459578 459578 1 2 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 3 017004 017004 4 LW .312 MEDIUM SPRING ZN 4 070664 070664 5 FW .344 X .750 X .060 ZN 5 034272 034272 1 NT .312-18 HX G5 ZN 6 033035 033035 1 TOP SEAL .12 X .75 X 18.5” 7 033035 033035 2 SIDE SEAL .12 X .75 X 13” 8 037374 037374 2 GROMMET .50 X 1.060 X .810 X .
PAGE 32
4-8 766238 8/06
PAGE 33
Chapter 5 Contents Exhaust System - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2 Exhaust System - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 Air Cleaner Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6 Air Cleaner Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 34
Exhaust System - 4500 2 3 1 4 6 9 7 7 5 RIGHT SIDE OF SUB-FRAME 5 8 16 7 15 14 10 11 12 13 5-2 766238 8/06
PAGE 35
Exhaust System - 4500 INDEX NO. SERVICE PARTNO. MFG. PART NO. 1 715003 715003 1 EXHAUST TUBE 2 714725 714725 2 NUT M8X1.25 HEX QTY. 3 714774 714774 1 EXHAUST PIPE FLANGE 4 714816 714816 1 GASKET 5 721167 721167 1 U-BOLT 1.50 6 721563 721563 1 CLAMP SADDLE 7 076547 076547 4 FW .344 X .688 X .065 SAE ZN 8 031989 031989 1 MUFFLER 9 036236 036236 1 CS .312-18 X 1.00 HX G5 ZN 10 017004 017004 1 LW .312 MEDIUM SPRING ZN NT .
PAGE 36
Exhaust System - 4600 2 3 EXISTING GASKET 1 7 4 1 5 6 12 8 9 10 10 8 RIGHT SIDE OF SUB-FRAME 11 17 16 15 10 3 7 13 14 5-4 766238 8/06
PAGE 37
Exhaust System - 4600 INDEXN O. SERVICE PART NO. MFG. PART NO. 1 383562 383562 1 EXHAUST TUBE 2 004317 004317 4 CS M 8-1.25X25 G10.9 HEX FL ZN 3 017004 017004 5 LW .312 MEDIUM SPRING ZN 4 034280 034280 1 CS .312-18 X .750 HX G5 ZN 5 392498 392498 1 CLAMP STRAP 6 043661 043661 1 CUSHIONED TUBE CLAMP 7 034272 034272 2 NT .312-18 HX G5 ZN QTY. 8 721167 721167 1 U-BOLT 1.50 9 721563 721563 1 CLAMP SADDLE 10 076547 076547 4 FW .344 X .688 X .
PAGE 38
Air Cleaner Assembly - 4500 4 1 2 5 1 3 6 10 8 9 11 7 19 12 20 13 14 15 16 17 18 5-6 766238 8/06
PAGE 39
Air Cleaner Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 025544 025544 1 2 715029 715029 1 AIR CLEANER HOSE 3 057661 057661 1 HOSE CLAMP 4 775353 775353 1 ENGINE CENTRIFICAL PRECLEANER 5 021758 021758 1 SERVICE INDICATOR 6 715573 715573 1 AIR CLEANER ASSEMBLY (INCLUDES ITEMS 12-18) 7 721894 721894 2 MOUNTING BANDS 8 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 9 070664 070664 4 FW .344 X .750 X .060 ZN 10 017004 017004 4 LW .
PAGE 40
Air Cleaner Assembly - 4600 3 1 2 1 4 1 5 10 9 8 7 6 11 12 13 14 15 16 5-8 17 766238 8/06
PAGE 41
Air Cleaner Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 057661 057661 2 HOSE CLAMP 2 031831 031831 1 AIR CLEANER HOSE 3 775353 775353 1 ENGINE CENTRIFICAL PRECLEANER 4 021758 021758 1 SERVICE INDICATOR 5 032045 032045 1 AIR CLEANER ASSEMBLY (INCLUDES ITEMS 11-17) 6 721894 721894 2 MOUNTING BANDS 7 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 8 070664 070664 4 FW .344 X .750 X .060 ZN 9 017004 017004 4 LW .
PAGE 42
5-10 766238 8/06
PAGE 43
Chapter 6 Contents Brake Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2 Tail Wheel Installation - 4500 & 4600 . . . . . . . . . . . . . . . . . . . . . . . . 6-4 Tail Wheel Breakdown - 747782 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 44
Brake Assembly 1 2 USE EXISTING HARDWARE 4 7 5 USE EXISTING HARDWARE 3 6 4 12 10 16 15 9 17 11 13 8 23 7 19 14 1 See Detail A 6 25 16 18 20 21 22 3 5 24 2 26 .
PAGE 45
Brake Assembly INDEX NO. SERVICE PART NO. MFG. PART NO. 1 383687 383687 1 LEVER AND CABLE ASSEMBLY 2 072405 N/A 1 BRAKE HANDLE LEVER ASSEMBLY 3 072389 N/A 1 RIGHT BRAKE CABLE ASSEMBLY 4 032052 N/A 1 LEFT BRAKE CABLE ASSEMBLY 5 060889 060889 3 PLASTIC STRAP 6 061812 061812 8 CS .50-13 X 3.
PAGE 46
Tail Wheel Installation - 4500 & 4600 3 5 4 6 2 1 11 12 10 13 9 7 14 See Detail A 15 8 4 7 14 2 20 19 16 17 3 19 18 45° ROD HOOK 9 1 21 10 Turn item 10, grease zerk, as shown so rod hook will not interfere with use of grease gun.
PAGE 47
Tail Wheel Installation - 4500 & 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 2 3 4 5 6 052860 017012 049346 385831 036244 706168 523001 082180 018747 508788 015511 016527 017046 344267 077123 387035 082966 521989 041475 025296 061101 747782 052860 017012 049346 385831 036244 706168 468934 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 041475 025296 061101 747782 2 2 2 1 1 1 1 A/R 2 1 1 2 2 2 4 2 2 2 2 4 2 2 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 DESCRIPTION CS .375-16 X 1.250 HX G5 ZN LW .
PAGE 48
Tail Wheel Breakdown - 747782 1 2 1 3 4 1 6 6-6 5 766238 8/06
PAGE 49
Tail Wheel Breakdown - 747782 ITEM NO. SERVICE PART NO. MFG. PART NO. 1 039677 N/A 2 WHEEL BEARING 2 747741 N/A 1 13 X 6.50 TIRE 3 747832 N/A 1 6 X 4.5 WHEEL 4 782771 N/A 1 BEARING SPACER 5 019521 N/A 1 TIRE VALVE 6 015511 N/A 1 GREASE FITTING 45° QTY DESCRIPTION NOTES: 1. Inflate tire to 8-12 psi.
PAGE 50
6-8 766238 8/06
PAGE 51
Chapter 7 Contents Steering Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2 Neutral Lock Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4 Clutch Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 52
Steering Controls 3 2 2 13 14 8 4 15 9 1 10 18 12 11 5 17 10 8 5 6 16 17 33 35 7 33 7 41 46 43 44 40 27 32 41 24 28 21 19 36 38 29 FWD 41 38 1 45 21 39 38 41 31 20 47 41 43 31 37 21 42 32 33 7 25 31 34 31 26 7 40 30 7 20 33 35 30 38 21 45 44 1 39 3.59 ± .
PAGE 53
Steering Controls 1. 2. 3. 4. 5. INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 54
Neutral Lock Assembly 3 4 5 1 3 6 2 4 5 10 8 7 2 8 7 1 11 12 9 8 9 8 7-4 766238 8/06
PAGE 55
Neutral Lock Assembly INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 467811 467811 1 2 467787 467787 1 ADJUSTMENT PLATE 3 055947 055947 3 CS .25-20 X .50 HX G5 ZN 4 017038 017038 3 LW .250 MEDIUM SPRING ZN 5 025403 025403 3 FW .281 X .625 X .062 ZN 6 083766 083766 1 GRIP 7 056077 056077 4 CS .25-20 X 1.00 HX G5 ZN 8 017079 017079 8 FW .250 X .560 X .040 SAE ZN 9 715748 715748 4 NT .
PAGE 56
Clutch Assembly 10 3 1 4 17 16 2 2 5 8 6 7 9 5 14 13 11 16 12 15 1 27 26 25 18 19 21 3 22 23 24 30 20 29 32 24 28 4 36 33 31 34 4 35 13 7-6 766238 8/06
PAGE 57
Clutch Assembly INDEX NO. 1. 2. 3. 4. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 387027 387027 1 CLUTCH LINKAGE 2 384826 384826 1 CLUTCH MOUNT 3 072611 072611 1 FW .406 X .812 X .065 BO 4 017251 017251 2 CP .156D X 1.00 LG HML ZN 5 064014 064014 2 CS .312-18 X .875 HX G5 ZN 6 017004 017004 2 LW .312 MEDIUM SPRING ZN 7 049346 049346 2 FW .375 X .870 X .
PAGE 58
7-8 766238 8/06
PAGE 59
Chapter 8 Contents Mechanical Throttle Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . 8-2 Electronic Throttle Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . 8-4 Throttle Control Cable - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6 Choke Control Cable Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . 8-8 Carburetor Assembly - Mechanical Throttle . . . . . . . . . . . . . . . . . . 8-10 Carburetor Installation - Electronic Throttle . . .
PAGE 60
Mechanical Throttle Assembly - 4500 2 3 5 4 1 6 3 2 28 29 5 30 8 1 9 7 13 14 1 10 17 19 26 25 11 12 14 15 19 16 20 17 1 15 27 18 15 14 PART OF MECHANICAL GOVERNOR 13 22 24 2 23 11 21 7 FULL THROTTLE POSITION 10 16 IDLE POSITION ASSEMBLED DETAIL 8-2 766238 8/06
PAGE 61
Mechanical Throttle Assembly - 4500 MFG. PART NO. 3 INDEX NO. SERVICE PART NO. 1 012054 N/A 1 BALL JOINT ASSEMBLY 2 044255 N/A 3 NT #10-32 HX ZN 3 448365 N/A 1 CONNECTING LINK 4 039685 N/A 1 BALL JOINT CONNECTION 5 056077 056077 3 CS .25-20 X 1.00 HX G5 ZN 6 038273 038273 1 MECHANICAL GOVERNOR 7 388694 388694 1 ADJUSTMENT BRACKET 8 068551 068551 1 NT .25-20 HX NL ZN FW .281 X .625 X .098 ZN QTY.
PAGE 62
Electronic Throttle Assembly - 4500 2 2 1 3 8 2 1 1 4 5 1 6 7 6 FOOTREST 8-4 766238 8/06
PAGE 63
Electronic Throttle Assembly - 4500 MFG. PART NO. 2 INDEX NO. SERVICE PART NO. 1 029710 029710 7 CS .312-18 X .750 HXFLK ZNYC 2 787051 787051 1 4500 THROTTLE CONTROL SWITCH 3 379396 379396 1 4500 CONTROL CAP 4 026237 N/A 2 RELAY 5 059832 059832 2 NT #10-24 HX NL ZN QTY. DESCRIPTION 6 N/A 808485 7 NUTSERT, 5/16-18 THREAD 7 368787 368787 1 CONTROL SWITCH MOUNT BRACKET 8 786939 786939 1 4500 ELECTRONIC GOV THROTTLE DECAL NOTES: 1.
PAGE 64
Throttle Control Cable - 4600 1 6 5 3 2 1 4 10 8 9 5 7 1 8-6 766238 8/06
PAGE 65
Throttle Control Cable - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 714998 714998 3 2 035691 035691 2 FW .210 X .50 X .046 ZN 3 056333 056333 1 KNOB 4 742437 742437 1 THROTTLE CONTROL ASSEMBLY 5 056176 056176 3 LW #10 MEDIUM SPRING ZN 6 035626 035626 2 NT 10-24 HX ZN 7 043661 043661 1 CLAMP 8 497446 497446 1 THROTTLE MOUNT PLATE DESCRIPTION MS 10-24 X .625 HX ZN 9 011841 011841 1 CONDUIT CLIP 10 497438 497438 1 THROTTLE LINK NOTES: 1.
PAGE 66
Choke Control Cable Assembly - 4500 See Detail A 7 4 8 1 2 11 8 3 10 5 6 9 1 REMOVE EXCESS ADHESIVE FROM LEVER AFTER KNOB IS INSTALLED .750 INSTALLED 1 APPLY ADHESIVE TO BOTH SIDES OF THIS AREA 9 .620 APPROX.
PAGE 67
Choke Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 083535 083535 1 KNOB 2 714998 714998 2 MS 10-24 X .625 HX ZN 3 035691 035691 2 FW .210 X .50 X .046 ZN 4 291765 291765 1 LEVER MOUNT BRACKET 5 056176 056176 2 LW #10 MEDIUM SPRING ZN 6 035626 035626 2 NT 10-24 HX ZN 7 715748 715748 1 NT .25-20 FLX LK 8 058081 058081 3 FW .250 X .750 X .10 NY 9 291542 291542 1 CHOKE LEVER 10 056077 056077 1 CS .25-20 X 1.
PAGE 68
Carburetor Assembly - Mechanical Throttle 5 6 2 3 4 7 5 9 1 3 8 3 4 10 2 4 11 2 18 15 19 14 6 4 12 1 13 See Detail A 17 16 LINE FROM FUEL PUMP INTAKE MANIFOLD Figure 1 INCORRECT Figure 2 CORRECT 4 Detail A 8-10 766238 8/06
PAGE 69
Carburetor Assembly - Mechanical Throttle INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. N/A 1 CARBURETOR (FACET) 2 710285 710285 2 CHOKE ROD SEAL 3 035691 035691 2 FW .210 X .50 X .046 ZN 4 056176 056176 4 LW #10 MEDIUM SPRING ZN 5 715581 715581 1 NT 8-36 HX ZN 6 714998 714998 2 MS 10-24 X .
PAGE 70
Carburetor Connections- Electronic Throttle 1 1 PART OF CARBURETOR 2 3 4 7 5 6 5 ENGINE HARNESS 786749 REAR WIRING HARNESS 751743 8-12 ENGINE HARNESS 786749 766238 8/06
PAGE 71
Carburetor Connections - Electric Throttle INDEX NO. SERVICE PART NO. MFG. PART NO. 1 038422 038422 1 CHOKE WIRE ASSEMBLY 2 714998 714998 1 MS #10-24 X .625 HX ZN CONDUIT CLIP QTY. DESCRIPTION 3 011841 011841 1 4 035691 035691 1 FW .210 X .500 X .046 ZNYC 5 056176 056176 2 LW #10 MED SPRING ZNYC 6 035626 035626 1 NT #10-24 HX ZN 7 044255 044255 1 NT #10-32 HX ZN NOTES: 1. Used on tractors with serial numbers 02034020 and higher.
PAGE 72
8-14 766238 8/06
PAGE 73
Chapter 9 Contents Front Engine Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 Front Engine Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-4 Rear Engine Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-6 Rear Engine Assembly (Mechanical Governor) - 4500 . . . . . . . . . . . 9-8 Rear Engine Assembly (Electronic Governor) - 4500 . . . . . . . . . . .
PAGE 74
Front Engine Assembly - 4600 11 10 9 7 6 7 7 12 7 21 4 8 1 22 23 7 3 4 24 19 5 20 5 15 30 2 8 26 6 16 1 29 25 14 2 9 17 3 18 28 27 3 13 9-2 766238 8/06
PAGE 75
Front Engine Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 056325 056325 1 2 299479 299479 1 DRIVE SHAFT HANGER 3 017038 017038 3 LW .250 MEDIUM SPRING ZN 4 024927 024927 1 NT .25-20 HX G5 ZN 5 089755 089755 1 HOSE .625 O.D. X .375 I.D. X 1.65” 6 017921 017921 1 NT .312-18 HX ZN 7 017004 017004 5 LW .312 MEDIUM SPRING ZN 8 064345 064345 1 CS .312-18 X 2.00 HX ZN 9 030692 030692 1 DRIVE SHAFT, P.T.O.
PAGE 76
Front Engine Assembly - 4500 11 10 9 7 6 7 7 12 8 1 7 21 1 7 22 3 4 19 6 14 5 24 27 28 29 3 23 20 2 25 2 15 16 5 17 3 26 4 18 13 9-4 766238 8/06
PAGE 77
Front Engine Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 056325 056325 1 CS .25-20 X 1.00 ZN 2 299479 299479 1 HANGER 3 017038 017038 3 LW .250 MEDIUM SPRING ZN 4 024927 024927 1 NT .25-20 HX G5 ZN 5 089755 089755 1 HOSE .625 O.D X .375 I.D. X 1.65” 6 017921 017921 1 NT .312-18 HX ZN 7 017004 017004 5 LW .312 MEDIUM SPRING ZN 8 016337 016337 1 CS .312-18 X 2.50 HX ZN 9 030692 030692 1 DRIVE SHAFT, P.T.O.
PAGE 78
Rear Engine Assembly - 4600 2 1 3 31 30 29 1 28 7 14 9 15 8 5 4 5 27 6 6 Speed Control Lever on Injector Pump 26 12 21 20 11 23 25 24 13 22 10 14 18 19 9-6 17 16 766238 8/06
PAGE 79
Rear Engine Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. 1 756304 756304 1 KUBOTA ENGINE, V-1505 2 758888 N/A 1 FAN BELT 3 757419 757419 1 WATER TEMPERATURE SWITCH 4 497412 497412 1 ENGINE MOUNT LH 5 035238 035238 17 LW .437 MEDIUM SPRING ZN 6 038638 038638 17 CS M10-1.25 X 25 HX G8 BO 7 032706 032706 1 FUEL FILTER ASSEMBLY 8 042341 N/A 1 FUEL FILTER ELEMENT 9 016287 016287 2 CS .312-18X1.
PAGE 80
Rear Engine Assembly (Mechanical Governor) - 4500 12 2 1 4 7 23 22 9 21 32 47 11 Hardware Supplied by Vendor 30 11 15 20 18 37 40 42 13 16 28 43 3 44 39 See Detail A 36 8 41 7 12 25 5 46 4 37 14 1 9 8 19 10 2 33 3 31 8 34 35 6 6 5 10 29 8 Use Existing Hardware 45 7 38 27 8 24 26 7 16 17 Hardware Supplied by Vendor 4.45 (REF) .70 1.125 .
PAGE 81
Rear Engine Assembly (Mechanical Governor) - 4500 766238 8/06 INDEX NO. SERVICEPA RT NO. MFG. PART NO. 1 753574 N/A 1 ALTERNATOR ASSEMBLY 2 753582 N/A 1 ALTERNATOR PULLEY 3 070656 N/A 1 CS .375-16 X 1.00 HX G8 ZN 4 753616 N/A 1 ALTERNATOR ADJUSTMENT ARM 5 017004 N/A 1 LW .312 MEDIUM SPRING ZN 6 028035 N/A 1 CS M8-1.25 X 20 HX G8 ZN 7 013730 N/A 9 CS M10-1.50 X 40 HX G8 ZN 8 035238 N/A 11 LW .
PAGE 82
Rear Engine Assembly (Mechanical Governor) - 4500 NOTES: 1. Torque to 6-9 ft. lbs. 2. Torque to 14-21 ft. lbs. 3. Torque to 74-88 ft. lbs. 4. Tension belt to 79-124 lbs. 5. Tension belt to 75 lbs. 6. Assemble item 34, bowed fan retaining strap, with one item 35, capscrew, to center hole in item 31, water pump pulley. Position bowed strap ends against fan hub face & over unused holes in fan hub. 7. Spark plug wires (not shown) to be routed to clear governor & throttle linkage. 8. .010-.
PAGE 83
This page intentionally left blank.
PAGE 84
Rear Engine Assembly (Electronic Governor)- 4500 11 2 1 4 10 7 23 22 7 19 21 34 35 2 33 3 31 32 1 4 9 38 Hardware Supplied by Vendor 6 9 8 30 11 14 8 5 6 5 15 20 18 12 41 3 13 16 8 25 28 Use Existing Hardware 37 29 40 27 39 8 7 36 8 24 26 7 16 17 Hardware Supplied by Vendor 9-12 766238 8/06
PAGE 85
Rear Engine Assembly (Electronic Governor) - 4500 766238 8/06 INDEX NO. SERVICEPA RT NO. MFG. PART NO. 1 753574 N/A 1 ALTERNATOR ASSEMBLY 2 753582 N/A 1 ALTERNATOR PULLEY 3 070656 N/A 1 CS .375-16 X 1.00 HX G8 ZN 4 753616 N/A 1 ALTERNATOR ADJUSTMENT ARM 5 017004 N/A 1 LW .312 MEDIUM SPRING ZN 6 028035 N/A 1 CS M8-1.25 X 20 HX G8 ZN 7 013730 N/A 9 CS M10-1.50 X 40 HX G8 ZN 8 035238 N/A 11 LW .
PAGE 86
Rear Engine Assembly (Electronic Governor) - 4500 NOTES: 1. Torque to 6-9 ft. lbs. 2. Torque to 14-21 ft. lbs. 3. Torque to 74-88 ft. lbs. 4. Tension belt to 79-124 lbs. 5. Assemble item 34, bowed fan retaining strap, with one item 35, capscrew, to center hole in item 31, water pump pulley. Position bowed strap ends against fan hub face & over unused holes in fan hub. 6. .010-.050 clearance between tip of flywheel tooth to root of starter pinion tooth. 7.
PAGE 87
Chapter 10 Contents Cooling System - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-2 Cooling System - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 88
Cooling System - 4500 1 AIR SCOOP ANGLE SUPPORT 55 56 2 18 47 23 19 19 38 5 4 2 15 See Detail B 40 18 39 33 42 36 29 19 32 41 35 7 58 See Detail D 8 54 6 10 3 19 24 13 20 18 44 45 43 20 30 32 48 19 18 25 47 46 51 48 50 49 48 See Detail E 21 8 18 17 27 48 52 28 14 26 18 19 8 22 19 53 49 See Detail C 11 12 37 8 16 8 9 34 1 46 FORD CONTROL MODULE 57 23 3 23 20 29 See Detail A 31 2 10-2 766238 8/06
PAGE 89
Cooling System - 4500 6 7 7 7 7 766238 8/06 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 90
Cooling System - 4500 .62 +- .12 UP 22 Clamp must be in this position before tightening (this clamp only) Detail B FAN LOCATION IN SHROUD Detail A 6 36 17 .250 (typ) 37 37 2 54 36 SHROUD SEAL LOCATION Adhesive side to tank, tuck ends between corner gusset & core. Detail D Detail C 49 2.0 +- .12 4 5 1.50 +-.
PAGE 91
Cooling System - 4500 NOTES: 1. Attach item 5, overflow hose, from bottom of bottle to radiator overflow port located on filler neck. 2. Use 3M™ Scotch Grip™ 1300 adhesive or equivalent to install seals. Follow vendor’s instructions carefully for proper application of adhesive. 3. Use existing fasteners. 4. With item 49, water bypass hose, rotated to approximate position shown, cut hose 1.50” from outside radius (as shown). 5. Measure 2.00” additional, cut again & discard this section of hose.
PAGE 92
Cooling System - 4600 34 1 2 5 1 34 4 3 33 AIR SCOOP ANGLE SUPPORT 31 7 6 30 See Detail C 18 31 19 8 18 See Detail B 32 11 33 34 35 19 4 10 9 36 37 See Detail D 27 14 39 12 15 19 28 20 5 10 9 16 21 38 18 28 17 13 See Detail A 3 18 19 20 24 26 23 17 25 10-6 766238 8/06
PAGE 93
Cooling System - 4600 2 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 94
Cooling System - 4600 .50 +- .12 UP Clamp must be in this postion before tightening (this clamp only) Detail B FAN LOCATION IN SHROUD Detail A 6 14 13 .250 (typ) 9 9 3 14 8 Adhesive side to tank, tuck ends between corner gusset & core.
PAGE 95
Chapter 11 Contents Oil Cooler Assembly - 4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-2 Oil Cooler Assembly - 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 96
Oil Cooler Assembly - 4500 2 1 1 1 4 3 6 7 8 7 9 3 11 12 13 10 3 5 14 17 18 15 16 2 2 2 To L/H Rear Tractor Frame 11-2 766238 8/06
PAGE 97
Oil Cooler Assembly - 4500 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 98
Oil Cooler Assembly - 4600 2 1 1 1 4 3 6 7 8 7 9 3 11 12 13 10 3 5 2 15 17 16 2 19 20 2 18 14 17 2 2 To L/H Rear Tractor Frame 11-4 766238 8/06
PAGE 99
Oil Cooler Assembly - 4600 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 100
11-6 766238 8/06
PAGE 101
Chapter 12 Contents Hydraulic System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-2 Valve & Cylinder Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-6 Hydraulic Hose & Fuel Line Routing - 4500. . . . . . . . . . . . . . . . . . . 12-8 Hydraulic Hose & Fuel Line Routing - 4600. . . . . . . . . . . . . . . . . .
PAGE 102
Hydraulic System To right side of oil cooler 28 4 10 To directional control valve 9 3 2 See Detail A 1 5 29 10 30 Return from left side of oil cooler 10 45 12 12 12 26 34 10 6 7 12 8 11 45° 13 28 23 35 32 20° 25 33 36 38 20 31 10 17 19 18 25 15 39 14 See Detail C 29 23 See Detail E 14 37 27 22 16 13 21 11 27 Wire harness from engine See Detail B From directional control valve 26 2 23 11 41 42 L/H WHEEL MOTOR 43 40 5 See Detail D ENGINE SUBFRAME 24 R
PAGE 103
Hydraulic System INDEX NO. SERVICE PART NO. 1 712182 712182 1 HYDRAULIC PUMP ASSEMBLY 2 067918 067918 2 NT .50-13 HX G8 ZN 3 017046 017046 2 LW .50 MEDIUM SPRING ZN 4 017137 017137 2 FW .560 X 1.370 X .109 SAE ZN 5 054502 054502 2 NT .375-16 HX G5 ZN 6 017012 017012 2 LW .375 MEDIUM SPRING ZN 7 073858 073858 2 FW .406 X .750X .250 ZN 8 016410 016410 2 CS .375-16 X 2.00 HX G5 ZN HOSE .50 I.D. 21.50” QTY.
PAGE 104
Hydraulic System 44 10 3 20° 14 FITTING POSITION Detail A Detail B Rotate approximately 20° as shown GASKET 26 4 26 23 16 11 11 Detail C Detail D 1.50 +- .25 .50 +- .
PAGE 105
Hydraulic System NOTES: 1. Use Loctite® Pipe Sealant 592 (005488) on the threads of all pipe fittings. 2. Bottom of reservoir must rest on supports of sub-frame. 3. Remove bolt that holds lift bracket and replace bracket with one item 44, flat washer. 4. Place a thin layer of oil on element gasket before assembly. Install as shown. Tighten element 3/4 turn after initial gasket contact. 5. Use Loctite® 545 (this fitting only). 6. Used on tractors with serial number prior to 04014000.
PAGE 106
Valve & Cylinder Assembly 1 3 2 2 Footrest Assembly 10 1 8 13 12 9 7 4 See Detail A 5 5 35 6 11 19 6 11 38 20 14 Footrest Assembly 39 23 32 34 19 26 24 16 15 17 20 28 36 20 33 25 40 15 37 Main Frame Assembly 27 18 21 27 31 30 8 22 5 29 Port F Port B 6 15° Port B Port D Port D Port E 15° Port F Port E Port A Port C Port A Rotate up 10° 10° Port C Rotate fittings approximately as shown FITTING INDEX DETAIL Detail A 12-6 766238 8/06
PAGE 107
Valve & Cylinder Assembly INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 714600 714600 1 2 076547 076547 2 FW .344 X .688 X .065 ZN 3 714618 714618 1 CS .312-18 X 4.00 HX G5 ZN 4 034934 034934 1 VALVE ASSEMBLY 5 017004 017004 4 LW .312 MEDIUM SPRING ZN 6 034272 034272 4 NT .312-18 HX G5 ZN 7 714626 714626 1 CS .25-20 X 3.50 HX G5 ZN 8 017038 017038 3 LW .250 MEDIUM SPRING ZN 9 025403 025403 1 FW .281 X .625 X .062 ZN 10 089789 089789 A/R FW .266 X .
PAGE 108
Hydraulic & Fuel Line Routing - 4500 QUICK COUPLERS 21 20 15 9 15 16 19 18 PORT J To charge press.
PAGE 109
Hydraulic & Fuel Line Routing - 4500 PORT A PORT B PORT D 27 CHARGE PRESS. INLET PORT C CASE OUTLET 23 26 Hydraulic Pump Rotated 180° Partial View L/H Side of Engine Detail A Detail B WIRE STRAP (060889) REAR VIEW OF OIL RESERVOIR HYDRAULIC HOSE FUEL LINE HOSE ROUTE TOWARD FRONT OF TRACTOR POSITIVE BATTERY CABLE NEGATIVE BATTERY CABLE Detail C INDEX MFG. NO. PART NO.
PAGE 110
Hydraulic & Fuel Line Routing - 4600 QUICK COUPLERS 15 21 20 9 15 16 To charge press.
PAGE 111
Hydraulic & Fuel Line Routing - 4600 PORT E PORT A PORT B PORT D CHARGE PRESS. INLET PORT C CASE OUTLET Hydraulic Pump Rotated 180° Detail A INDEX NO. 1 2 3 4 5 6 7 8 9 10 766238 8/06 PART NO.
PAGE 112
12-12 766238 8/06
PAGE 113
Chapter 13 Contents Electrical System (Footrest)- 4500 . . . . . . . . . . . . . . . . . . . . . . . . . 13-2 Electrical System (Engine) - 4500 (Mechanical Governor) . . . . . . . 13-6 Electrical System (Engine) - 4500 (Electronic Governor) . . . . . . . 13-10 Electrical System - (Footrest) 4600 . . . . . . . . . . . . . . . . . . . . . . . . 13-14 Electrical System (Engine) 4600 . . . . . . . . . . . . . . . . . . . . . . . . . . 13-18 Electrical Diagram - 4500 (Mechanical Governor . . . . . . . . . . . .
PAGE 114
Electrical System (Footrest) - 4500 2 SERVICE PARTS ONLY 38 3 1 37 12 11 9 { 4 8 39 7 5 40 14 10 6 15 TO SEAT SWITCH 42 13 16 21 17 36 41 19 30 14 6 28 13 18 22 19 20 36 26 24 21 18 9 24 25 8 34 27 35 31 33 7 14 9 28 29 12 32 6 15 1 23 30 13-2 766238 8/06
PAGE 115
Electrical System (Footrest) - 4500 INDEX NO SERVICE PART NO MFG PART NO 1 048959 048959 1 OIL LIGHT ASSEMBLY 2 064220 064220 1 PLUG 3 083493 083493 1 ALTERNATOR LIGHT ASSEMBLY 4 072439 072439 1 HOT LIGHT ASSEMBLY 5 467910 467910 1 ENGINE LIGHT PANEL 6 726802 726802 1 WIRE HARNESS 7 714998 714998 5 MS 10-24 X 625 HX ZN 8 056176 056176 5 LW #10 MEDIUM SPRING ZN 9 035691 035691 7 FW 210 X 50 X 046 ZN 10 026237 026237 1 RELAY QTY DESCRIPTION 11 726745 72
PAGE 116
Electrical System (Footrest) - 4500 18 GA WHITE 18 GA BLUE 18 GA YELLOW 18 GA BLUE CONNECTOR BODY TO DELAY MODULE CONNECTOR BODY TO SEAT SWITCH 18 GA YELLOW 14 GA BROWN 18 GA WHITE 14 GA RED 18 GA BLACK RELAY CONNECTOR WHITE 18 GA BLACK 14 GA BROWN 18 GA ORANGE 14 GA ORANGE 16 GA BLACK HOUR METER 032649 12 GA RED IGNITION SWITCH 083501 13-4 766238 8/06
PAGE 117
Electrical System (Footrest) - 4500 18 GA YELLOW 14 GA YELLOW + POSITIVE TERMINAL INTERMITTENT TONE NEGATIVE TERMINAL 14 GA YELLOW 14 GA RED 14 GA RED 18 GA BLACK NEUTRAL LOCK SWITCH 023002 ELECTRONIC BUZZER 040527 14 GA RED 14 GA ORANGE 18 GA ORANGE 16 GA GREEN 043950 5 AMP FUSE 14 GA YELLOW 16 GA BLUE 16 GA BLUE ELECTRIC CLUTCH SWITCH 057778 LIGHT PANEL 18 GA BROWN 18 GA RED LIGHT PANEL 18 GA BLUE 4 18 GA YELLOW OIL LIGHT 18 GA YELLOW HOT LIGHT 18 GA BROWN PART OF ITEM 6 HARNESS 18 GA
PAGE 118
Electrical System (Engine) - 4500 (Mechanical Governor) 1 6 14 9 7 10 7 11 35 3 2 8 36 12 13 37 15 5 33 16 5 7 11 17 7 18 20 2 19 4 11 23 3 3 21 27 2 ELECTRIC CLUTCH 23 3 21 3 26 2 37 2 29 7 42 31 30 22 25 38 4 39 21 24 4 18 40 38 41 4 34 28 33 13 6 12 32 31 BATTERY 13-6 1 766238 8/06
PAGE 119
Electrical System (Engine) - 4500 (Mechanical Governor) INDEX NO 766238 8/06 SERVICE PART NO MFG PART NO QTY DESCRIPTION 1 N/A N/A 1 ALTERNATOR 2 024927 024927 7 NT 25-20 HX G5 ZN 3 017038 017038 5 LW 250 MEDIUM SPRING ZN 4 751743 751743 1 WIRE HARNESS 5 081117 N/A 1 MARINE STARTER 6 045336 045336 1 NT M8-1 25 HX G8 ZN 7 017004 017004 4 LW 312 MEDIUM SPRING ZN 8 085381 085381 1 STARTER CABLE 9 081158 N/A 1 STARTER RELAY 10 023234 023234 1 FUSE 30 AMP AG
PAGE 120
NOTES: 1. BCI Group 24F battery size model 4500: 12V, 350 CCA. 2. Tie battery cables to hoses & other electrical cables running through hose mount located on left front of engine using item 20, plastic straps Be sure cables & hoses do not interfere with pump pulley, throttle linkage, choke cable or route too close to exhaust manifold or exhaust pipe. 3. Coil excess wire next to front idler mount. 4. End of loom clamped to solenoid mount bolt. 5.
PAGE 121
Electrical System (Engine) - 4500 18 GA ORANGE 12 GA WHITE 39 40 13 33 CUT HOSE AS REQUIRED 2 18 GA WHITE 3 DETAIL OF ALTERNATOR 31 6 8 7 18 GA BLACK 18 GA BLACK 18 GA BROWN 18 GA RED DETAIL OF STARTER 18 10 GA RED LEFT SIDE VIEW OF ENGINE 12 GA WHITE 10 14 GA YELLOW 19 14 13 10 GA BLACK 10 GA RED 11 7 19 18 GA WHITE 23 18 24 4 8 DETAIL OF WIRE CLAMPS 766238 8/06 DETAIL OF STARTER RELAY 13-9
PAGE 122
Electrical System (Engine) - 4500 (Electronic Governor) 1 6 14 9 7 10 7 11 2 8 33 3 5 31 16 4 7 11 23 21 2 27 ELECTRIC CLUTCH 23 3 3 21 26 35 39 30 22 25 2 37 21 24 4 3 3 36 4 18 20 2 19 7 11 6 35 15 17 18 5 12 13 34 2 28 29 7 38 36 39 4 32 12 BATTERY 13-10 1 766238 8/06
PAGE 123
Electrical System (Engine) - 4500 (Electronic Governor) INDEX NO 766238 8/06 SERVICE PART NO MFG PART NO QTY DESCRIPTION 1 N/A N/A 1 ALTERNATOR 2 024927 024927 7 NT 25-20 HX G5 ZN 3 017038 017038 5 LW 250 MEDIUM SPRING ZN 4 751743 751743 1 WIRE HARNESS 5 081117 N/A 1 MARINE STARTER 6 045336 045336 1 NT M8-1 25 HX G8 ZN 7 017004 017004 4 LW 312 MEDIUM SPRING ZN 8 085381 085381 1 STARTER CABLE 9 081158 N/A 1 STARTER RELAY 10 023234 023234 1 FUSE 30 AMP AG
PAGE 124
NOTES: 1. BCI Group 24F battery size model 4500: 12V, 350 CCA. 2. Tie battery cables to hoses & other electrical cables running through hose mount located on left front of engine using item 20, plastic straps Be sure cables & hoses do not interfere with pump pulley, throttle linkage, choke cable or route too close to exhaust manifold or exhaust pipe. 3. 4. 5. 6. 7. Coil excess wire next to front idler mount. End of loom clamped to solenoid mount bolt. To Carburetor servo motor.
PAGE 125
This page intentionally left blank.
PAGE 126
Electrical System (Footrest) - 4600 SEE NOTE 4 2 1 40 3 11 10 9 12 { 5 8 41 7 4 13 16 TO SEAT SWITCH 14 6 44 42 43 23 17 18 45 19 20 21 22 21 33 15 15 24 29 25 31 27 26 23 20 19 37 38 7 15 36 34 32 27 9 8 28 30 9 31 35 12 1 33 39 GLOW PLUG TIMER (KUBOTA) 16 6 13-14 766238 8/06
PAGE 127
Electrical System (Footrest) - 4600 INDEX NO 3 2 5 5 5 5 SERVICE PART NO MFG PART NO QTY DESCRIPTION 1 048959 N/A 1 OIL LIGHT ASSEMBLY 2 032516 N/A 1 GLOW PLUG LIGHT ASSEMBLY 3 083493 N/A 1 ALTERNATOR LIGHT ASSEMBLY 4 072439 N/A 1 HOT LIGHT ASSEMBLY 5 467910 N/A 1 ENGINE LIGHT PANEL 6 754960 754960 1 WIRE HARNESS 7 714998 714998 5 MS 10-24 X 625 HX ZN 8 056176 056176 5 LW #10 MEDIUM SPRING ZN 9 035691 035691 7 FW 210 X 50 X 046 ZN 10 026237 026237 1 RE
PAGE 128
3. For tractors with serial prior to 02014008 4. For tractors with serial number prior to 08060000. 5. For tractors with serial numbers 0806000 and higher.
PAGE 129
Electrical System (Footrest) - 4600 18 GA BROWN 18 GA BROWN 18 GA BLUE 18 GA WHITE CONNECTOR BODY TO DELAY MODULE CONNECTOR BODY TO SEAT SWITCH 14 GA ORANGE 14 GA ORANGE 13 18 GA BLUE 14 GA BROWN 18 GA PURPLE 14 GA RED 18 GA PURPLE RELAY CONNECTOR 24 18 GA GREEN 18 GA WHITE 12 GA BROWN 18 GA BLUE 18 GA ORANGE 16 GA BLACK 10 GA RED 10 GA PURPLE HOUR METER 032649 IGNITION SWITCH 034058 766238 8/06 13-17
PAGE 130
Electrical System (Footrest) - 4600 18 GA YELLOW 14 GA YELLOW + POSITIVE TERMINAL INTERMITTENT TONE NEGATIVE TERMINAL 14 GA YELLOW 14 GA RED 18 GA BLACK NEUTRAL LOCK SWITCH 023002 ELECTRONIC BUZZER 040527 14 GA RED 14 GA RED 14 GA ORANGE 16 GA GREEN 043950 5 AMP FUSE 14 GA YELLOW 16 GA BLUE 16 GA BLUE ELECTRIC CLUTCH SWITCH 057778 LIGHT PANEL 18 GA RED 18 GA BROWN 18 GA BLUE LIGHT PANEL 18 GA BROWN 18 GA YELLOW 18 GA PURPLE 18 GA YELLOW HOT LIGHT 18 GA YELLOW 18 GA GREEN PART OF ITEM 6 HA
PAGE 131
This page intentionally left blank.
PAGE 132
Electrical System (Engine) - 4600 2 1 5 ALTERNATOR 6 2 7 FRAME 3 8 4 9 SOLENOID MOUNT BRACKET 14 13 12 16 STARTER GLOW PLUG 15 CLUTCH ANCHOR 12 10 11 OIL PRESSURE SENDER 11 18 13 6 7 23 FUEL SHUT-OFF SOLENOID 8 20 14 11 19 17 ELECTRIC CLUTCH 12 16 FRONT IDLER MOUNT BATTERY 13-20 1 766238 8/06
PAGE 133
Electrical System (Engine) - 4600 INDEX NO SERVICE PART NO MFG PART NO QTY 1 754952 754952 1 WIRE HARNESS 2 012153 012153 1 BATTERY CABLE, 48” RED POSITIVE 3 023234 023234 1 FUSE 30 AMP AGC 4 757419 757419 1 WATER TEMPERATURE SWITCH 5 034280 034280 1 CS 312-18 X 750 HX G5 ZN 6 076547 076547 2 FW 344 X 688 X 065 SAE ZN 7 029876 029876 2 LW 312 ZN 8 017004 017004 2 LW 312 MEDIUM SPRING ZN 9 034272 034272 2 NT 312-18 HX G5 ZN 10 060889 060889 2 PLASTIC STRAP
PAGE 134
Electrical System (Engine) - 4600 10 21 A A PARTIAL RIGHT SIDE VIEW OF ENGINE 21 22 9 VIEW A-A 13-22 766238 8/06
PAGE 135
Electrical System (Engine) - 4600 18 GA GREEN 18 GA GREEN 18 GA PURPLE 18 GA BLUE 18 GA BLACK GLOW PLUG LIGHT CONNECTOR 12 GA WHITE 16 GA PURPLE 18 GA BLUE ALTERNATOR STARTER SOLENOID EXISTING NUT 12 GA BROWN 14 GA YELLOW 12 GA WHITE 10 GA RED 10 GA RED 3 STARTER 766238 8/06 13-23
PAGE 136
Electrical Diagram - 4500 (Mechanical Governor) 726802 18 ORG 726802 14 RED 726802 18 WHT 726802 14 BRN 87A SEAT SWITCH DELAY 726745 726802 18 YEL 87 30 86 85 726802 18 BLK RELAY 026237 726802 18 BLU 726802 18 RED 726802 18 BRN 726802 14 YEL IGNITION SWITCH 083501 A R S B I 726802 18 ORG 726802 12 RED 726802 18 YEL + HOT 726802 18 ORG 726802 18 YEL 726802 18 BLK 726802 18 BLK NC NO NC NO BEEPER 040527 _ ALT INDICATOR PANEL 726802 16 GRN OIL 726802 14 ORG COM COM NEUTRAL LO
PAGE 137
Electrical Diagram - 4500 (Mechanical Governor) L 751743 18 ORG 726802 18 ORG 726802 18 WHT 751743 18 WHT 726802 18 BLU NC NO NC NO SEAT SWITCH 085381 4 RED 751743 10 WHT 30 AMP FUSE 751743 18 BRN VARIABLE RELUCTANCE SENSOR 766220 18 CLR STARTER RELAY 081158 751743 12 RED B+ 751743 10 WHT 751743 18 RED 751743 14 YEL ALTERNATOR 766220 18 BLK ENGINE COOLANT TEMP SENSOR 18 TAN/BLK 766220 18 BRN 012153 4 RED 766220 18 YEL 766220 18 BLK _ HOUR METER 032649 766220 18 RED 085852 RED +
PAGE 138
Electrical Diagram - 4500 (Electronic Governor) 726802 18 ORG 726802 14 RED 87A 30 SEAT SWITCH DELAY 726745 726802 18 YEL 726802 18 WHT 726802 14 BRN 87 86 726802 18 BLK 85 RELAY 026237 726802 18 BLU 726802 18 RED 726802 18 BRN 726802 14 YEL IGNITION SWITCH 083501 R A S I B 726802 18 ORG 726802 12 RED 726802 18 YEL 726802 18 BLK 726802 18 YEL ALT INDICATOR PANEL 726802 16 GRN OIL 726802 18 ORG 726802 14 ORG COM COM NEUTRAL LOCK SWITCH 023002 HOT 726802 18 YEL NC NO NC NO BEEPER
PAGE 139
Electrical Diagram - 4500 (Electronic Governor) 726802 18 ORG 751743 18 ORG L ALTERNATOR 726802 18 WHT 751743 18 WHT 751743 10 WHT B+ TIMING CONNECTOR 726802 18 BLU SEAT SWITCH 786749 18 BLK 751743 18 RED 751743 18 BRN 751743 14 YEL 751743 10 WHT 085381 4 RED STARTER RELAY 081158 30 AMP FUSE 786749 18 BLK 786749 18 BLK/YEL VARIABLE RELUCTANCE SENSOR 786749 18 BLK 786749 ENGINE COOLANT 18 CLR TEMP SENSOR 10 ohm 786749 18 YEL/BLK 751743 12 RED TO MAP SENSOR 786749 18 YEL 012153 4 RED
PAGE 140
Electrical Diagram - 4600 754960 18 BLU 754960 14 RED 8 AMP FUSE 754960 12 BRN 87A 85 86 754952 14 ORG 754952 14 BLK 754960 18 PUR SEAT SWITCH DELAY 726745 754960 18 BLU 87 30 754960 14 ORG RELAY 026237 754960 18 WHT 754960 18 BRN 754960 18 RED 754960 18 BRN 754960 14 YEL 039859 10 BLU 17 30 19 AC 50 754960 18 BLU IGNITION SWITCH 034058 754960 18 YEL NC NO NC NO BEEPER 040527 + 754960 18 BLK 754960 18 YEL _ GLOW PLUG HOT OIL 754960 18 GRN 754960 18 GRN TIMER 754960 18 PUR IN
PAGE 141
Electrical Diagram - 4600 754952 18 BLU 754960 18 BLU L 754952 12 WHT HOLD PULL _ ALTERNATOR 754952 16 PUR 754960 16 PUR SHUT-OFF SOLENOID B IG 754960 18 WHT NC NO 754960 18 BRN SEAT SWITCH 754952 18 RED 754952 18 BRN 754952 14 YEL GLOW PLUGS STARTER 754952 12 BRN 30 AMP FUSE 754952 10 RED WATER OIL PRESS TEMP SENDER SENDER 754952 10 RED 754952 10 PUR 012153 4 RED 754960 18 ORG + _ HOUR METER 032649 754960 18 BLK 085852 4 RED + 754952 10 BLK _ BATTERY ELECTRIC CLUTCH 5 AMP FUS
PAGE 142
13-30 766238 8/06
PAGE 143
Chapter 14 Contents Decal Group. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 144
Decal Group 4600 ENGINE LIGHT PANEL 1 2 .25 A 1.40 A 2 1.32 ~ 5 ~ .25 2 pls 14 3 4 7.0 B B 2.0 13 6 .25 Align decal with front 12 edge of park brake cut out. Decal must be read from seat. 7 Align decal with front edge of slot & inside edge of slot (as shown) Align decal with front 11 edge of slot & inside edge of slot (as shown) 4600 ENGINE 3 LIGHT PANEL .75 1.0 1.0 10 Back edge of fender. .25 8 14 2.0 9 Center on back of tractor.
PAGE 145
Decal Group INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 146
Decal Group 2 1 .75 3.0 3 .50 1.25 .50 .25 Center logo & text side to side 6 5 View A 4 View B 9 Locate plate between clip & oil fill (as shown) readable from right side. Decals centered on tank 1.50 7 8 PARTIAL TOP VIEW OF ENGINE .50 HYDRAULIC OIL RESERVOIR 14 .25 4.50 4.50 .25 16 15 10 13 Center on inside of door 3.0 3.0 7.75 7.75 .50 5.0 5.
PAGE 147
Decal Group INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 727800 727800 1 2 N/A 083279 1 SERIAL NO. PLATE 3 728527 728527 1 DASH DECAL (4500) 728535 728535 1 DASH DECAL (4600) 4 760645 760645 1 4000 OPERATOR’S DECAL 5 727545 727545 1 SWITCH GUARD DECAL 6 741264 741264 1 MADE IN U.S.A.
PAGE 148
14-6 766238 8/06
PAGE 149
Chapter 15 Contents 4500 Engine & Hydraulic Set-Up Procedures (Mech. Gov.) . . . . . . 15-2 4600 Engine & Hydraulic Set-Up Procedures . . . . . . . . . . . . . . . . .
PAGE 150
4500 Engine & Hydraulic Set-Up Procedures-Mechanical Gov LINKAGE ROD C 1/32 LOCKING NUT 1.03 .70 B D A F LOW SPEED STOP SCREW .
PAGE 151
4500 Engine & Hydraulic Set-Up Procedures-Mechanical Gov 4500 ENGINE & HYDRAULIC SET-UP PROCESS IN TEST & ADJUST POSITION Step 1. Check fluid levels. • Engine Oil Capacity: 3 & 1/2 Quarts • Hydraulic System Capacity: 3 & 1/2 Gallons (With 11 ounces of Lubrizol #5178 additive.) • Cooling System Capacity: 3 & 1/4 Gallons of 50-50 Mixture Ethylene Glycol & Water Step 2. Adjusting the Neutral Lock Switch • The neutral lock switch (023002) can be damaged if not properly adjusted.
PAGE 152
.65 inch dimension. d. Put slight tension on governor spring with lever (A) and install throttle rod hardware between governor throttle lever and carburetor lever. Adjust length of linkage rod so that carburetor lever is about 1/32 to 1/16 inch off it’s wide open stop. Tighten locking nuts on linkage rod. e. Release spring tension and operate throttle lever manually to check for any binding in linkage. Make corrections as required. f. Start engine and warm to operating temperature. g.
PAGE 153
• • • • Lock the steering lever into position using front neutral lock (467811) and rear neutral lock (483735). If the wheels rotate, loosen the jam nuts on the turnbuckles. Adjust the turnbuckles until the drive wheels do not rotate either clockwise or counterclockwise. Retighten the turnbuckle jam nuts. Tighten the two front nuts on the threaded rod (766303) making sure the rod does not shift position. Warning: make sure all locking nuts and fasteners are tight on turnbuckles.
PAGE 154
4600 Engine & Hydraulic Set-Up Procedures 4600 ENGINE & HYDRAULIC SET-UP PROCESS IN TEST & ADJUST POSITION Step 1. Check fluid levels. • Engine Oil Capacity: 5 Quarts • Hydraulic System Capacity: 3 & 1/2 Gallons • Cooling System Capacity: 2 & 3/4 Gallons of 50-50 mixture ethylene glycol & water Step 2. Adjusting the neutral lock switch • The neutral lock switch (023002) can be damaged if not properly adjusted. To insure proper adjustment, put the front neutral lock (467811) in the down position.
PAGE 155
Chapter 16 Contents Hydraulic Pump Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-2 Wheel Motor Breakdown - 007914 . . . . . . . . . . . . . . . . . . . . . . . . . 16-4 Wheel Motor Breakdown - 792341 . . . . . . . . . . . . . . . . . . . . . . . . . 16-6 Electric Clutch Breakdown. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 156
Hydraulic Pump 5 6 * 4 3 1 10 16 2 12 * 17 * 13 20 14 23 19 15 7 18 24 8 21 25 15 14 28 27 * 13 12 * 26 21 22 11 9 20 30 31 * 32 * 32 * 31 10 30 16 13 12 * * 48 14 15 33 34 * 33 35 35 41 20 39 40 * 37 38 36 1 46 21 45 34 35 28 43 35 29 17 * 47 10 34 22 * 14 13 32 * 34 32 * 33 30 33 30 31 * 31 * 27 12 * 11 18 44 10 15 42 20 23 25 50 49 24 16-2 * 722744 - Seal Kit 766238 8/06
PAGE 157
Hydraulic Pump INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 158
Wheel Motor Breakdown - 007914 1 2 3 4 5 6 7 8 7 9 10 11 12 15 13 13 14 13 17 13 16 13 18 19 20 ADDITIONAL PARTS AVAILABLE FROM YOUR DEALER: Rebuilt Wheel Motor - Excel Part Number 708826 Seal Kit - Excel Part Number 708859 16-4 766238 8/06
PAGE 159
Wheel Motor Breakdown - 007914 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY.
PAGE 160
Wheel Motor Breakdown - 792341 1 2 3 4 5 6 7 9 8 9 10 11 12 13 16 14 14 15 14 18 14 17 14 20 19 21 ADDITIONAL PARTS AVAILABLE FROM YOUR DEALER: Seal Kit - Excel Part Number 792572 16-6 766238 8/06
PAGE 161
Wheel Motor Breakdown - 792341 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 706192 N/A 1 NUT 2 792515 N/A 1 DIRT & WATER SEAL * 3 792465 N/A 1 OUTER BEARING 4 792523 N/A 1 SERVICE HOUSING ASSY 5 792549 N/A 1 6 792531 N/A 7 792598 N/A 1 SHAFT SEAL (40 MM DIA.
PAGE 162
Electric Clutch Breakdown 6 5 4 1 3 2 1 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 027243 N/A 1 ARMATURE ASSEMBLY 2 027433 N/A 1 DOUBLE ROLL BEARING 3 027458 N/A 1 ROTOR SHIM 4 027250 N/A 1 ROTOR 5 027268 N/A 1 CLUTCH COIL 6 027441 N/A 1 SINGLE ROLL BEARING NOTES: 1. Air gap should be .012 to .024.
PAGE 163
Chapter 17 Contents Seat Kit 306878K. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17-2 Seat Kit 306860K. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17-3 Seat Kit 306894K. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17-4 Seat Kit 311217K . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17-5 Hood Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 164
Seat Kit 306878K 8 7 10 9 1 6 2 3 3 4 SEAT MOUNT 5 3 4 5 INDEX NO. SERVIC PART NO. MFG PART NO. 1 762914 762914 1 DELUXE SEAT 2 762948 762948 2 SPRING 3 076547 076547 12 FW .344 X .688 X .065 SAE ZN 4 017004 017004 8 LW .312 MEDIUM SPRING ZN 5 034272 034272 8 NT .312-18 HX G5 ZN 6 036236 036236 4 CS .312-18 X 1.00 HX G5 ZN 7 764472 764472 1 BACK ASSEMBLY 8 764480 764480 1 ARM REST SET BOTTOM CUSHION QTY.
PAGE 165
Seat Kit 306860K 7 8 9 1 6 2 3 3 4 SEAT MOUNT 5 3 4 5 INDEX NO. SERVICE PART NO. MFG. PART NO. 1 762898 762898 1 STANDARD SEAT 2 762948 762948 2 SPRING 3 076547 076547 12 FW .344 X .688 X .065 SAE ZN 4 017004 017004 8 LW .312 MEDIUM SPRING ZN 5 034272 034272 8 NT .312-18 HX G5 ZN 6 036236 036236 4 CS .312-18 X 1.
PAGE 166
Seat Kit 306894K 8 1 7 10 9 6 11 3 12 2 SEAT MOUNT 3 1 4 1 5 1 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 762914 762914 1 2 762930 762930 2 SUSPENSION 3 076547 076547 12 FW .344 X .688 X .065 SAE ZN 4 017004 017004 8 LW .312 MEDIUM SPRING ZN 5 034272 034272 8 NT .312-18 HX G5 ZN 6 036236 036236 4 CS .312-18 X 1.
PAGE 167
Seat Kit 311217K 8 7 1 9 10 6 11 3 2 SEAT MOUNT 3 1 4 1 5 1 INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. 1 762898 762898 1 2 762930 762930 2 SUSPENSION 3 076547 076547 12 FW .344 X .688 X .065 SAE ZN 4 017004 017004 8 LW .312 MEDIUM SPRING ZN 5 034272 034272 8 NT .312-18 HX G5 ZN 6 036236 036236 4 CS .312-18 X 1.
PAGE 168
Hood Kit 318915K 1 26 17 16 6 18 19 25 2 3 24 9 21 4 23 20 8 29 22 5 2 10 2 11 12 27 18 19 13 28 2 7 15 See Detail A 1 14 See Detail B Main Frame 14 14 15 14 Detail A 1 Detail B 17-6 766238 8/06
PAGE 169
Hood Kit 318915K INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION 1 386011 386011 1 HOOD 2 033936 033936 4 SC .25-20 X .50 HWH STP ZN 3 072041 072041 1 GROMMET .370 X .870 X .620 X .120 4 387985 387985 1 HOOD ROD 5 017996 017996 1 GROMMET .250 X .50 X .370 X .060 6 038968 038968 1 PLASTIC CLIP 7 499145 499145 1 REAR SCREEN 8 392647 392647 1 CENTER SCREEN RIVET .125 .062-.
PAGE 170
Air Scoop Kit 466615 2 1 2 24 19 27 20 2.00 21 6 5 26 24.00 1 4 10 8 14 8 11 25 20 12 3 1 22 10 1 9 10.00 3 23 7 9.
PAGE 171
Air Scoop Kit 466615 INDEX NO. 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 SERVICE PART NO. MFG. PART NO. QTY. 1 442731 442731 1 AIR SCOOP 2 727610 727610 1 LOGO DECAL 3 760173 760173 2 REAR SCREEN SEAL 4 059519 059519 1 HALF ROUND WEATHER SEAL 1.92’ 5 017657 017657 4 RIVET .125 .062-.125 GRIP 6 028738 028738 2 LATCH CATCH 7 715599 715599 2 CS 10-24 X 1.00 HX G5 ZN 8 017079 017079 3 FW .250 X .560 X .
PAGE 172
Front Tire Options 2 4 2 1 1 3 17-10 766238 8/06
PAGE 173
Front Tire Options INDEX NO. SERVICE PART NO. MFG. PART NO. QTY. DESCRIPTION STANDARD TIRE & WHEEL ASSEMBLY 747956 4 PLY MULTI-TRAC TIRE/WHEEL ASSY 23 X 8.50-12 1 747733 N/A 1 WHEEL 12 X 7.00 2 019521 N/A 1 VALVE STEM 3 024265 N/A 5 WHEEL NUT 4 747378 N/A 1 4 PLY MULTI-TRAC TIRE 23 X 8.50-12 1 WHEEL 12 X 8.50 OPTIONAL TIRE & WHEEL ASSEMBLIES 747964 1 747949 N/A 4 PLY MULTI-TRAC TIRE/WHEEL ASSY 23 X 10.
PAGE 174
17-12 766238 8/06
PAGE 175
Numerical Index Part No. Page No. Part No. Page No. Part No. Page No.
PAGE 176
Part No. 035691 035865 035881 035931 035949 035956 035964 036145 036236 036244 036574 036749 036756 036855 037044 037051 037069 037168 037374 037788 038273 038398 038422 038448 038455 038463 038471 038489 038513 038638 038836 038968 038984 039131 039677 039685 039743 039784 039859 040527 041202 041236 041434 041475 041483 041491 042341 042630 042960 043570 043661 043950 Page No.
PAGE 177
Part No. 074542 074559 075408 076349 076422 076547 076588 076919 076927 076992 077123 077842 077859 078246 079186 079210 080358 080655 080838 081042 081117 081125 081158 081745 081752 082180 082248 082420 082511 082727 082966 083022 083121 083279 083469 083493 083501 083519 083535 083592 083626 083766 084681 084756 084921 085381 085571 085639 085837 085852 089755 089789 778837 8/06 Page No.
PAGE 178
Part No. 442558 442731 442871 443184 447250 447367 447425 447557 447656 447912 448035 448043 448365 448852 450874 455113 459578 460311 460600 460634 462531 466615 467738 467746 467753 467761 467779 467787 467811 467837 467845 467910 468934 474932 474940 476051 483735 496117 496828 496919 497263 497305 497313 497339 497370 497396 497412 497420 497438 497446 497487 498899 499145 506576 Page No.
PAGE 179
Part No. 717629 717637 717645 717652 717660 717678 717686 717694 717702 717728 717736 717744 717769 717777 717785 717801 717819 717827 717835 717843 717850 717868 717876 717884 717892 717918 718247 720177 720219 721167 721563 721589 721894 722678 724724 724732 724740 726745 726802 727008 727016 727032 727040 727164 727545 727578 727586 727602 727610 727735 727784 727792 727800 727818 778837 8/06 Page No.
PAGE 180
Part No. 792457 792465 792473 792481 792499 792507 Page No. 7 7 7 7 7 7 Part No. Page No. 792515 792523 792531 792549 792564 792572 7 7 7 7 7 6, 7 i-6 Part No. 792598 792606 808485 881888 924738 925008 Page No.